- DL manuals
- Charmglow
- Grill
- 720-0230
- Use And Care Manual
Charmglow 720-0230 Use And Care Manual
Summary of 720-0230
Page 1
` rr for outdoor use only stainless steel gas grill use and care guide model no.: 720-0230 please contact 1-800-913-8999 for assistance do not return to place of purchase. R r.
Page 2: Table of Content
Table of content section one importance………………………….….. 1 precautions…………………………. . 2-3 placement of the grill……………….…. 3 section two screw description………………………4 assembly instructions……………… 5-11 how to install a gas tank………………12 propane tank assembly……………… ..13 installation instruction…………………14 your ga...
Page 3
1 importance * * * warning * * * for your safety if you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid 4. If odor continues, immediately call your gas supplier or your fire department. For your safety 1. Do not store or use gasoline or other flammable vapors a...
Page 4: Precautions
2 precautions warning do not try lighting this appliance without reading the “lighting instructions” section of this manual. Tested in accordance with ansi z21.58b-2002, cga 1.6b-2002 standard for outdoor cooking gas appliances. This grill is for outdoor use only. Check your local building codes for...
Page 5: Precautions
3 precautions when using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause burns from steam. Do not use a towel or bulky cloth in place ...
Page 6
4 screw description double-ended screw φ 4× 12+3+φ 5× 12mm 2pcs 2pcs 1/4 × 10mm crossed tray head screw 1/4 × 12mm 20pcs 12pcs 1/ 4× 38mm crossed flat head screw quantity specification description(scale 1:1) item crossed flat head screw landfrom screw 5/32 × 6+φ 5× 5mm 1pc 1/4 × 78.4mm 1/4 × 14mm 1p...
Page 7: Assembly Instructions
5 assembly instructions please read the instructions carefully and follow step by step . Attention: please lock the caster during the process of installation of the grill. Tools required: philips head screwdriver (not provide), crescent wrench (not provide) step 1: . Assemble two regular casters to ...
Page 8
6 step 3: assemble the back panel to the two side panels with four (4) 1/4 x 12mm screws as shown figure below. Step 4: assemble the cart flame to the front side of the side panel with four (4) 1/4 x 38mm screws. Please attention don’t screw them too tight in the beginning.
Page 9
7 step5 : remove the head unit of grill from carton. Insert the upper portion of the grill onto the cart from the top with four (4)1/4 x 12mm screws. Caution!! The firebox is heavy, and we recommend two or more people to lift up firebox. Step 6: 1. Place flame tamers (3) on to the fire box as show f...
Page 10
8 step 7 :.Use four (4)1/4 x 12mm screws to install the rear panel as show below. Step8 : assemble side burner with (8) 1/4 x 12mm screws as figure show below. Connect the condiment tray and side shelf with two screws. The two screws have been fitted in side shelf..
Page 11: Assembly Instructions
9 assembly instructions side burner valve assembly: step 1: insert valve assembly through side step 2: remove 4(four) screws & washers panel from the “u” brackets on the side burner step 3: insert valve stem assembly into burner step 4: insert valve stem assembly through knob venturi hole to the con...
Page 12
10 step 9: firstassemble the door handle to the door with the screw which packaged in the condiment rack then assemble the two front doors to the grill with two (2) double ended screws. Step 10 :assemble the condiment rack inside of the left door..
Page 13
11 step11: screw in the tank retention screw as the picture shown below..
Page 14: How to Install A Gas Tank
12 how to install a gas tank opening the front door and place gas tank into the gas tank holes. Secure the gas tank by turning the retention screw at the back of the grill clockwise until it is tight. Complete..
Page 15: Propane Tank Assembly
13 propane tank assembly ● with hand attach propane gas tank to regulator inlet fitting by turning the regulator clockwise until tight as shown in figure below. Your gas grill is ready to use o pe n clo se g caution! Do not use tools to attach regulator / hose assembly to preopane tank.
Page 16: Installation Instruction
14 installation instruction model 720-0230 gas hose retention kit package should include (4 pcs): regulator ring clamp with wing mounting bolt with ring slot 1 hex nut and washer 1 wrench hose clamp installation 1a. Insert “threaded end” mounting bolt through top middle vent 2a. Put regulator hose t...
Page 17
15 your gas grill is ready to use.
Page 18: Gas Hook-Up
16 gas hook-up only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement pressure regulator and hose assembly must be specified by the grill manufacturer. This is a propane configured grill. Do not attempt to use a natural gas supply unless the grill has b...
