Summary of Golf Car
Page 3
Operation manual for electric golf car thanks for purchasing our electric golf cars. This manual contains information for proper operation and maintenance and care of your golf car. A thorough understanding of this manual will help you to obtain maximum enjoyment from this golf car. Please keep it p...
Page 4
Avoid turning the steering wheel too sharply at higher speed. Always drive slowly up or down on the incline. Do not make any modification or addition which may affect the capacity or safety children are not allowed to play in the car. Children should be seated between adults and protected by them wh...
Page 5
The electric system and motor will be damaged. Note: the buzzer will beep when the lower part of this switch is depressed to give warning to the people around your golf car. The accelerator pedal is used to control the speed to move the golf car. Press it down slowly to increase the speed. The car w...
Page 6
Starting: stopping: a) with the park brake applied, press the forward/reverse switch and lock it in the desired position. Caution! Do not shift from forward to reverse while the golf car is moving. B) turn the power key to on position. Do not step down the accelerator pedal when turning on the power...
Page 7
Re-charging will cause negative effect on the battery. Notes: the lead- acid battery does not develop a memory, so need not be fully discharged before recharging. B. If the golf car is going to be kept unused for a certain long time, the battery shall be fully recharged first. After that, the batter...
Page 8
9) read carefully the operation manual for the charger for detailed operation instructions. No explosive gas vapor is in the air, otherwise, it may cause serve injury and damage to your body and property if the explosive gas vapor contacts the sparks generated from the motor. 1) the carbon brush sho...
Page 9
Symptom(s) possible cause(s) troubleshooting the axle housing gear and bearing a r e d a m a g e d u n t i m e l y a n d there is too much noise on the final drive 1. The gear oil is out of use or used improperly 2.The bearing is assembled un correct 3. Adjust the brake shoe pin shim or the interval...
Page 10
The golf car. Make sure to turn off the power key and apply the park brake when you do the maintenance unless otherwise specified. If the owner is not familiar with the maintenance of this golf car, this work should be done by the dealer from who you get your golf car: warning! Be sure the mounting/...
Page 11
9. Storage 10. Wiring diagram please follow the steps as below when the golf car is stored. 1. Check the liquid level inside the battery, recharge it fully before storing the golf car. Please charge the battery once a month if your golf car will be stored more than one month. 2. Turn the power key t...
Page 12
C h a r g e r 9 1 1 1 1 4 1 3 1 5 1 2 s 2 1 6 3 8 6 7 4 5 9 1 0 1 2 s 1 2 1 0 t h r o t t le m - b - a 2 s 2 m s 1 a 1 b + c o n tr o ll e r 1 2 6 6 + 4 8 v b e t t e r y h h + - o s p e e d s e n s o r w a lk a w ay r e la y f 1 2 5 0a f u s e f2 10a m a in c o n t a c t o r r 5 0 0 o h m /5 w run/...