1. DL manuals
  2. EarthQuake
  3. Tiller
  4. 6015BCE
  5. Original Operating Instructions

EarthQuake 6015BCE Original Operating Instructions

Other manuals for 6015BCE: Operator's Manual
Manual is about: CRT ROTOTILLER

Summary of 6015BCE

  • Page 1

    Ardisam .Com getearthquake.Com om6015 rev. 11/05/10 © 2010 ardisam, inc. All rights reserved. 6015v viper engine 196 cc 6015vce (shown) viper engine 196 cc 6015bce briggs and stratton 205 cc original operating instructions 6015v, 6015vce, 6015bce crt rototiller.

  • Page 2

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 2 getearthquake.Com 800-345-6007 introduction thank you . . . For purchasing an earthquake® counter rotating rear-tine rototiller from ardisam, inc. We have worked to ensure that this rear-tine rototiller meets high standards fo...

  • Page 3

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 3 getearthquake.Com 800-345-6007 caution indicates you can or your equipment can be hurt if the safety instructions that follow this signal word are not obeyed. Safety owner’s responsibility accurate assembly and safe and effect...

  • Page 4

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 4 getearthquake.Com 800-345-6007 important the right and left sides of your rototiller are determined from the operating position as you face the direction of forward travel. Engine is shipped from factory without oil. You must ...

  • Page 5

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 5 getearthquake.Com 800-345-6007 part no. Lbl516c warning belt cover decal part no. Lbl516j tines danger hood flap decal safety decals this rototiller unit has been designed and manufactured to provide you with the safety and re...

  • Page 6: Important

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 6 getearthquake.Com 800-345-6007 unpacking and assembly your rototiller comes fully assembled except for a few parts. The following instructions will help you unpack your tiller and assemble and adjust your tiller’s depth regula...

  • Page 7

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 7 getearthquake.Com 800-345-6007 forward drive safety control lever detent pin forward cable recoil start wheel lock pin belt guard depth regulator lever features attach handlebar (6015vce, 6015bce, europe) 1. Locate handlebar e...

  • Page 8: Danger

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 8 getearthquake.Com 800-345-6007 operation pre-start inspection 1. Make sure all safety guards are in place and all nuts and bolts a r e secure. 2. Check oil level in engine crankcase. See your engine manual for procedure and sp...

  • Page 9

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 9 getearthquake.Com 800-345-6007 idle speed use the “low” position on the throttle lever to reduce stress on the engine when tilling is not being performed. Lowering the engine speed to “idle” will help extend the life of the mo...

  • Page 10

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 10 getearthquake.Com 800-345-6007 drive safety control lever forward lever engages wheels and tines into forward. Pulling the drive safety control lever toward the handlebar engages the wheels and tines. Releasing the lever stop...

  • Page 11

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 11 getearthquake.Com 800-345-6007 wheel lock pins place wheels in tilling position. 1. Remove lock pin. Align hole in axle with hole in wheel hub. (see figure 2) 2. Insert lock pin through holes, fold lock pin ring to secure pin...

  • Page 12

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 12 getearthquake.Com 800-345-6007 depth regulator lever tilling depth is controlled by the height of the depth regulator lever. To adjust tilling depth. (see figure 4) 1. Remove detent pin. 2. Raise the depth regulator lever to ...

  • Page 13

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 13 getearthquake.Com 800-345-6007 tilling tips the key to successful tilling is to begin with a shallow cut on the first pass, and then work an inch or two deeper on each successive pass. • tilling depth will vary with ground co...

  • Page 14

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 14 getearthquake.Com 800-345-6007 servicing the rototiller the following information will help you make the necessary checks and perform the procedures required to follow the normal care recommendations made for your rototiller ...

  • Page 15: Figure 6

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 15 getearthquake.Com 800-345-6007 belt replacement part #’s: 31315 (forward belt) change forward/reverse belt 1. Turn off engine. Engine must be cool. 2. Remove spark plug wire and secure from spark plug. 3. Remove belt guard. (...

  • Page 16: Important

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 16 getearthquake.Com 800-345-6007 engine maintenance refer to the engine manual included in your parts packet for information on engine maintenance. Your engine manual provides detailed information and a maintenance schedule for...

  • Page 17

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 17 getearthquake.Com 800-345-6007 lubrication proper lubrication of moving mechanical parts is critical for proper care and maintenance. Oil the moving parts at 10 hour intervals using a 30 weight oil. Clean tine axle shaft 1. T...

