- DL manuals
- Charmglow
- Grill
- 730-0230
- Use And Care Manual
Charmglow 730-0230 Use And Care Manual
Summary of 730-0230
Page 1
` rr stainless steel gas grill use and care guide for outdoor use only model no.: 730-0230 r r please contact 1-800-913-8999 for assistance do not return to place of purchase..
Page 2: Table of Content
Table of content section one importance………………………….………….. 1 precautions…………………………. ………. 2-3 placement of the grill……………….……….….3 section two screw description……………………………….4 assembly instructions……………………… 5-10 installation of the hose onto the ng regulator…11 your gas grill is ready to use…………………..12 ...
Page 3
Importance * * * warning * * * for your safety if you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid 4. If odor continues, immediately call your gas supplier or your fire department. For your safety do not store or use gasoline or other flammable vapors and li...
Page 4: Precautions
Precautions warning do not try lighting this appliance without reading the “lighting instructions” section of this manual. Tested in accordance with ansi z21.58b-2002, cga 1.6b-2002 standard for outdoor cooking gas appliances. This grill is for outdoor use only . Check your local building codes for ...
Page 5: Precautions
Precautions when using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause burns from steam. Do not use a towel or bulky cloth in place or...
Page 6
Screw description φ 4× 12 +3+ φ 5 × 12mm 2pcs 2pcs 1/4 × 10mm crossed tray head screw 1/4 × 12mm 20pcs 12pcs 1/4× 38mm crossed flat head screw quantity specification description(scale 1:1) item crossed flat head screw landfrom screw 5/32 × 6+ φ 5× 5 mm 1pcs double-ended screw 4.
Page 7: Assembly Instructions
Assembly instructions please read the instructions carefully and follow step by step . Attention: please lock the caster during the process of installation of the grill. Tools required: philips head screwdriver(not provide), crescent wrench(not provide) step 1: . Assemble two regular casters to the ...
Page 8
Step 3 : assemble the back panel to the two sides panel. With four (4) 1/4x12mm screws as shown figure below. Step 4 : assemble the cart flame to the front side of the side panel with four (4) 1/4x38mm screws . Please attention don’t screw them too tight in the beginning 6.
Page 9
Step5 : remove the head unit of grill from carton. Insert the upper portion of the grill onto the cart from the top with four (4)1/4x12mm screws. Caution!! The firebox is heavy, and we recommend two or more people to lift up firebox. Step 6 : 1 . Place flame tamers (3) on to the fire box as show fig...
Page 10
Step 7 : .Use four (4)1/4x12mm screws to install the rear panel as show below. Step8 : assemble side burner with (8) 1/4x12mm screws as figure show below. Connect the condiment tray and side shelf with two screws. The two screws have been fitted in side shelf. 8.
Page 11: Assembly Instructions
9 assembly instructions side burner valve assembly: step 1: insert valve assembly through side step 2: remove 4(four) screws & washers panel from the “u” brackets on the side burner step 3: insert valve stem assembly into burner step 4: insert valve stem assembly through knob venturi hole to the con...
Page 12
10 step 9: first assemble the door handle to the door with the screw which packaged in the condiment rack then assemble the two front doors to the grill with two (2) double ended screws. Step 10 : assemble the condiment rack inside of the left door..
Page 13
11 installation of the hose onto the ng regulator step1: remove 3/8 inch adaptor step2: attach the hose step 3: the complete assembled unit note: you must remove the 3/8 inch adaptor first, in order to connect with the ng regulator. If you have any questions please contact our customer service:1-800...
Page 14
12 your gas grill is ready to use.
Page 15: Gas Hook-Up
Gas hook-up only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement pressure regulator and hose assembly must be specified by the grill manufacturer. This is a natural gas configured grill. Do not attempt to use a liquid propane supply unless the grill h...
Page 16: Installer Final Check List
Installer final check list specified clearance maintained 24” from combustibles. All internal packaging removed. Knobs turn freely. Burners are tight and sitting properly on orifices. Unit tested and free of leaks. User informed of gas supply shut off valve location. User, please retain these instru...
Page 17: Operating Instruction
Operating instruction general use of the grill and rotisserie each main burner is rated at 12,000 btu/hr. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. Above the burners are stainless steel radiants (flame covers). T...
