Camille Bauer SINEAX TV815 Manual - page 2
SINEAX TV815
ENGLISH 5/8
SINEAX TV815
ENGLISH 6/8
SINEAX TV815
ENGLISH 7/8
SINEAX TV815
ENGLISH 8/8
Phone +41 56 618 21 11
Camille Bauer Metrawatt AG Fax +41 56 618 21 21
Aargauerstrasse 7
info@cbmag.com
CH-5610 Wohlen/Switzerland www.camillebauer.com
6.5 Settings with internal bridges
J9
SW1
SW2
SW3
J9
Active output
J9
Passive output
Internal bridges position
Settings through internal bridges
Active / Passive output
7. Electric connections
Make sure you adhere to the data on the type plate.
The country-specifi c provisions (e.g. for Germany, VDE 0100 «Conditions for
setting up high-voltage systems with nominal voltages below 1000 Volt») are to
be observed during installation and material selection for electric lines.
In order to meet the immunity requirements, we advise using shielded cables to
connect the signals. The shield has to be connected to primary grounding for
instrumentation. Moreover, it is favourable not to route conductors near power
appliances such as inverters, motors, induction ovens, etc.
It is imperative to ensure that all lines are de-energised when connecting!
High voltage may cause danger.
To connect electric lines, the signal converter has screw terminals suitable for wire cross sections
up to a maximum of 2.5 mm
2
. When connecting cables, please observe the following:
1. Remove approx. 0.8 cm of the cable insulation.
2. Insert the cable in the round opening.
3. Tighten the screw terminal fi rmly using a screwdriver.
4. Check if the cable is attached securely.
7.1 Power supply
Power supply has to range between 10 and 40 VDC
(irrespective of polarity) or 19 and 28 VAC; see also
the section «Installation instructions».
19 ÷ 28 VAC
10 ÷ 40 VDC
2,5 W max.
2
3
The upper limits must not be exceeded to avoid serious damage of the
module. Protect the power supply source to avoid possible damage of the
module by using a fuse of suitable size.
7.2 Current input
mA
11
10
+
mA (2 wire)
7
11
+
The loop is powered by
the sensor
The loop is powered by the
module
7.3 Voltage input
V - mV
9
10
+
V - mV
12
10
+
V input > 150 mV
V input < 150 mV
7.4 Output
Voltage
Generated current (*3)
External power supply
current (*4)
V output
6
1
+
V
mA output
6
1
+
A
active
+ mA output
1
6
A
+
passive
The loop is powered by
the sensor
The loop is powered by the
module
(*3) Already powered, active output to be connected to passive inputs.
(*4) Non-powered, passive output to be connected to active inputs. For selection see «Settings
with internal bridges».
8. Maintenance
The signal converter is maintenance-free. Any repair work may only be performed by authorised
bodies. Any warranty claim will lapse in case of violation.
9. Terms of warranty
Camille Bauer AG warrants the fl awless condition of the product with respect to material, man-
ufacturing and function and offers a standard warranty of 36 months. Such warranty becomes
effective upon delivery of the product to the customer. Camille Bauer AG reserves the right to
amend the terms of warranty any time with future effect.
Any defects shall be communicated by the buyer immediately after discovery. The rejected
products shall be sent in proper packaging and with suffi cient transport protection to one of our
authorised service centres. The sender shall bear the shipping risk.
Any defects arising due to improper treatment, faulty installation, mechanical damage, failure to
perform maintenance work, inappropriate use and connection to improper power supply shall be
excluded from any kind of warranty.
In case of repair work, alterations or tampering on the part of the buyer or any unauthorised third
parties, any warranty claim shall lapse.
10. Order information
Description
Article-No.
