1. DL manuals
  2. Charmglow
  3. Grill
  4. 234
  5. Use And Care Manual

Charmglow 234 Use And Care Manual

Manual is about: STAINLESS STEEL GAS GRILL

Summary of 234

  • Page 1

    6 ® ` rr stainless steel gas grill use and care guide model no.: 720-0234 for outdoor use only ® please contact 1-800-913-8999 for assistance do not return to place of purchase..

  • Page 2: Table of Content

    Table of content section one importance………………………….….. 1 precautions…………………………. . 2-3 placement of the grill……………….…. 3 section two screw description………………………4 assembly instructions……………… 5-12 propane tank assembly……………… ..13 your gas grill is ready to use…………..14 gas hook up……………………………15 leak testin...

  • Page 3

    Importance * * * warning * * * for your safety if you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid 4. If odor continues, immediately call your gas supplier or your fire department. For your safety 1. Do not store or use gasoline or other flammable vapors and...

  • Page 4: Precautions

    Precautions warning do not try lighting this appliance without reading the “lighting instructions” section of this manual. Tested in accordance with anis z21.58b-2002, cga 1.6b-2002 standard for outdoor cooking gas appliances. This grill is for outdoor use only . Check your local building codes for ...

  • Page 5: Precautions

    Precautions when using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause burns from steam. Do not use a towel or bulky cloth in place or...

  • Page 6

    Screw description 9 6pcs 5/32× 12mm cr ossed r ound head scr ew cr ossed r ound head scr ew cr ossed r ound head scr ew cr ossed r ound head scr ew 2pcs 5/32× 6mm 8 1pcs 5/32× 5mm hexagonal scr ew 5 i t em descr i pt i on(scale 1: 1) speci f i cat i on quant i t y 1 2 cr ossed r ound head scr ew 1/4...

  • Page 7: Assembly Instructions

    Assembly instructions please read the instructions carefully and follow step by step . Attention: please lock the caster during the process of installation of the grill. Tools required: philips head screwdriver(not provide),monkey wrench(not provide) step 1: . Assemble two regular casters to the rig...

  • Page 8

    Step 3 : assemble the back panel to the two side panels. With two (2)pcs 1/4*12mm screws and four (4) pcs 5/32*12 as shown figure below. Step 4 : assemble the front cart flame and back cart flame to the front side and back side of the side panel with eight (8) screws . Attention: the front cart flam...

  • Page 9

    Step 5: insert fix piece of door shaft into the square pipe at left and right side as shown figure below, screw four(4)pcs 5/32*12 screws. Attention: do not screw too tight. Step 6: assembly the door in the fix piece of door shaft from bottom as shown figure and tighten the screws. 7.

  • Page 10

    Step 7: first assemble the door handle to the door with the eight (8) pcs 5/32*10 screws as shown figure below, then put the condiment rack inside of the left door as shown figure below. Step8 : remove the head unit of grill from carton. Insert the upper portion of the grill onto the cart from the t...

  • Page 11

    9 step9 : open the lid ,take out the cooking grid first, then screw tighten the four(4) pcs 1/4*12 screws into the left side and right side of firebox as shown figure below. Step 10 : assemble the side shelf with three(3) pcs 1/4*12 screws as shown figure below..

  • Page 12

    10 step 11 : assemble the panel of side burner with three(3) pcs 1/4*12 screws as shown figure below. Step 12 : .Assemble the side shelf and panel of side burner into the firebox with eight(8) pcs 1/4*12 screws. Attention: the upper screws to the firebox should be screwed from inside to outside for ...

  • Page 13: Side Burner Valve Assembly:

    11 side burner valve assembly: step 1: insert valve assembly through side step 2: remove 4(four)screws & washer from the “u” panel. . Brackets on the side burner. Step 3: insert valve stem assembly into burner step 4: insert valve stem assembly into control panel. Venturi. Step 5: replace ”u” bracke...

  • Page 14

    12 step 13. Put the warming rack, grease tray and small grease box as shown figure below..

  • Page 15

    13 propane tank assembly 1 ． with hand attach propane gas tank to regulator inlet fitting by turning the regulator clockwise until tight as shown in figure below. 2. Lp gas cylinder must be fitted with a listed overfill prevention device (opd). O pe n clo se g caution! Do not use tools to attach reg...

  • Page 16

    14 your gas grill is ready to use.

  • Page 17: Gas Hook-Up

    Gas hook-up only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement pressure regulator and hose assembly must be specified by the grill manufacturer. This is a liquid propane configured grill. Do not attempt to use a natural gas supply unless the grill h...

