1. DL manuals
  2. Campbell Hausfeld
  3. Pressure Washer
  4. PW2120
  5. Product Manual

Campbell Hausfeld PW2120 Product Manual

Manual is about: Gasoline Powered Pressure Washer

Summary of PW2120

  • Page 1

    Built to last gasoline powered horizontal pressure washers product manual pw2120, pw2420, pw2458, pw2705 carefully read and understand these instructions before operating your pressure washer. © 2003 campbell hausfeld/scott fetzer in462400av 8/03 frequently asked questions . . . . . . . . . . . . . ...

  • Page 2: Frequently Asked Questions

    Pressure washers www.Chpower.Com frequently asked questions how do i start my pressure washer? 1. Make sure you have gas and oil in the engine. 2. Turn the water on, then trigger the gun to make sure the water will flow smoothly out of the nozzle or tip. 3. Put the engine throttle control in the “fa...

  • Page 3: Notice

    Ble support. Keep good footing and balance at all times. 10. Follow the maintenance instructions specified in the manual. Risk of injection or severe injury. Keep clear of nozzle. Do not discharge streams at persons. This product is to be used only by trained operators. Always remove lance from gun ...

  • Page 4: Pre-Operation

    Pressure washers www.Chpower.Com 4 pre-operation unpacking remove the equipment and all parts from the carton. The carton should contain the following. • one pressure washer (pump, engine, cart base). • one cart handle assembly. • one basket (not included with all models). • one front guard tube (no...

  • Page 5: Pre-Operation (Continued)

    Trigger safety latch in the engaged position, the trigger safety latch prevents the gun from being triggered accidentally. Push the latch fully down to engage it (see figure 11). Always engage the trigger safety latch when the unit is not in use. Accessory storage additional accessories can be store...

  • Page 6: Notice

    Pressure washers www.Chpower.Com when pulling the starter rope, make sure to keep your hand and arm clear of the engine and cart components. Never let the starter rope return by itself. Doing so could jam the recoil system. 8. If the engine does not start after two or three pulls or if the rope is h...

  • Page 7: Operation (Continued)

    Adjusting the spray fan angle your unit is either equipped with a adjustable fan nozzle or quick connect tips that have a range of spray fan angles. If equipped with the adjustable fan nozzle, the spray end of the lance can be rotated to have a 0 o narrow high impact stream to a 60 o wide fan spray ...

  • Page 8: Notice

    Pressure washers turbo nozzle (not included with all models) a turbo nozzle, sometimes referred to as a rotary nozzle, can significantly reduce cleaning time. The turbo nozzle combines the power of a narrow high impact stream with the efficiency of a 25 degree fan pattern. The turbo nozzle swirls a ...

  • Page 9: Operation (Continued)

    9 operation (continued) soiled areas. Never allow the deter- gent to dry on the cleaning surface. 2a. To rinse or to return the nozzle to high pressure, release the trigger and slide the nozzle to the high pressure setting. 2b.For units with quick connect tips: replace black 65 o tip with another co...

  • Page 10: Maintenance

    Pressure washers 10 maintenance observe regular maintenance intervals to ensure maximum performance and life from the pressure washer. Refer to the schedule for recommended mainte- nance. If you operate the pressure washer in dusty conditions, perform maintenance checks more often. Engine oil changi...

  • Page 11: Maintenance (Continued)

    Engine oil type sae 10w-30 sae 30w (above 60˚ f) engine oil capacity briggs and stratton engines 20 fl. Oz. Honda engines 18 fl. Oz. Robin engines 20 fl. Oz. Engine fuel capacity briggs and stratton engines 0.75 gal honda engines 0.46 gal robin engines 0.95 gal pump oil type horizontal axial pumps s...

  • Page 12

    Pressure washers www.Chpower.Com troubleshooting chart - gasoline powered pressure washers only symptom possible cause(s) corrective action(s) engine will not start or is hard to start engine misses or lacks power low pressure and/or pump runs rough water leakage from under pump manifold water in pu...

  • Page 13: Service Record

    13 www.Chpower.Com service record date maintenance performed replacement components required notes pressure washer will not spray detergent 1. Nozzle not pushed up far enough 2. Clog, kink, or hole in detergent suction hose 3. Hose length too long 4. Lance not functioning properly 5. Not using quick...

  • Page 14

    Pressure washers 14 www.Chpower.Com limited warranty 1. Duration: from the date of purchase by the original purchaser as follows: standard duty - one year, serious duty - two years, extreme duty - three years, maxus brand serious duty - three years, maxus brand extreme duty - five years. 2. Who give...