Summary of ACT-7
Page 1
Act-7 quick start guide.
Page 2
2 act-7 quick start guide quick start guide health and safety warning as the air conditioner contains electrical and rotational equipment, it is recommended that only competent persons carry out any work on this type of device. Isolate electrically before entering machine or removing panels. This ap...
Page 3
3 act-7 quick start guide quick start guide – please read before operating the unit table of contents health and safety 2 system description 3 electrical supply 3 air fl ow 3 siting 4 heat exchanger 4 condensate 5 connections 5 room unit fl uid level 5 gas charge 5 controls 6 setting th e desired temp...
Page 4
4 act-7 quick start guide quick start guide ducted fan speed switch when th e act-7 is fi tted with ducting, th e position of th e ducted fan speed switch inside th e act-7 room unit has to be changed. The switch is accessed by removing th e top cover (fi ve screws). The switch is located at th e back...
Page 5
5 act-7 quick start guide condensate in operation, th e act-7 room unit condenses water vapour out of th e atmosphere. This water is pumped away th rough th e interconnecting line between th e room unit and th e heat exchanger. Re-evaporation of some of th e water occurs in th e heat exchanger, but ...
Page 6
6 act-7 quick start guide quick start guide fan speed control the speed of th e fan is controlled by th e fan speed control dial as shown above. Turning th e dial clockwise increases th e speed of th e fan and more solid black bars will be shown on th e fan speed indicator. Please note th at th ere ...
Page 7
7 act-7 quick start guide temperature reset alarm + - 25 act-7 16 c setting th e required temperature press and hold th e ‘enter’ key for two seconds, th en release to enter th e ‘settings menu’. With th e ‘temperature’ option highlighted press th e ‘enter’ key. Use th e ‘up’ and ‘down’ keys to chan...
Page 8
8 act-7 quick start guide quick start guide reset alarms hp fault lp fault act-7 16 c act-7 16 c alarms high pressure and low pressure faults are indicated by a fl ashing red ‘h’ or ‘l’ respectively and must be reset to resume normal operation. See ‘troubleshooting’ section. Resetting th e alarms fau...
Page 9
9 act-7 quick start guide tank full alarm this alarm resets itself and no action is required on th e part of th e user. When th e condensate tank in th e act-7 is full, a blue bucket fl ashes on th e console. While th is is fl ashing th e act-7 continues to work for a furth er 30 seconds. Aft er 30 se...
Page 10
10 act-7 quick start guide quick start guide settings menu advanced reset alarm advanced settings changing th e off set an off set is used to calibrate th e temperature shown on th e main screen. In th e ‘settings menu’ scroll down to ‘advanced settings’ and push ‘enter’. Highlight ‘off set’ and push ‘...
Page 11
11 act-7 quick start guide press ‘enter’ to move onto th e next digit. When ‘enter’ is pressed on th e fi nal digit, th e value is stored..
Page 12
12 act-7 quick start guide quick start guide setting th e language advanced menu enable pin language in th e ‘advanced menu’ scroll down to ‘language’ and push ‘enter.’ language menu english francais deutsch use th e ‘up’ and ‘down’ arrows to select th e desired language. Push ‘enter’ to save th e c...
Page 13
13 act-7 quick start guide turning off if you wish to turn th e device off and disconnect th e power supply, switch th e device to standby for a minimum of 30 minutes to allow for th e condensate pump to drain th e system. The hoses and th e mains power can th en be disconnected. Failure to follow th ...
Page 14
14 act-7 quick start guide quick start guide troubleshooting only a competent electrician should attempt to rectify electrical supply problems . Only a competent refrigeration engineer should work on th e refrigeration system . Symptoms possible causes action required no air fl ow from room unit, dis...
Page 15
15 act-7 quick start guide.
Page 16
Calorex heat pumps limited, the causeway, maldon, essex cm9 4xd, united kingdom t. +44 (0)1621 857171 e. Service@calorex.Com www.Calorex.Com.