- DL manuals
- E-TON
- Offroad Vehicle
- ROVER
- Owner's Manual
E-TON ROVER Owner's Manual
Summary of ROVER
Page 1
Owner’s manual e e - - ton ton rover & rover gt e e - - ton e ton e - - ton e ton e - - ton e ton e - - ton e ton e - - ton e ton e - - ton e ton e - - ton ton rover rover gt copyright ©2008-2009 eton america, all rights reserved..
Page 2: Rover
Rover (safety nets) rover (brush guards) rover gt e-ton rover c o n f i g u r a t i o n s copyright ©2008-2009 eton america, all rights reserved..
Page 3: Important Notices
Obey all state and local laws and regulations speed restriction devices read and understand this owner's manual no passengers adult supervision and instruction are required. Always wear protective clothing off road use only both the operator and the adult supervisor should completely read and unders...
Page 4: Table of Contents
Table of contents table of contents page 2 safety notes vehicle identification number control feature key switch throttle pedal brake pedal parking brake lever fuel system fuel tank fuel valve inline fuel filter engine oil tires and wheels tire & wheel inspection tire pressure spark plug spark arres...
Page 5: Safety Notes
Safety notes safety notes 1. Both the adult supervisor and youth operator must fully understand everything in this manual 2. This vehicle was designed for the operator only. No passengers should be allowed on 3. This vehicle is designed for operation on level, obstacle free off-road areas. 4. Riding...
Page 6: Safety Notes
Safety notes safety notes 13. Never ride this vehicle unless it has 14. Warn up your body with some exercises before riding. This helps to make you alert and prevent cramping and other discomfort. 15. Learn to ride this vehicle properly and safely. Have an experienced rider teach you the safe operat...
Page 7: Safety Notes
Safety notes safety notes 18. Hot! The engine and exhaust system on your vehicle become very hot during normal operation. Touching these hot surfaces can cause sever burns. Always assume that your units engine and exhaust system are hot unless you know that they are not. 16. Never refuel this vehicl...
Page 8: Additional Safety Tips:
Additional safety tips: pre-ride inspection - inspecting the condition of your vehicle before each ride is very important to minimizethe chance of injury and maximize the enjoyment of your ride. It also helps ensures long term performance of your vehicle. Follow the owner's manual guide to inspectio...
Page 9: Your Vin
Engine serial number is located on the left-hand side of the engine on the crankcase housing. Vehicle identification number (vin) is located at the right of the frame and approaches the front wheel. Vehicle identification numbers your vin eng. No. Page 7 controls, switches & feature locations 5. Thr...
Page 10
Controls, switches & feature locations locations of controls and features 14. Fuel tank filler and vent tube 13. Front cargo box 15. Rear cargo box page 8 15 15 13 13 14 14 9 9 8 8 12 12 11 11 10 10 9. Manual chocke knob 8. Brake oil reservoir 12. Transmission gear selector & reverse indicator lamp ...
Page 11: Key Switch
A - off position - with key in off position,all switched power is off,and engine should not run. Key switch manual chocke knob b - on position - turn key from off to the position and all switched power circuits will be energized. C - start position - turn key to start position to start the engine .R...
Page 12: Brake Pedal
Parking off parking off parking on parking on brake pedal this vehicle is equipped with dual front hydraulic discl brakes and a rear hydraulic disc brake. Parking brake lever the parking brake is shown on the picture. This should be engaged as a parking brake whenever the vehicle is not in operation...
Page 13: Fuel Tank
Page 11 fuel tank fuel system the fuel tank fill cap is located on top of the back of the seat. The cap contains a vent to prevent a vacuum from forming in the tank as fuel is used. The vent tube must be attached to the cap and inserted in the vent tube holder hole the fuel cap vent and vent tube mu...
Page 14: Inline Fuel Filter
Inline fuel filter this vehicle is equipped with an inline fuel filter to prevent dirt and debris from entering the carburetor and engine. Check the filter for dirt or damage before each ride and at each refueling. Replace the filter if dirty or damaged. The filter should be replaced every 600 hours...
Page 15: Transmission Gear Selector
Transmission gear selector the vehicle is equiped with a transmission gear selector switch mounted on the dash- board. The switch has three positions ("r", "n","f"). "r" = reverse "n" = neutral "f" = forward the selector must be placed on "n" to start the engine. Once the engine is started, engine t...
Page 16: Tire Pressure
Always check the pressure when the tires are cool. Use the tire pressure gauge that came with your vehicle to check the tire pressure. Tire pressure wheel nut torque 24-30 n/m (18-22 lb/ft) recommended tire pressure is: front min max 2 3.2psi / 0.23kg/cm 2 4.0psi / 0.28kg/cm 2 3.2psi / 0.23kg/cm 2 4...
Page 17: Rover
Engine type four cycle air cooled (epa compliant) sohc displacement 88.4cc bore / stroke φ47.0 * 51.0mm compression ratio / pressure 10.2 : 1 / 120-140psi torque / bhp 6.5n ms @ 6500rpm / 4.8bhp epa approved meet or exceeds epa clean air requirements and ca green sticker spark plug recommended: ngk ...
Page 18: Rover
Sprockets front 520x12t rear 520x32t chain #520 battery jell acid (maintenance free) 12v-4ah/ah - gtx5l fluids fuel type unleaded gasoline 92 octane volume 11liters / 2.9gal engine oil type sae 15w-40 volume 0.9liters / 0.23gal transmission type sae 80w-90 volume 300cc / 10.2oz safety features speed...
