- DL manuals
- Charmglow
- Grill
- 730-0289
- Use And Care Manual
Charmglow 730-0289 Use And Care Manual
Summary of 730-0289
Page 1
Stainless steel gas grill use and care guide model no.: 730-0289 please contact 1-800-913-8999 for assistance do not return to place of purchase for outdoor use only ® ® k15y06n-1.
Page 2: Table of Contents
1 safety instructions …………………….. Side shelf assembly………..…………. Side shelf handle assembly………..… battery assembly …………………….. Condiment assembly …… ……………. Installation of nature gas regulator….. To match light the grill ………….. Lighting instructions………………………… lighting illustrations……………………. 2~7 8 9 10 ...
Page 3
2 for your safety if you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid. 4. If odor continues, immediately call your gas supplier or your fire department. Safety instructions ***** warning ***** k15y06n-1.
Page 4
3 warning do not try lighting this appliance without first reading the “lighting instructions” section of this manual. Warning electrical grounding instructions this appliance (rotisserie motor) is equipped with a plug and should be plugged directly into a properly grounded receptacle. Do not cut or...
Page 5
4 keep a spray bottle of soapy water near the gas supply valve and check the connections before each use. Do not attempt to light the grill if odor of gas is present. Call for service 1-800-913-8999. Rotisserie drive motor use only for outdoors, do not expose to rain. Caution: to ensure continued pr...
Page 6: Safety Instructions
5 children should not be left alone or unattended in an area where the grill is being used. Never allow them to sit, stand or play on or around the grill at any time. Do not store items of interest to children around or below the grill or in the cart. Never allow children to crawl inside of the cart...
Page 7: Safety Instructions
6 when using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause burns from steam. Do not use a towel or bulky cloth in place of potholder...
Page 8: Safety Instructions
Safety instructions checking for gas leaks never test for leaks with a flame. Prior to first use and at the beginning of each new season, you must check for gas leaks. Follow these steps: 1.Make soap solution by mixing one part liquid detergent and one part water. 2.Turn off heat control valves, and...
Page 9
Side shelf assembly 1. The screws used to attach the side shelf are already screwed into the left side burner and right side panel(see the figure below).Loosen the screws from the left side burner and right side panel, install the side shelves and tighten screws as the figure shown below. Attention:...
Page 10: Side Shelf Handle Assembly
Side shelf handle assembly the screws used to attach the side shelf handle are already screwed into the side shelf handle (see the figure below).Loosen the screws from the side shelf handle, align with the holes in the side shelf, and secure into the holes on the right side shelf of the grill 9 k15y...
Page 11: Battery Assembly
Battery assembly 1. In order to install the battery, remove the ignition button housing. Please keep the positive pole of the battery facing toward you. Insert the battery into the housing. Replace the ignition button housing after battery is installed. Condiment rack assembly assemble the condiment...
Page 12
Installation of nature gas regulator 1. The nature gas regulator has been factory installed. Attach the pvc gas hose to the regulator (see drawing below). 2. Connect the other end of the pvc gas hose to the house gas line using the quick-connect fitting. 11 k15y06n-1.
Page 13: To Match Light The Grill
To match light the grill 1. If the burner will not light after several attempts then the burner can be match lit. 2.You’ve just attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. Keep your face and hands as far away from the grill as possible. Inser...
Page 14: Lighting Instruction
Lighting instruction 1. Become familiar with safety guidelines in front of the manual. Do not smoke while lighting the grill or checking gas supply connections. 2. Check that each burner is tightened into its properly location in front of each valve orifice. 3. Make sure all gas connections are secu...
Page 15: Operating Instructions
Operating instructions burn-off: before cooking on your gas grill for the first time, burn off the grill to get rid of any odors or foreign matter by igniting the burners, closing the lid, and operating at a “hi” setting for about five minutes. You may then either set the controls to “off” or cook o...
Page 16
Lighting illustrations step 1: make sure the lid is open 14 main & side burner lighting illustration step 2. Push and turn main or side burner knobs to ”ignite/hi” ignition. Pilot torch will light. Hold for 3~4 seconds until burner is lit. Step 3. You may need to try 3 or 4 times to light the burner...
