- DL manuals
- Calomax
- Boiler
- Cascade-6A
- Installation, Operation And Servicing Instructions
Calomax Cascade-6A Installation, Operation And Servicing Instructions
Summary of Cascade-6A
Page 1
Manuals and documents brought to you by wechillit.Com ltd wci group house 18 pride hill shrewsbury sy1 1dq tel: 01743 289418 fax: 01743 289416 web: www.Wechillit.Com.
Page 2
Model: cascade-6a with power switch installation, operation and servicing instructions calomax limited lupton avenue, leeds ls9 7dd tel. 0113 249 6681 fax. 0113 235 0358 e-mail: service@calomax.Co.Uk www.Calomax.Co.Uk please read these instructions carefully before operating your boiler for the rst ...
Page 3
Page 2 page 3 contents introduction thank you for purchasing a calomax cascade-6a boiler. All our products are designed to give years of simple, reliable operation. To ensure this, it is important that the installation and subsequent servicing is carried out by a suitably quali ed engineer in accord...
Page 4: Installation
Page 4 page 5 location to comply with recommendations from the health and safety executive it is important that due consideration be given to safe operation of the controls of the boiler. The boiler should therefore be mounted in such a manner that the operator can stand directly facing the machine ...
Page 5: User Instructions
Page 6 page 7 electrical connections cascade-6a boilers require xed wiring to the rear terminal block. A means of disconnection must be provided in which at least 3mm separation between the live and neutral poles of the supply exists. ( double pole isolating switch ). The installation of a residual ...
Page 6
Page 8 page 9 cleaning • hold a cup below the tap or place large vessels on the drip tray. Care must be taken to avoid injury through splashing or over- lling. • to begin lling, pull the handle forward or push it backward – hot water begins to ow. If the tap is opened fully it can be locked open (fo...
Page 7: Service Instructions
Page 10 page 11 kr relay 17 spare parts (refer to centre pages for location). When the green service indicator light on the front of the boiler is showing solid colour, the machine has been starved of water for in excess of 20 minutes and the solenoid valve has been disabled to prevent damage to the...
Page 8
Page 12 page 13 if parts required are not identified, please contact calomax limited * includes nuts, washers, etc. Exploded parts view (to be read in conjunction with the spare parts list) (wrapper not shown for clarity) 1 2 3 4 5 6 9 10 10 * 11 12 13 14 15 8 * 7 17 16.
Page 9
Page 14 page 15 note: whenever the body lid has been removed from the boiler a new lid gasket may be required to ensure a steam-tight joint. Damage to the unit caused by a poor lid seal is not covered by warranty. Scale deposits should be removed from all internal surfaces, particularly the heating ...
Page 10: Accessories
Page 16 page 17 accessories worktop-mounting stainless steel drip tray with drain outlet ref: ssdtwdk boiler securing clamp (to fix boiler to a worktop) ref: c6c ingredient caddy ref: ic3 (3 bay) - as shown shelf unit ref: shu ic4 (4 bay) boiler stand (to increase height of boiler) ref: cas6s## (whe...
Page 11
Page 18 page 19 symptoms possible cause remedy no boiling water available broken tap top normal level sensor holding signal element(s) cut-out tripped elements failed replace tap top (or component) de-scale / clean / dry see “important” note page 13 replace elements steam ejected from over ow excess...
Page 12
Page 20 page 21 calomax have manufactured water boilers in the uk for over 50 years. We are proud of our products and the back-up service we provide properly maintained and serviced, a calomax boiler should last many years and we have no hesitation in providing a full 12 months parts and labour warr...
Page 13
Page 22 page 23 service history and notes service history and notes.
Page 14
Page 24 model cascade- 6a serial number draw off capacity 18 litres heat-up time (full capacity - rst switch on) 48 minutes max ow rate from tap (boiler full) 4.5 litres / minute average ow rate from tap (during 18 litre draw off) 2.8 litres / minute voltage 220 - 240 v ac 50 - 60 hz power rating 6k...