Page 19: Installer Final Checklist
17 before testing make sure that all packing material is removed from the grill including the burner tie-down straps. Do not smoke while leak testing. Never perform leak test with an open flame. Make a soap solution of one part liquid detergent and one part water. You will need a spray bottle, brush...
Page 20: Operating Instruction
18 operating instruction general use of the grill and rotisserie each main burner is rated at 12,000 btu/hr. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. Above the burners are stainless steel radiants (flame covers)...
Page 21
19 if the burner will not light after several attempts then the burner can be match lit. If you’ve just attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. Keep your face and hands as far away from the grill as possible. Insert a lit light rod or lig...
Page 22: Using The Side Burner
20 using the side burner warning: important! Using the side burner: inspect the gas supply hose prior to turning the gas “on”. If there is evidence of cuts, wear or abrasion, it must be replaced prior to use. Do not use the side burner if the odor of gas is present. Warning: always keep your face an...
Page 23: Trouble Shooting
21 care & maintenance of side burner burner cleaning: clean the exterior of the burner with a wire brush. Clear any clogged burner ports with a straightened paper clip. Never enlarge the burner ports. Never use a wooden toothpick as it may break off the clog the port. Stainless steel: there are many...
Page 24
22 exploded view for 720-0230 42 39 01 06 02 04 03 05 07 08 09 10 11 12 13 15 14 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 33 34 35 36 37 ed al lio n m.
Page 25: Model 720-0230 Parts List
23 model 720-0230 parts list no part (description) q'ty no part (description) q'ty 01 lid, front 1 23 bottom panel 1 02 heat indicator 1 24 a/b double layer door (l&r) 1 03 heat insulating spacer 2 25 main burner 3 04 handle assembly, post 2 26 flame tamer 3 05 handle assembly, lid 1 27 cooking grid...
Page 26: Grilling Hints
24 grilling hints the doneness of meat, whether rare, medium, or well done, is affected to a large degree by the thickness of the cut. Expert chefs say it is impossible to have a rare doneness with a thin cut of meat. The cooking time is affected by the kind of meat, the size and shape of the cut, t...
Page 27: Grill Cooking Chart
25 grill cooking chart food weight or thickness flame size approximate time special instructions and tips vegetables fresh slice. Dot with butter or margarine. Wrap in heavy-duty foil. Grill, turning occasionally. Beets medium 12 to 20 minutes carrots turnips grill, turning once. Brush occasionally ...
Page 28
26 food weight or thickness flame size approximate time special instructions and tips tenderloin, porterhouse, t-bone, sirloin rare 1 inch high 8 to 14 minutes remove excess fat from edge. Slash remaining fat at 2-inch intervals. Grill, turning once. 1-1/2 inch high 11 to 18 minutes medium 1 inch me...
Page 29
27 food weight or thickness flame size approximate time special instructions and tips fish and seafood steaks grill, turning once. Brush withmelted butter, margarine or oil to keep moist. Halibut 3/4 to 1 inch medium to 8 to 15 minutes salmon high swordfish whole catfish 4 to 8 ounces medium to 12 t...
Page 30: Grill Recipe Suggestions
28 grill recipe suggestions bbq salmon 2 large salmon steaks 2 tbs. Oil salt & pepper 2 oz. Thin bacon slices 2 tbs. Butter 1 tbs. Lemon juice spring of parsley lemon wedges preheat the bbq. Brush the steaks with oil and season with salt and pepper. Place on bbq grill and cook for 10 minutes, turnin...
Page 31
29 minutes longer or until potatoes are tender. Let stand 5 minutes before serving. Vegetable kabobs 3 medium-sized zucchini 12 cherry tomatoes 12 fresh mushrooms grated parmesan cheese parboil whole zucchini 5 minutes on your side burner or until just tender. Drain and cut into ½ inch slices. Threa...
Page 32
30 accordion pleated. Fasten the second meat hook into the rack. Turn your rotis burner on high. Rotis for 50 minutes or until done. Pork roast apple cider vinegar basting sauce: 1 c. Apple cider vinegar 6 oz. Water ½ stick butter salt, pepper, parsley and garlic seasoning 2 oz. Lemon juice 10 lbs. ...
Page 33
31 limited warranty model 720-0230 stainless steel outdoor gas grill nexgrill industries inc. Warrants to the original consumer purchaser of each outdoor gas grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below. This ...