  • Page 18

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 18 getearthquake.Com 800-345-6007 troubleshooting troubleshooting guide while normal care and routine maintenance will extend the life of your rototiller, prolonged or constant use may eventually require that service be performe...

  • Page 19

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 19 getearthquake.Com 800-345-6007 problem remedy/action belts squeal in neutral • adjust forward belt guide: - turn engine off and allow muffler to cool - disconnect spark plug wire and secure from spark plug - remove belt guard...

  • Page 20

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 20 getearthquake.Com 800-345-6007 crt handlebar parts (model 6015v) 2 3 1 4 9 8 7 6 5.

  • Page 21

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 21 getearthquake.Com 800-345-6007 crt handlebar parts list (model 6015v) ref. No. Part # description qty. 1 3262 deadman, front tine weldment 1 2 53613 link, 9-1/2” long 1 3 53606 nut, 10-24 hex zn 1 4 53620 spring compression f...

  • Page 22

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 22 getearthquake.Com 800-345-6007 13 11 12 10 9 8 7 7 6 5 3 4 2 crt handlebar and hood parts (model 6015vce and 6015bce).

  • Page 23

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 23 getearthquake.Com 800-345-6007 ref. No. Part # description qty. 1 -- -- -- 2 2001 bolt 3/8-16 x 1/34 hh gr5 zn 4 3 1662 nut 3/8-16 nylock 4 4 31329 strap, handle bar extension ce 2 5 2102 bolt 3/8-16 x 1 hh gr5 zn 4 6 31335 c...

  • Page 24

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 24 getearthquake.Com 800-345-6007 crt motor mount parts 1 2 3 4 5 6 7 8 9 11 13 15 10 12 39 16 17 18 19 20 21 22 23 24 25 26 27 28 30 29 31 32 34 36 33 35 37 38 3 1 2 3 21 19 3 19 17 15 14 3 2.

  • Page 25

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 25 getearthquake.Com 800-345-6007 crt motor mount parts list (models 6015v, 6015vce, and 6015bce) r e f. No. Part # description qty. 1 810 bolt, 5/16-24 x 1 hh gr5 2 2 504 lockwasher, r-spring 5/16” 4 3 wf516 washer, flat 5/16” ...

  • Page 26

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 26 getearthquake.Com 800-345-6007 crt tines & hood parts (models 6015v, 6015vce and 6015bce) 4 5 6 7 8b 10 9 15 16 17 14 13 12 11 18 4 8a 4 7 11 24 2 19 1 2 3 23 20 21 21 22 23 25 14.

  • Page 27

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 27 getearthquake.Com 800-345-6007 crt tines & hood parts list r e f . No. Part # description qty. 1 417 bolt, 5/16-18 x 1/2 hh gr5 4 2 504 lockwasher, spring 5/16” 5 3 8930 bolt, 1/4-20 x 3/4 hh gr5 zn 6 4 1501 bolt, 5/16-18 x 3...

  • Page 28

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 28 getearthquake.Com 800-345-6007 crt wheel & tiller shaft parts & parts list ref. No. Part # description qty. 1 1500p101 bolt, m6 x 25mm 6 2 1500p102 cover, rear transmission 1 3 1500p103 gasket, front & rear transmission cover...

  • Page 29: 6015V Crt Rototiller

    6015v crt rototiller 1-year limited warranty terms and conditions ardisam, inc., a manufacturing company, warrants this earthquake® crt rototiller to be free from defects in the material or workmanship for a period of one year from the date of purchase. During the one-year warranty of this product, ...

  • Page 30

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 30 getearthquake.Com 800-345-6007 notes _______________________________________________________________________________________________________ ____________________________________________________________________________________...

  • Page 31

    Operator instructions and parts crt models 6015v, 6015vce, 6015bce page 31 getearthquake.Com 800-345-6007 notes _______________________________________________________________________________________________________ ____________________________________________________________________________________...

  • Page 32

    Earthquake, division of ardisam, inc. 1160 eighth avenue; p.O. Box 666 cumberland, wisconsin 54829 800-345-6007 · fax (715) 822-2223 e-mail: info@ardisam.Com getearthquake.Com importers/ repair centers (for u.K. Customers) rochford garden machinery ltd. Wincanton business park , wincanton somerset, ...