Page 17: Cleaning and Maintenance
Cleaning and maintenance burner cleaning 1. Wire brush entire surface of burner to remove food residue and dirt. 2. Clean any clogged ports with a stiff wire such as an open paper clip. 3. Inspect the burner for damage (cracks or holes) and if such damage is found, order and install a new burner. Af...
Page 18: Trouble Shooting
Trouble shooting problem solution when i light the grill it does not flame immediately . --make sure you have turn on the gas --make sure it has spark while you are trying to ignite the burner. --push in for approximately 5 second before to turn and ignite the grill. --make sure your burner is clean...
Page 19
Rotisserie motor will not turn --check the voltage at the outlet. --if an extension cord is required, ensure it is a 16 gauges, grounded cord. --ensure the on/off switch is on. --ensure the load does not exceed the 40 pounds operational capacity. --ensure the spit is fully inserted in the motor. --e...
Page 20: Exploded View
Exploded view 22 21 20 19 18 01 02 03 36 37 60 61 62 72 06 07 52 51 71 08 09 10 14 15 16 23 25 26 27 28 42 43 44 45 46 47 49 55 57 58 59 68 31 32 33 34 73 74 75 78 79 80 40 39 82 50 81 77 30 83 38 70 76 67 41 49 05 05 76 29 35 24 79 81 81 81 48 63 64 65 66 56 54 53 17 12 13 11 69 82 04 04 18 k15y06n...
Page 21: Model 730-0289 Parts List
Model 730-0289 parts list r r e e f f # # d d e e s s c c r r i i p p t t i i o o n n q q ’ ’ t t y y r r e e f f # # d d e e s s c c r r i i p p t t i i o o n n q q t t y y 0 0 1 1 m m a a i i n n l l i i d d 1 1 4 4 3 3 d d o o o o r r m m a a g g n n e e t t 1 1 0 0 2 2 t t e e m m p p e e r r a ...
Page 22: Grilling Hints
Grilling hints the doneness of meat, whether rare, medium, or well done, is affected to a large degree by the thickness of the cut. Expert chefs say it is impossible to have a rare doneness with a thin cut of meat. The cooking time is affected by the kind of meat, the size and shape of the cut, the ...
Page 23: Grill Cooking Chart
Grill cooking chart food weight or thickness flame size approximate time special instructions and tips vegetables fresh slice. Dot with butter or margarine. Wrap in heavy-duty foil. Grill, turning occasionally. Beets medium 12 to 20 minutes carrots turnips grill, turning once. Brush occasionally wit...
Page 24
Rib eye, food weight or thickness flame size approximate time special instructions and tips tenderloin, porterhouse, t-bone, sirloin rare 1 inch high 8 to 14 minutes remove excess fat from edge. Slash remaining fat at 2-inch intervals. Grill, turning once. 1-1/2 inch high 11 to 18 minutes medium 1 i...
Page 25
Halved or medium 40 to 60 minutes quartered well- done breasts well- done medium 30 to 45 minutes food weight or thickness flame size approximate time special instructions and tips fish and seafood steaks grill, turning once. Brush withmelted butter, margarine or oil to keep moist. Halibut 3/4 to 1 ...
Page 26: Grill Recipe Suggestions
Grill recipe suggestions bbq salmon 2 large salmon steaks 2 tbs. Oil salt & pepper 2 oz. Thin bacon slices 2 tbs. Butter 1 tbs. Lemon juice spring of parsley lemon wedges preheat the bbq. Brush the steaks with oil and season with salt and pepper. Place on bbq grill and cook for 10 minutes, turning s...
Page 27
4 cups thinly sliced potatoes (4 medium-sized potatoes) preheat grill. Combine cheese, condensed soup, milk, bbq sauce, oregano, salt and pepper in a large mixing bowl. Stir in potatoes until well coated. Turn into well buttered1-1/2 quart rectangular baking dish. Cover dish with aluminum foil. Bake...
Page 28
On the spit running the rod on the fleshier side of the bone. Rotis using the rotis burner. Cook on medium high heat for 40 minutes basting occasionally with the remainder of the marinade mixture. Serve with sliced onions and lemon wedges. Spare ribs marinade: 1 c. Soy sauce ½ c. Honey ½ c. Vinegar ...
Page 29
Limited warranty model 730-0289 stainless steel outdoor gas grill nexgrill industries, inc. Warrants to the original consumer purchaser of each outdoor gas grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below. This wa...