1. DL manuals
  2. EarthStone
  3. Oven
  4. woofire oven
  5. Installation Instructions Manual

EarthStone woofire oven Installation Instructions Manual

Manual is about: wood-fire oven

Summary of woofire oven

  • Page 1

    Pre-assembled installation instructions earthstone ovens-6717 san fernando rd glendale ca 91201 telephone: 800-840-4915 818-553-1134 fax: 818-553-1133 www.Earthstoneovens.Com e-mail: earthstone@earthlink.Net a major cause of oven related fires is failure to maintain required clearances (air spaces) ...

  • Page 2

    Earthstone wood fire ovens 6717 san fernando rd, glendale ca 91201 earthstone@earthlink.Net www.Earthstoneovens.Com pre-assembled installation instructions. Table of contents page instructions for moving and lifting oven parts list 1 installation procedures written portion 2-5 required clearances an...

  • Page 3

    Instructions for lifting and moving oven attention: only proper heavy lifting machinery and handling equipment should be used for unloading, moving and installing the oven. This duty should be performed by professionals trained in this kind of work. Improper handling of the equipment could result in...

  • Page 4: List of Supplied Items

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 1 list of supplied items oven additional items metal door digital thermometer (requires 120v ac outlet) 120 v ac, 60 hz, 1 amp power supply (supplied) training video.

  • Page 5

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 2 pre-assembled installation instruction guide read all instructions carefully before installing and using the appliance. If this oven is not properly installed, a fire may result. To reduce the risk of fire, follow the installat...

  • Page 6

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 3 installation. Operating and maintenance preface refer to pages 9, 10 and 11 for complete instructions. 1) on daily basis, and after the oven temperature is at least 500 at f: (a) ashes are to be removed by a metal ash scoop/sho...

  • Page 7: Installation

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 4 a. Installation procedures 1. Mark an outline on the floor of the location desired. This is to assure that you have adequate space. Refer to fig. 1, pg. 6. 2. Check that there is adequate clearance at the ceiling for the hood. ...

  • Page 8

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 5 i type-i exhaust hood-installed per nfpa 96, standard for ventilation control and fire protection of commercial cooking operations. (for commercial applications only) 1. If required, a type 1 hood must be placed above the cooki...

  • Page 9

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 6 for commercial use only figure 2 u.M.C. & n.F.P.A. Figure 1 combustibles 3"min. 1" min. 105" 80" hood 3"min. Combustibles 3"min. Feed opening combustibles 1" min. 1"min. 1"min. 48" min. 48" min. Figure 4 outside diameter model ...

  • Page 10

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 7 grease hood models 130 and 160 models 90 and 110 7” 7” 7” 7” figure 16.

  • Page 11

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 8 all models 10” 37” 22" overall exhaust hood dimensions are minimums. Section figure 17 4” to 6” conc. Floor slab embed 2 1/2” min. Oven stand base plate ramset red heads (typ.) figure 17-a.

  • Page 12

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 9 direct venting figure 18 grease duct heating appliance chimney attached to primary hood this diagram generally depicts the installation required to maintain the u.L. Listing of the oven for this type of venting application. For...

  • Page 13

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 10 residential direct venting figure 18 grease duct heating appliance chimney attached to primary hood this diagram generally depicts the installation required to maintain the u.L. Listing of the oven for this type of venting app...

  • Page 14: Wood-Fired Pizza Oven

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 11 wood-fired pizza oven operating instructions warning: read all instructions carefully. Improper use of this appliance may result in a building fire or personal injury. Instructions must be read and thoroughly understood by all...

  • Page 15: Maintenance Instructions

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 12 8. A- before starting, turn "on" exhaust fan and make-up air blowers. B- place a small amount of wood and kindling on the hearth over a fire-starter block. Light fire- starter. At any time do not use more than four pieces of w...

  • Page 16

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 13 3. Store wood in a cool, dry place well away from any source of flame or heat. If stored outside, keep the fuel covered to protect from rain or snow. If stored inside, fuel should be kept in a covered metal container at least ...

  • Page 17

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 14 40” min 36” min for models 90 and 110 for models 130 and 160 22” 10” 37” type-i exhaust hood installed per nfpa 96 **it is never appropriate to use “class a” or “b vent” in any part of the exhaust system exhaust systems servin...

  • Page 18

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 15 30” 36” granite mantle temperature gauge on/off switch for gas burner burner control box, for pagw models only. Adequate clearance must be provided for air openings into the combustion chamber for and . Minimum 24” x 24” locat...

  • Page 19

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 16 important: please read for gas fire or gas/wood combination ovens only combustion air intake procedures and installation proper installation: roof false ceiling air flow air flow 24”x24” opening needed for combustion air. Only...

  • Page 20

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 17 improper installation (cont) 2) oven is not closed to plenum/attic and is open to hvac airflow. Roof ceiling air flow air flow air flow installing a sealed enclosure around the oven shell may cause improper operation by starvi...

  • Page 21

    Earthstone ovens pre-assembled installation instructions---u.L. Listed 18 expansion cracks, due to the refractory mass, are normal in the front entrance and on any interior surface. This will not effect the performance, efficiency and longevity of the oven in any way. Notice cut view of inside oven ...