Charmglow Drop-In Side Burner Owner's Manual - Assembly Instructions

Manual is about: Outdoor Gas Side Burner

Page of 15

Download

Print this page

Bookmark us

READ ALL SAFETY WARNINGS & ASSEMBLY INSTRUCTIONS CAREFULLY

BEFORE ASSEMBLING OR OPERATING YOUR GRILL.

No tools are required to assemble this

Natural Gas Drop-In Side Burner:

PARTS LIST:

Cooking Grate

Side Burner Assembly

(Proof of purchase will be required.)

Inspect contents of the box to ensure all parts are

included and undamaged.

FOR MISSING PARTS, PLEASE CALL CUSTOMER

SERVICE AT 800-527-0717.

Battery

Grease Tray

ASSEMBLY INSTRUCTIONS

Placement Of The Grill

Location

When determining a suitable location take into account concerns such as exposure to wind,

proximity to traffic paths, and keeping gas supply lines as short as possible. Place the grill in well

ventilated areas. Never locate the grill in a building, garage, breezeway, shed or other such

enclosed areas. During heavy use, the grill will produce a lot of smoke. For your comfort, we

recommend a finished height for your grill base of 36 to 38 inches (91.4 to 96.5 cm) and a

minimum of 12 inches (30.5 cm) on either side of your grill.

Clearance

Non-combustible Construction

A minimum of 6 inches (15.3 cm) clearance from the back of the side burner to non-combustible

materials are required for the lid to open fully.

Ventilation

We recommend that adequate ventilation be incorporated into your built in grill base. Vents

should be placed on both sides of your grill base. The upper vent opening should be at least

20 square inches (129 cm

) and located within 5 inches (12.7 cm) of the top edge of your grill

base. The lower vent opening should be at least 10 square inches (64.5 cm

) and located within

1 inch (2.5 cm) or less from floor level of your grill base.

« ‹ Prev 9 10 11 12 13 14 15 Next › »

Summary of Drop-In Side Burner

Page 1
Side b urne r outdoor gas side burner / hornilla lateral a gas para uso al aire libre warning/advertencia hazardous explosion may result if these warnings and instructions are ignored. Read and follow all warnings and instructions in this manual to avoid personal injury, including death or property ...
Page 2: Important Safety
1 we want you to assemble and use your side burner as safely as possible. The purpose of this safety alert symbol is to attract your attention to possible hazards as you assemble and use your side burner. When you see the safety alert symbol pay close attention to the information which follows! Read...
Page 3: Table of Contents
2 table of contents danger: indicates an imminently hazardous situation which, if not avoided, will result in death or serious injury. Warning: be alert to the possibility of serious bodily injury if the instructions are not followed. Be sure to read and carefully follow all of the messages. Caution...
Page 4: Warning
3 warning • never use liquid propane gas (lp) in a unit designed for natural gas. • never use charcoal briquets or lighter fluid in a gas side burner. • leak test all connections before first use, even if side burner was purchased fully assembled and after each time the hose is connected to natural ...
Page 5: Warning
4 warning • for outdoor use only. Do not operate indoors or in an enclosed area such as a garage, shed or breezeway. • use your side burner outdoors in a well ventilated space away from dwellings or other buildings to prevent dangers associated with gas accumulation and toxic vapors. We recommend yo...
Page 6: Warning
Checking for leaks: 1. Create a mixture of 50% water and 50% liquid dishwashing soap. 2. Open the lid. 3. Insure all burner knobs are set to the off position. 4. Turn on the natural gas supply. 5. Apply the soap water mixture to the following: quick-disconnect coupler plug and hose connection the fu...
Page 7: Warning
6 warning pre-start check list: property damage, bodily harm, severe burns, and death could result from failure to follow these safety steps. These steps should be performed after the side burner has been assembled, stored, moved, cleaned, or repaired. Do not operate this side burner until you have ...
Page 8: Caution!
Turning off the side burner: 1. Turn off the natural gas supply. 2. Turn all burner control knobs to the "off" position. Note: turn off natural gas supply first to prevent gas from being left in the system under pressure. 7 match lighting the side burner: 1. Open the lid to the side burner before li...
Page 9: Proper Care & Maintenance
8 grilling to proper temperature • use a meat thermometer to be sure food has reached a safe internal temperature. You may order a commercial-quality thermometer from brinkmann. For more information on this product and other brinkmann accessories, please refer to the accessory pages at the end of th...
Page 10
9 burner assembly/maintenance (continued) • although your burner is constructed of brass and cast iron, it may corrode as a result of the extreme heat and acids from cooking foods. Regularly inspect the burner for cracks, abnormal holes, and other signs of corrosion damage. If found, replace the bur...
Page 11: Warning
10 • burner will not light • fire at control knob • yellow flames at burner • flame blows out on "low" • burner is too hot transporting and storage: • never move a grill when it is hot or when objects are on the cooking surfaces. • make sure that the natural gas supply is shut off. After moving the ...
Page 12: Frequently Asked Questions
11 your grill's serial number and model number, and the contact information for brinkmann customer service, are listed on a silver label found on the back of the grill or on the grill body side, under the side shelf. These questions and answers are for your general knowledge, and may not be applicab...
Page 13: Assembly Instructions
12 read all safety warnings & assembly instructions carefully before assembling or operating your grill. No tools are required to assemble this natural gas drop-in side burner: parts list: 1 cooking grate 1 side burner assembly 1 2 (proof of purchase will be required.) inspect contents of the box to...
Page 14: Front View
13 warning: do not install this unit into combustible enclosures. Maintain a minimum clearance of 36 inches (91 cm) between all sides of grill and walls or other combustible material. Do not use grill under overhead unprotected combustible construction. 18 2 ” 6” 36” - 38” 12” 12 w ” 5” 9 2 ” 1” 12”...
Page 15
14 hose connection after dropping in the side burner, run the side burner hose fitting through the side hole and pull hose through as far as possible. Then connect it to the quick-disconnect coupler . Quick-disconnect coupler side burner hose fitting side hole battery installation remove burner igni...