Owner’s manual / manual del propietario warning/advertencia hazardous explosion may result if these warnings and instructions are ignored. Read and follow all warnings and instructions in this manual to avoid personal injury, including death or property damage. Se puede producir una explosiÓn peligr...
1 we want you to assemble and use your grill as safely as possible. The purpose of this safety alert symbol is to attract your attention to possible hazards as you assemble and use your grill. When you see the safety alert symbol pay close attention to the information which follows! Read all safety ...
2 general warnings . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 installation and lp cylinder specifications and safe use . . . . . . . . . . . . . . 4-6 connecting lp cylinder and hose / regulator to grill . . . . . . . . . . . . . . . . . 6-7 leak te...
3 warning • never use natural gas in a unit designed for liquid propane gas. • never use charcoal or wood briquets in a gas grill. Flavoring chips must be contained in a metal smoking box to contain ash and prevent fires. • leak test all connections before first use, even if grill was purchased full...
4 warning installation information: the installation of this appliance must be in accordance with: all applicable local codes, or in the absence of local codes, either: • national fuel gas code ansi z223.1 nfpa 54 • natural gas and propane installation code: can/cga b149.1 • natural gas installation...
5 5 the cylinder must also be equipped with: • a shut-off valve terminating in a type 1 gas cylinder valve outlet. • the nominal cylinder height = 18 inches (45.7 cm), diameter = 12 inches (30.5 cm) and bottom ring diameter = 8 inches (20.3 cm). • a type 1 valve that prevents gas flow until a positi...
6 filling the lp gas cylinder: • allow only qualified lp gas dealers to properly fill or repair your lp gas cylinder. • new tanks should be purged prior to filling; inform lp gas dealer if you are using a new tank. • do not allow the cylinder to be filled beyond 80% capacity. Over-filled tanks can c...
7 warning • never use your grill without leak testing all gas connections and hoses. See the section on "leak testing" in this manual for proper procedures. The pressure regulator and hose assembly supplied with your gas grill must be used. • do not attempt to connect grill, as purchased for lp (pro...
Leak testing: to prevent fire or explosion hazard: • do not smoke or permit ignition sources in the area while conducting a leak test. • perform test outdoors only in a well ventilated area. • never perform a leak test with a match or open flame. • never perform a leak test while the grill is in use...
9 warning 6. Check each place listed (a–h) for growing bubbles which indicates a leak. 7. Turn off gas supply at cylinder valve. 8. Tighten any leaking connections. 9. Repeat soapy water test until no leaks are detected. 10. Turn off gas supply at cylinder valve until you are ready to use your grill...
10 lighting instructions: follow the instructions exactly. 1. Open the grill lid before attempting to light a burner so that fumes do not accumulate inside the grill. An explosion could occur if grill lid is closed. 2. Make sure that all burners are off. The red indicator light above the on/off swit...
Turning off the grill: 1. Turn off the cylinder valve. 2. Make sure that all burners are off. The red indicator light above the on/off switch for the burners should not be lit. Note: turn off lp cylinder first to prevent gas from being left in the system under pressure. Caution: • the cylinder valve...
Warning 12 refrigerator power cord control box power cord built-in electrical outlet convention oven power cord built-in electrical outlet power cord on/off switch of built-in electrical outlet built-in electrical outlet box cover (pull up) using other features of the grill: using the built-in elect...
Warning • when the “start/stop” indicator light is on, the convection oven is activated. • appliance surfaces are hot during and after use. Always wear protective, insulated oven mitts when touching hot oven or hot dishes and food, or when inserting or removing the bake rack, bake pan, or other baki...
14 grill cooking tips cleanliness • always wash hands thoroughly with soap and hot water prior to handling food and after handling raw meat, uncooked poultry or seafood. • when using a platter to carry raw meat, uncooked poultry or seafood to the grill, make sure to wash the platter thoroughly with ...
• to protect your grill from excessive rust, the unit must be kept clean and covered at all times when not in use. • wash cooking grills and heat distribution plates with hot, soapy water, rinse well and dry. Lightly coat cooking grill with vegetable oil or vegetable oil spray. • clean inside and ou...
Burner assembly/maintenance • although your burners are constructed of stainless steel, they may corrode as a result of the extreme heat and acids from cooking foods or from the climate your grill is exposed to. Regularly inspect the burners for cracks, abnormal holes, and other signs of corrosion d...
Transporting and storage: • never move a grill when it is hot or when objects are on the cooking surfaces. • make sure that cylinder valve is shut off. After moving the grill check that all gas connections are free of leaks. Refer to instructions for leak testing. • do not store a spare lp gas cylin...
18 trouble shooting problem: possible causes: 1. Check lp cylinder fuel level. 2. Bad electrode spark. Check to see if the grill will match light. Electrode or collector may need adjustment. 3. Burner may not be properly seated. 4. Burner may be obstructed. 5. The cylinder valve may be closed. 6. Re...
Your grill's serial number and model number, and the contact information for brinkmann customer service, are listed on a silver label found beneath the control panel, on the back of the grill or on the side of the grill body, under the side shelf. These questions and answers are for your general kno...
20 cleaning stainless steel cooking grills: wash grills with a mild detergent and rinse with hot water before initial use and as needed. Do not use a commercial oven cleaner. For stubborn food residue, use a degreaser and fiber or brass cleaning brush. Cleaning porcelain-finished cast-iron cooking g...
Assembly instructions read all safety warnings & assembly instructions carefully before assembling or operating your grill. We recommend two people work together when assembling this unit. The following provided tools are required to assemble this charmglow ® gourmet gas grill with electronic contro...
22 (proof of purchase will be required.) inspect contents of the box to ensure all parts are included and undamaged. For covers, accessories and other products, please visit us online at: www.Brinkmann.Net for grill warranty replacement parts, please visit us at: www.Grillpartsonline.Com.
Adjustment screws choose a good, cleared assembly area and get a friend to help you put your grill together. Lay cardboard down to protect grill finish and assembly area. Caution: some parts may contain sharp edges. Wear protective gloves if necessary. Step 1 insert the side table into the slot of t...
Step 4 place the heat distribution plates on the lower ledge above the burners. Step 5 place the cooking grills on the ledge above the heat distribution plates. Step 6 insert the rear of warming rack to the holes in back panel, and the front legs of warming rack rest in rotisserie cutouts on left an...
Charmglow ® 8640 (assembled) 25.
Replacement parts list 8640-1 hood inner panel 8640-2 hood handle 8640-3 logo 8640-4 temperature gauge 8640-5 hood 8640-6 refrigerator 8640-7 beam kit 8640-8 trim boxes 8640-9 left door kit 8640-10 right door kit 8640-11 heat-insulation panel for refrigerator 8640-12 side shelf bracket kits 8640-13 ...
27 8640-33 main burner gas tube-r 8640-34 thermocouple 8640-35 motor mount bracket kit 8640-36 rotisserie motor kit 8640-37 control box 8640-38 right side shelf 8640-39 main burner gas tube cover kit 8640-40 seal washer panel 8640-41 seal washer 8640-42 main burner orifice viewing hole lids 8640-43 ...
Charmglow dist. By home depot u.S.A. Inc. 2455 paces ferry road n.W. Atlanta, ga 30339-4024 ©2007 the brinkmann corporation dallas, texas 75244 u.S.A www.Brinkmann.Net 140-8640-s 12/07 owner’s manual for model manual del propietario para el modelo 810-8640-s the brinkmann corporation warrants to the...
