Summary of DSA-099L
Page 1
Manual de servicio split acondicionador de aire modelo :.
Page 2: Contents
Contents p 1 1 contents.....................................................................................1 service and maintenance ..........................................................2 exploded views and part list .....................................................17 disassembly and reass...
Page 3: Service And Maintenance
1 1 3 3 2 2 1 1 3 3 2 2 air conditioner no use for a long time. Start fan only for 3-4 hours to comple- tely dry the inside of the indoor unit. Set cool mode or heat mode, and select the highest setting tempera- ture, then fan turns. Turn off air conditioner, unplug the power plug. Otherwise, the ac...
Page 4: Service And Maintenance
3 3 1 1 1 4 4 3 3 2 2 1 1 4 4 3 3 2 2 filters should be cleaned once every two weeks. Take out filters. Clean filters with a vacuum cleaner or by typing them gently. ( if they are very dirty, wash them in warm water below 45 dissolved with neutral scouring agent.) clean filters with clean water, the...
Page 5: Controls Specification
Controls specification 1 1 2 2 abbreviation ts: setting temperature tr: room temperature ti: indoor defrost sensor temperature to: outdoor defrost sensor temperature operation of main board cool mode if tr > ts, cool operation is activated. Compressor and outdoor fan are turned on. Indoor fan runs a...
Page 6: Controls Specification
Outdoor de-ice after 40 minutes of continuous heating operation, if to -4 , the outdoor de-ice operation is activated. Compressor is turned off. Indoor fan speed reduces to low speed. After 30 seconds delay, 4 way value and outdoor fan will be turned off, indoor fan reduces to low speed, 15 seconds ...
Page 7: Controls Specification
Timer timer off can only be set when the system is operating. Timer on can only be set when the system is off. The maximum set time is 12 hours. Changing of on/off state will cancel timer mode. Sleep mode in cool mode, after sleep mode is set, ts will increase 1 in first hours, will increase 2 in se...
Page 8: Controls Specification
Manual swing (stepping motor) if the indoor fan is operating, the louver will swing or can be stopped at a preferred location in any mode. The louver change location follow the order of : if a command is received, the system will respond with a beep. Buzzer in cool mode, if tr-ts if 0 no change in s...
Page 9: Controls Specification
Manual operation button 3 3 operation of control panel on indoor unit every press of this button will turn the system on or off. System led light when system is operating, the run light is on. When system is off, the light is off. (cool only type) every time the switch is pressed, it changes in sequ...
Page 10: Indoor Unit
Stop operation of the air conditioner and remove the power cord before repairing the unit indoor unit disassembly and reassembly no parts procedure remark 1 front grille 1.Stop the air conditioner operation and block the main power. 2.Contract the second finger to the left ,and right handle and pull...
Page 11: Disassembly And Reassembly
Disassembly and reassembly 10 10 4.Separate the electrical box from the indoor unit. 1.Loosen the earth screw in evaporator. 2.Loosen the s ull softly the indoor pipe temperature sensor out from the pipe casing. Tepping motor line, and p no parts procedure remark 3.Push the hook outside to take the ...
Page 12: Disassembly And Reassembly
Disassembly and reassembly 3.Separate the evaporator from the indoor unit. 4 evaporator 2.Separete the ass’y tray drain from the body. 1.Push the left hook and separate the left part out of evaporator. 1.Separate the fan motor from the fan. No parts procedure remark 2.Push the right hook and separat...
Page 13: Disassembly And Reassembly
Disassembly and reassembly 1 cabinet 1.Turn off the unit and remove the power cable. 2.Remove the upper cabinet, the front cabinet and back cabinet. 2.Separate the propeller fan from fan motor. 1.Remove the nut flange. (turn to the right to remove as it a left turned screw ) 1.Loosen the fixing scre...
Page 14: Outdoor Unit
1 cabinet 1.Turn off the unit and remove the power cable. 2.Remove the upper cabinet, the front cabinet and back cabinet. 2.Separate the propeller fan from fan motor. 1.Remove the nut flange. (turn to the right to remove as it a left turned screw ) 1.Loosen the fixing screw of the base-electrical co...
