1. DL manuals
  2. Eastern Tools & Equipment
  3. Portable Generator
  4. TG72B12
  5. User manual

Eastern Tools & Equipment TG72B12 User manual

Manual is about: Portable Generator 8250 Surge Watts 7250 Continuous Watts

Summary of TG72B12

  • Page 1

    1 eastern tools & equipment, inc tg72b12 portable generator 8250 surge watts 7250 continuous watts customer service (888)-908-6200 www.Easterntools.Com eastern tools & equipment. Inc ontario, ca u.S.A.

  • Page 2: Table Of Contents

    2 thank you for purchasing products from easterntools & equipment, inc. We appreciate your business. The following manual is only a guide to assist you and is not a complete or comprehensive manual of all aspects of maintaining and repairing your generator. The equipment you have purchased is a comp...

  • Page 3: Safety Warning

    3 safety warning please read this manual to understand how to use your unit as well as understanding the risk the come with the unit. Notice exceeding your generator wattage/ amperage coverage capacity can damage your unit as well as any devices attached to your unit. Consumers should notice that th...

  • Page 4

    4 keep the same concept when disconnecting electrical devices; make sure all devices are in the "off" position before disconnecting. Operate the generator on level surfaces only. Inclined surfaces reduce the effective lubrication of the engine. Do not expose the generator to excessive moisture, dust...

  • Page 5

    5 controls and features read this owner’s manual before operating your generator. Familiarize yourself with the location and function of the controls and features. Save this manual for future reference. (1) fuel tank cap (12) cap assy,oil filler (2) muffler comp (13) oil indicator light assy (3) cir...

  • Page 6

    6 order no. Name qty 1 air-cooled generator set 1 2 tool kit: flat head screwdriver spark plug wrench wrench, 8×10,17×19 battery wire 1 3 assembly kit: wheel (2 pcs) 1 4 assembly kit: wheel kit hardware 1 5 assembly kit: etc. Generator foot (2 pcs) 1 6 assembly kit: handle 1 7 吊钩suspend conveyance s...

  • Page 7

    7 auto throttle control switch when using the generator, leave the auto throttle control switch (atc) in the “on” position; as soon as output is not needed. The engine will go into idle speed thus saving fuel. As soon as, power is need again the engine will operate as normal again. Battery cable ins...

  • Page 8

    8 starting the unit please refer to your start up guide that comes with your unit. Before beginning your work, you must verify that the rated (running) and surge (starting) watts for the items you will power at the same time are within the generators operating capacity. Please refer to the following...

  • Page 9: Storage

    9 air filter unscrew the bolt from the air cleaner cover, and remove the air cleaner cover. Check the air cleaner element to be sure they are clean and in good condition. If the air filter is dirty, remove and clean the element. Wash in solvent squeeze soak oil squeeze dry reinstall the air cleaner ...

  • Page 10

    10 ·tighten the oil drain plug and fill the engine with new oil to the filter neck. ·pull the starter grip carefully until resistance is felt. ·store the generator in a clean area. Maintenance below is a routine maintenance schedule. (1):these items should be serviced by a dealer. (2):every 3 years..

  • Page 11

    11 trouble shooting problem cause solution generator will not start no gasoline add gasoline faulty spark plug replace spark plug unit loaded during start up remove load from unit generator will not start; generator starts but runs roughly low oil level fill crankcase to the proper level place gener...

  • Page 12

    12 wiring diagram.

  • Page 13

    13 parts list (25) (9).

  • Page 14

    14.

  • Page 15

    15.

  • Page 16

    16.

  • Page 17

    17.

  • Page 18

    18.

  • Page 19: Limited Warranty

    19 limited warranty eastern tools & equipment, inc. Will repair or replace, free of charge, any part or parts of the generator that are defective in material or workmanship or both. Transportation charges on parts submitted for repair or replacement under this warranty must be borne by purchaser. Th...

  • Page 20

    20 normal wear: engines and generators, like all mechanical devices, need periodic parts service and replacement to perform well. Warranty will not cover repair when normal use has exhausted the life of a part of an engine. Improper maintenance: the life of an engine or your equipment depends upon t...

  • Page 21

    21 periods of time listed above listed above provided there has been no abuse, neglect or improper maintenance of your small nonroad engine. Your emission control system may include parts such as the carburetor, or fuel-injection system, the ignition system and catalytic converter. Also included may...

  • Page 22: Product Registration

    22 product registration for more efficient customer service, please fill out the information below and mail to eastern tools & equipment, inc. Product warranty and registration division. Model no._________________ engine serial no.____________ purchase date ____/____/_____ purchased from: [ ] retail...