SINEAX TV815
Voltage / current isolating amplifi er
172677
EG / IEC KONFORMITÄTSERKLÄRUNG
EC / IEC DECLARATION OF CONFORMITY
D o k u m e n t - N r . /
T V8 1 5 _ C E- k o n f . D O C
D o c u m e n t . N o . :
H e r s t e lle r /
C a m i l l e B a u e r M e t r a w a t t AG
M a n u f a c t u r e r :
S wi t ze r la n d
An s c h r if t /
Aa r g a u e r s t r a s s e 7
A d d r e s s :
C H - 5 6 1 0 W o h l e n
P r o d u k t b e ze i c h n u n g /
St r o m - / Sp a n n u n g s - T r e n n v e r s t ä r k e r
P r o d u c t n a m e :
V o l t a g e / c u r r e n t s ig n a l c o n v e r t e r
T yp / T yp e :
S I N E AX T V8 1 5
D a s b e z e i c h n e t e P r o d u k t s t i m m t m i t d e n V o r s c h r i f t e n f o l g e n d e r E u r o p ä i s c h e r R i c h t l i n i e n
ü b e r e i n , n a c h g e w i e s e n d u r c h d i e E i n h a l t u n g f o l g e n d e r N o r m e n :
T h e a b o v e m e n t i o n e d p r o d u c t h a s b e e n m a n u f a c t u r e d a c c o r d i n g t o t h e r e g u l a t i o n s o f t h e f o l l o w i n g E u r o p e a n d i -
r e c t i v e s p r o v e n t h r o u g h c o m p l i a n c e w i t h t h e f o l l o w i n g s t a n d a r d s :
R i c h t l i n i e /
D i r e c t i v e
2 0 0 4 / 1 0 8 / E G ( E C )
E l e k t r o m a g n e t i s c h e V e r t r ä g l i c h k e i t - E M V - R i c h t l i n i e
E l e c t r o m a g n e t i c c o m p a t i b i l i t y - E M C d i r e c t i v e
N o r m /
S t a n d a r d
E N 6 1 0 0 0 - 6 - 4 : 2 0 0 7
F a c h g r u n d n o r m e n - S t ö r a u s s e n d u n g f ü r I n d u s t r i e b e t r i e b e
G e n e r i c s t a n d a r d s - E m i s s i o n s t a n d a r d f o r i n d u s t r i a l e n v i r o n m e n t s
E N 6 1 0 0 0 - 6 - 2 : 2 0 0 5
F a c h g r u n d n o r m e n - S t ö r f e s t i g k e i t f ü r I n d u s t r i e b e r e i c h e
G e n e r i c s t a n d a r d s - I m m u n i t y f o r i n d u s t r i a l e n v i r o n m e n t s
P r ü f u n g e n /
T e s t s
I E C 6 1 0 0 0 - 4 - 5
R i c h t l i n i e /
D i r e c t i v e
2 0 0 6 / 9 5 / E G ( E C )
E l e k t r i s c h e B e t r i e b s m i t t e l z u r V e r w e n d u n g i n n e r h a l b b e s t i m m t e r S p a n n u n g s g r e n z e n – N i e d e r -
s p a n n u n g s r i c h t l i n i e – C E - K e n n z e i c h n u n g : 9 5
E l e c t r i c a l e q u i p m e n t f o r u s e w i t h i n c e r t a i n v o l t a g e l i m i t s – L o w V o l t a g e D i r e c t i v e – A t t a c h m e n t
o f C E m a r k i n g : 9 5
N o r m /
S t a n d a r d
E N 6 1 0 1 0 - 1 : 2 0 0 1
S i c h e r h e i t s b e s t i m m u n g e n f ü r e l e k t r i s c h e M e s s - , S t e u e r - , R e g e l - u n d L a b o r g e r ä t e – T e i l 1 : A l l -
g e m e i n e A n f o r d e r u n g e n
S a f e t y r e q u i r e m e n t s f o r e l e c t r i c a l e q u i p m e n t f o r m e a s u r e m e n t , c o n t r o l a n d l a b o r a t o r y u s e –
P a r t 1 : G e n e r a l r e q u i r e m e n t s
O r t , D a t u m /
W o h l e n , 1 3 . Ma i 2 0 1 4
P l a c e , d a t e :
U n t e r s c h r i f t / s i g n a t u r e :
M. U l r i c h
J . B r e m
L e i t e r T e c h n i k / H e a d o f e n g i n e e r i n g
Q u a l i t ä t s m a n a g e r / Q u a l i t y m a n a g e r
11. Declaration of conformity