Page 15: Disassembly And Reassembly
Disassembly and reassembly 2.Loosen the nut flange on compressor. 3.Separate the connector. 4.Separate the ass' y control out from the outdoor unit. No parts procedure remark 14 14.
Page 16: Troubleshooting
If problems can not be corrected after doing below items, please stop the air conditioner, contact our air conditioner specially eng- aged service centre nearest to you to get help. Is there a fault ? Fault analysis air conditioner does not operate at all. Does power fail ? Is plug out ? Does power ...
Page 17: Troubleshooting
Indoor unit fan stops for about 10 minutes during heating. It is defrosting of the outdoor unit coil.It should complete this process in about 10 minutes at most.( it freezes when outdoor temperature is low and humidity is high. ) issues cracking sounds the friction sounds caused by expansion and con...
Page 18: Indoor Unit
Exploded views and parts list indoor unit 17 17 dsa-099l dsa-129l.
Page 19: Indoor Unit
Exploded views and parts list indoor unit 18 18 dsa-099l dsa-129l n o . Part name quantity item code 1. Righ t air filte r 1 kfr25g.1.1.2-5(a1-gb40) 2 display board 1 kfr32g.2.1-3(791) 3 display control box cover 1 kfr32g.2.1-1(791) 4 decoration board 1 kfr32g.1-2 5 electrical control cover 1 kfr25g...
Page 20: Outdoor Unit
Exploded views and parts list outdoor unit 19 19 dsa-099l dsa-129l.
Page 21: Outdoor Unit
Exploded views and parts list outdoor unit 20 20 dsa-099l dsa-129l no. Part name quantity item code 1. Air outlet grille 1 kfr20w.1.1-2 2 front panel 1 kfr20w.1.1-1 3 left handle 1 sl05-01 4 top panel 1 kfr20w.1.2-1 5 fan screw nut m6 (left revolve) 1 gb41-86 6 outdoor fan 1 kfr20w.1.5.1 7 outdoor f...
Page 22: Indoor Unit
Exploded views and parts list indoor unit 21 21 dsa-189l.
Page 23: Indoor Unit
Exploded views and parts list indoor unit 22 22 dsa-189l n o . P a r t n a m e quantity item code 1 . C o n n e c t i n g b o a rd o f m o u n t i n g p la t e 1 k f r 3 6 g . 9-2 ( d 9-1 3 0 ) 2 m o u n t i n g p la t e 2 k f r 3 6 g . 9-1 ( d 9-1 3 0 ) 3 p i p e f ix i n g p la t e 1 1 k f r 3 6 g...
Page 24: Outdoor Unit
Exploded views and parts list outdoor unit 27 1 15 16 18 26 20 19 24 23 22 21 25 7 8 9 10 11 12 13 14 17 6 5 4 3 2 1 23 23 dsa-189l.
Page 25: Outdoor Unit
Exploded views and parts list outdoor unit 24 24 dsa-189l no. Part name quantity item code 1. Air outlet grille 1 kfr35w.1.2-3(g1-1) 2 fan screw nut 1 ld06-04 3 left handle 1 kfr35w.1.2-4(g1-1) 4 front panel 1 kfr35w.1.2-1(g1-1) 5 outdoor fan 1 lf51w.1.5.2(g1-5) 6 partition 1 kfr35w.1.6-1(g1-1) 7 ou...
Page 26: Remote Controller
Remote controller 1 1 2 2 3 3 4 4 5 5 6 6 7 7 8 8 10 10 quantity 1 1 1 1 1 1 1 1 1 1 4 ass’y pcb remocon screw case up conduct rubber inlay lcd lcd screen spring battery name back body number 11 10 1 2 3 4 5 6 7 8 9 back cover conduct rubber 9 9 11 11 spring battery exploded views and parts list 25 ...
Page 27: Wiring Diagram
Wiring diagram 26 26 pipe thermistor room thermistor.
Page 28: Block Diagram
D r iv e a /o c o n v e r t e r m a il p c b l e d p c b r e m o t e c o n t r o l l e r a c p o w e r in p u t o u td o o r f a n m o to r 4 .7 5 v 1 2 v r e m o te a n d e m e rg e n c y m o d e s le c to r s le e p la m p t im e r la m p t e m p e ra tu re la m p h e a tin g la m p c o o lin g la...