  • Page 18: Installer Final Checklist

    Do not smoke while leak testing. Never perform leak test with an open flame. Make a soap solution of one part liquid detergent and one part water. You will need a spray bottle, brush, or rag to apply the solution to the fittings. For the initial leak test, make sure the l.P. Cylinder is full. To tes...

  • Page 19: Operating Instruction

    Operating instruction general use of the grill and rotisserie each main burner is rated at 11,000 btu/hr. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. Above the burners are stainless steel radiants (flame covers). T...

  • Page 20

    Check for proper burner flame characteristics. Each burner is adjusted prior to shipment; however, variations in the local gas supply may take minor adjustments necessary. Burner flames should be blue and stable with no yellow tips, excessive noise, or lifting. If any of these conditions exist call ...

  • Page 21: Using The Side Burner

    Using the side burner warning: important! Using the side burner: inspect the gas supply hose prior to turning the gas “on”. If there is evidence of cuts, wear or abrasion, it must be replaced prior to use. Do not use the side burner if the odor of gas is present. Warning: always keep your face and b...

  • Page 22: Trouble  Shooting

    Care & maintenance of side burner burner cleaning: clean the exterior of the burner with a wire brush. Clear any clogged burner ports with a straightened paper clip. Never enlarge the burner ports. Never use a wooden toothpick as it may break off the clog the port. Stainless steel: there are many di...

  • Page 23

    Exploded view for 720-0234 23 39 37 38 56 44 35 34 33 27 26 15 07 06 36 54 51 24 32 29 49 47 48 28 02 03 25 62 30 42 31 59 61 53 57 58 55 43 45 50 60 52 14 16 10 09 11 12 13 40 41 46 64 63 20 21 17 19 22 18 08 05 04 01 21.

  • Page 24: Model 720-0234  Parts List

    Model 720-0234 parts list no part(description) qty no. Part(description) qty 01 lid 1 33 inlet plastic loop 1 02 handle assembly, lid 1 34 left door 1 03 base of handle 2 35 right door 1 04 heat indicator 1 36 left fix piece of door shaft ,top 1 05 name plate 1 37 right fix piece of door shaft, top ...

  • Page 25: Grilling Hints

    Grilling hints the doneness of meat, whether rare, medium, or well done, is affected to a large degree by the thickness of the cut. Expert chefs say it is impossible to have a rare doneness with a thin cut of meat. The cooking time is affected by the kind of meat, the size and shape of the cut, the ...

  • Page 26: Grill Cooking Chart

    Grill cooking chart food weight or thickness flame size approximate time special instructions and tips vegetables fresh slice. Dot with butter or margarine. Wrap in heavy-duty foil. Grill, turning occasionally. Beets medium 12 to 20 minutes carrots turnips grill, turning once. Brush occasionally wit...

  • Page 27

    Food weight or thickness flame size approximate time special instructions and tips tenderloin, porterhouse, t-bone, sirloin rare 1 inch high 8 to 14 minutes remove excess fat from edge. Slash remaining fat at 2-inch intervals. Grill, turning once. 1-1/2 inch high 11 to 18 minutes medium 1 inch mediu...

  • Page 28

    Food weight or thickness flame size approximate time special instructions and tips fish and seafood steaks grill, turning once. Brush withmelted butter, margarine or oil to keep moist. Halibut 3/4 to 1 inch medium to 8 to 15 minutes salmon high swordfish whole catfish 4 to 8 ounces medium to 12 to 2...

  • Page 29: Grill Recipe Suggestions

    Grill recipe suggestions bbq salmon 2 large salmon steaks 2 tbs. Oil salt & pepper 2 oz. Thin bacon slices 2 tbs. Butter 1 tbs. Lemon juice spring of parsley lemon wedges preheat the bbq. Brush the steaks with oil and season with salt and pepper. Place on bbq grill and cook for 10 minutes, turning s...

  • Page 30

    Minutes longer or until potatoes are tender. Let stand 5 minutes before serving. Vegetable kabobs 3 medium-sized zucchini 12 cherry tomatoes 12 fresh mushrooms grated parmesan cheese parboil whole zucchini 5 minutes on your side burner or until just tender. Drain and cut into ½ inch slices. Thread z...

  • Page 31

    Accordion pleated. Fasten the second meat hook into the rack. Turn your rotis burner on high. Rotis for 50 minutes or until done. Pork roast apple cider vinegar basting sauce: 1 c. Apple cider vinegar 6 oz. Water ½ stick butter salt, pepper, parsley and garlic seasoning 2 oz. Lemon juice 10 lbs. Por...

  • Page 32

    Limited warranty model 720-0234 stainless steel outdoor gas grill nexgrill industries inc. Warrants to the original consumer purchaser of each outdoor gas grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below. This war...