1. DL manuals
  2. Eagle Power
  3. Scrubber
  4. FASTRACTS SC12
  5. Operation And Parts Manual

Eagle Power FASTRACTS SC12 Operation And Parts Manual

Manual is about: 12 Gallon Extractor

Summary of FASTRACTS SC12

  • Page 1

    Electronic service manuals this electronic document is provided as a service to our customers. We do not create the contents of the information contained in this docu- ment. Should you have detailed questions pertaining to the information contained in this document, you may contact michco, or the ma...

  • Page 2: Sc12

    Operation and parts manual rev b 01/2003 sc12 fastracts sc12 12 gallon extractor.

  • Page 3

    Before operating the machine read the manual carefully and completely before attempting to operate the unit. This manual has important information for the use and safe operation of the machine. Keep this manual handy at all times. This machine will ensure years of satisfactory service if operated an...

  • Page 4

    I • use defoamer at all times to prevent damage to the vacuum motor(s). • do not use water in excess of 140°f (62°c). • use only commercially available carpet cleaners and defoamer intended for use with machines of this type. Do not use dyes, bleaches, ammonia or other additives. The use of powdered...

  • Page 5

    Note: if dirty solution does not appear through the vacuum lid check to be sure if: • the vacuum lid is resting properly on the recovery pails • the machine’s nose is touching the carpet in the working mode. • the solution tank is not empty. 4. Roll the machine forward on its four wheels for next st...

  • Page 6

    Maintenance the upright extractor is engineered for minimum maintenance. But it does require some care to keep it in optimum working condition. Careful attention to these maintenance instructions will give you maximum operating performance and life expectancy of the machine. • solution line, fitting...

  • Page 7

    Solution system problem possible cause pump motor on, no 1. Clogged spray tips. Spray thru carpet 2. Clogged solution intake filter screen. Spray tips or 3. Clogged solenoid valve or open solenoid coil. Accessory tool 4. If carpet spray works normally, plugged up female quick disconnect coupler. 5. ...

  • Page 8

    Brush drive belt service and/or replacement (refer to parts diagram). 1. Remove 2 1/4-20 hex screws attaching lower frame to upper frame. 2. Remove (2) spring cover plate assemblies and carefully remove springs from the slide blocks. 3. Loosen (2) 1/4-20 hex screws that hold brush motor bracket in p...

  • Page 9: Fastracts Sc12

    Fastracts sc12.

  • Page 10: Fastracts Sc12

    Fastracts sc12 fig. 2.

  • Page 11: Fastracts Sc12

    Fastracts sc12 fig. 5.

  • Page 12: Fastracts Sc12

    Fastracts sc12 fig. 6.

  • Page 13

    Parts list fastracts sc7 and sc12 item description part no. Qty. Fig. 1 clip, adapter retainer d02391 1 1 2 hose, adaptor d02359 1 1 3 seal, vacuum intake e02431 1 1 4 shaft, lid pivot d02373-1 2 1 5 spring, dome pivot d02372 1 1 spring, slide block d02372 4 2 6 vacuum lid assembly 80491-1a 1 1 7 ga...

  • Page 14

    Parts list fastracts sc7 and sc12 item description part no. Qty fig. 31 brush chamber assembly 82362a 1 2 32 90 elbow, 1/8 fp x 1/4 c a00144 2 2 33 glide, back, ss d02366 1 2 34 glide, front, ss d02365 1 2 35 slide block assembly 80500a 2 2 36 washer, slide block, 1/16 thk, 25/64 id, 2" od f00504 1 ...

  • Page 15

    Parts list fastracts sc7 and sc12 item description part no. Qty. Fig 63 vacuum motor mounting assembly (2 stage) 82291a 1 5 64 loom, corrugated, 26” f00463 1 5 65 vacuum motor, 2 stage, 5.7” dia, 115v 00537a 2 5 w/molex connector 66 cap, latch handle k00725 1 5 67 latch handle assembly 82355a 1 5 68...

  • Page 16

    Parts list fastracts sc7 and sc12 item description part no. Qty. Fig. 97 light, indicator, green lens b021916 1 6 98 grip, handle, black k00715b-1 2 6 99 boot, flex, circuit breaker b02193 1 6 (115v - 1req.) 100 spring, bracket, vacuum valve, assembly 1 101 spring, vacuum valve slide return 2 102 ha...

  • Page 17: Fastracts   Sc12

    Fastracts sc12.

  • Page 18

    Warranty policy limited warranty eagle power products (epp) warrants new cleaning equipment against defects in material and workmanship under normal use and service to the original purchaser as detailed below. 10 years subject to the conditions stated below, epp warrants polyethylene tanks and housi...