Page 18
To manually light the grill if the burner will not light after several attempts then the burner can be match lit. If you ’ ve just attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. Keep your face and hands as far away from the grill as possible. In...
Page 19: Using The Side Burner
Using the side burner warning: important! Using the side burner: inspect the gas supply hose prior to turning the gas “on”. If there is evidence of cuts, wear or abrasion, it must be replaced prior to use. Do not use the side burner if the odor of gas is present. Warning: always keep your face and b...
Page 20: Trouble Shooting
Care & maintenance of side burner burner cleaning: clean the exterior of the burner with a wire brush. Clear any clogged burner ports with a straightened paper clip. Never enlarge the burner ports. Never use a wooden toothpick as it may break off the clog the port. Stainless steel: there are many di...
Page 21
Exploded view for 730-0230 m e d a l l i on 3 8 3 7 3 6 3 5 3 4 3 2 3 1 3 0 2 9 2 8 2 7 2 6 2 5 2 4 2 3 2 2 2 1 2 0 1 9 1 8 1 4 1 5 1 3 1 2 1 1 1 0 0 9 0 8 0 7 0 5 0 3 0 4 0 2 0 6 0 1 4 0 1 6 1 7 19.
Page 22: Model 730-0230 Parts List
Model 730-0230 parts list no part (description) q'ty no part (description) q'ty 01 lid, front 1 22 gas valve, side burner 1 02 heat indicator 1 2 4 bottom panel 1 03 heat insulating spacer 2 2 5 a/b double layer door (l&r) 1 04 handle assembly, post 2 2 6 main burner 3 05 handle assembly, lid 1 2 7 ...
Page 23: Grilling Hints
Grilling hints the doneness of meat, whether rare, medium, or well done, is affected to a large degree by the thickness of the cut. Expert chefs say it is impossible to have a rare doneness with a thin cut of meat. The cooking time is affected by the kind of meat, the size and shape of the cut, the ...
Page 24: Grill Cooking Chart
Grill cooking chart food weight or thickness flame size approximate time special instructions and tips vegetables fresh slice. Dot with butter or margarine. Wrap in heavy-duty foil. Grill, turning occasionally. Beets medium 12 to 20 minutes carrots turnips grill, turning once. Brush occasionally wit...
Page 25
Food weight or thickness flame size approximate time special instructions and tips tenderloin, porterhouse, t-bone, sirloin rare 1 inch high 8 to 14 minutes remove excess fat from edge. Slash remaining fat at 2-inch intervals. Grill, turning once. 1-1/2 inch high 11 to 18 minutes medium 1 inch mediu...
Page 26
Food weight or thickness flame size approximate time special instructions and tips fish and seafood steaks grill, turning once. Brush withmelted butter, margarine or oil to keep moist. Halibut 3/4 to 1 inch medium to 8 to 15 minutes salmon high swordfish whole catfish 4 to 8 ounces medium to 12 to 2...
Page 27: Grill Recipe Suggestions
Grill recipe suggestions bbq salmon 2 large salmon steaks 2 tbs. Oil salt & pepper 2 oz. Thin bacon slices 2 tbs. Butter 1 tbs. Lemon juice spring of parsley lemon wedges preheat the bbq. Brush the steaks with oil and season with salt and pepper. Place on bbq grill and cook for 10 minutes, turning s...
Page 28
Minutes longer or until potatoes are tender. Let stand 5 minutes before serving. Vegetable kabobs 3 medium-sized zucchini 12 cherry tomatoes 12 fresh mushrooms grated parmesan cheese parboil whole zucchini 5 minutes on your side burner or until just tender. Drain and cut into ½ inch slices. Thread z...
Page 29
Accordion pleated. Fasten the second meat hook into the rack. Turn your rotis burner on high. Rotis for 50 minutes or until done. Pork roast apple cider vinegar basting sauce: 1 c. Apple cider vinegar 6 oz. Water ½ stick butter salt, pepper, parsley and garlic seasoning 2 oz. Lemon juice 10 lbs. Por...
Page 30
Limited warranty model 730-0230 stainless steel outdoor gas grill nexgrill industries inc. Warrants to the original consumer purchaser of each outdoor gas grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below. This war...