Page 19: Rover Gt
Engine type four cycle air cooled (epa compliant) sohc displacement 88.4cc bore / stroke φ47.0 * 51.0mm compression ratio / pressure 10.2 : 1 / 120-140psi torque / power 6.1n ms @ 4000rpm / 6.4ps/8000rpm epa approved meet or exceeds epa clean air requirements and ca green sticker spark plug recommen...
Page 20: Rover Gt
Safety features seat belt lap belt (standard) remote stop switch remote engine stop switch (optional) carrying capacity maximum rider weight 100kg / 200 lbs additional features rear cargo flat bed (standard) digital dash gauge—speedometer & fuel level (standard) covered front storage compartment das...
Page 21: To Clean The Filter
To maintain the highest performance from your engine and to reduce excessive wear that could cause engine failure the engine requires a continuous flow of clean air. Air is taken into the engine through an air filter to clean the air prior to mixing it with fuel and oil in the carburetor. During nor...
Page 22: Braking Systems
The vehicle is equipped with dual front hydraulic disc brakes and a rear hydraulic disc brake. The four wheel simultaneously brakes are operated by pushing the foot brake pedal. Proper maintenance of the brake system is a necessary part of safe operation of your unit. The brake systems should be ins...
Page 23: Purging Brake Lines
Purging brake lines the front caliper refold the cover gasket as shown in picture and replace cover. For the hydraulic brake system to operate safely, the brake system must be purged of air in the lines and reservoir. To bleed the air will require two people to perform the following procedure. 1. Pl...
Page 24: Drive Chain
Drive chain the drive chain will stretch with use and will require periodic adjustments. To check the chain tension, remove the chain guard and measure the slack. The amount of slack in the chain should not exceed 5-10mm or 0.2" - 0.4". Inspect the drive and axle sprockets for worn, damaged or broke...
Page 25: Electrical Battery
Electrical battery the unit's battery is located the left-hand side of the seat and supplies electrical power to the unit. The battery is a 12 volt jell acid type that contains no liquid electrolyte. The battery should be removed from the vehicle when stored for extended periods and charged before b...
Page 26: Changing Engine Oil
Engine oil drain engine oil drain changing engine oil 1. Place an oil catch pan under the unit directly below the engine crankcase. 2.Remove the engine oill drain plug located on the left-hand side of the engine. 3. Remove the engine oil dipstick located on the right-hand side of the engine. 4. Allo...
Page 27: Spark Plug
Replace spark plug at the beginning of each season with a replacement plug cr7hsa / ngk. Spark plug 1. After every 100 hours of operation the muffler should be cleaned by removing the clean out bolt by using a 10mm wrench. 2. After every 60 hours of operation the spark arrester has to be cleaned by ...
Page 28: Maintenance Schedule
Maintenance schedule i = inspect, clean, adjust, lubricate or replace as needed c= clean l = lubricate r = replace owners maintenance records maintenance preformed date preformed by note: e-ton recommends that all maintenance and inspections be performed only by a qualified and fully trained technic...
Page 29: Pre-Operation Inspection
Pre-operation inspection procedures the following procedure must be performed before each operating session. Checking your vehicle takes only a few minutes and may save you from serious injuries and costly repairs. 1. Check engine oil level. 2. Check engine fuel level. 3. Check brake operations and ...
Page 30: Driving Your Vehicle
Driving your vehicle your vehicle should only be driven in an area that is designated for this use. Insure that the area is free of obstacles and other dangers that could cause a loss of control. Check with your local authorities for any regulations regarding the use of your vehicle. Always keep you...
Page 31
Page 27 wiring diagram rover copyright ©2008-2009 eton america, all rights reserved..
Page 32
Page 28 wiring diagram rover gt copyright ©2008-2009 eton america, all rights reserved..
Page 33: Eton America, Llc.
Eton america, llc. Limited vehicle warranty eton america warrants all new eton vehicles sold by authorized eton dealers to be free from defects in materials and workmanship, subject to the following exclusions and limitations. New vehicles sold by an authorized dealer to original retail consumers ar...
Page 34: Eton America, Llc.
This warranty is valid at any authorized eton dealer in the united states only. In the event you experience any problem obtaining prompt service, contact eton america, customer service department for assistance. Always consult first with your selling dealer and or service personnel for assistance wi...
Page 35: Atv Limited Warranty
Eton america llc warrants each new scooter/moped vehicle that includes as standard equipment a taillight and a stoplight; a) is designed, built and equipped so as to conform at the time of initial retail purchase with all applicable regulation of the united states environmental protection agency ("u...
Page 36: Atv Limited Warranty
Eton america llc specifications which adversely affect performance and/or durability, (vi) alterations or modifications not recommended or approved in writing by eton america llc, and/or (vii) use in competitive racing or related events. B) replacement of parts and other services and adjustments req...
Page 37
Page 33 copyright ©2008-2009 eton america, all rights reserved..
Page 38: Taiwan, R.O.C.
E e - - ton e ton e - - ton e ton e - - ton e ton e - - ton e ton e - - ton e ton e - - ton e ton e - - ton e ton e - - ton ton e e - - ton e ton e - - ton e ton e - - ton e ton e - - ton e ton e - - ton e ton e - - ton e ton e - - ton e ton e - - ton ton e e - - ton e ton e - - ton e ton e - - ton ...