1. DL manuals
  2. Eaton
  3. Portable Generator
  4. 11kW
  5. Owner's Manual

Eaton 11kW Owner's Manual

Manual is about: Automatic Standby Generator

Summary of 11kW

  • Page 1

    Owner’s manual automatic standby generator this manual should remain with the unit. Eaton generator support 1-800-975-8331 n not intended for use in critical life support applications. N only qualified electricians or contractors should attempt installation. N deadly exhaust fumes! Outdoor installat...

  • Page 2: 1-800-975-8331

    I use this page to record important information about your generator set. Record the information found on your unit data label on this page. For the location of the unit data label, see section 2 general information. The unit has a label plate affixed to the inside partition, to the left of the cont...

  • Page 3

    Table of contents ii section 1 — safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 1.1 — general safety . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . ....

  • Page 4

    Iii this page intentionally left blank..

  • Page 5: Safety

    Automatic standby generator owner’s manual 1 section 1 safety introduction: thank you for purchasing this compact, high performance, air-cooled, engine-driven stationary automatic standby generator set. Every effort was made to make sure that the information and instructions in this manual were both...

  • Page 6

    2 automatic standby generator owner’s manual 1.1 — general safety study these safety rules carefully before operating or servicing this equipment. Become familiar with this owner’s manual and with the unit. The generator can operate safely, efficiently and reliably only if it is properly installed, ...

  • Page 7

    Automatic standby generator owner’s manual 3 1.3 — exhaust hazards • generator engine exhaust contains deadly carbon monoxide, an odorless, colorless, poisonous gas. Breathing carbon monoxide can cause dizziness, throbbing temples, nausea, muscular twitching, headache, vomiting, weakness, sleepiness...

  • Page 8

    4 automatic standby generator owner’s manual if this generator is used to power electrical load circuits normally powered by a utility power source, it is required by code to install a transfer switch. The transfer switch must effectively isolate the electrical system from the utility distribution s...

  • Page 9: General Information

    Automatic standby generator owner’s manual 5 section 2 general information 2.1 — the generator figure 2-1: gh-410 engine 8kw unit figure 2-2: gh-530 engine 11kw unit exhaust enclosure composite base oil filter oil fill cap battery compartment fuel regulator circuit breakers fuel inlet (back) control...

  • Page 10

    6 automatic standby generator owner’s manual figure 2-3: gt-990/gt-999 engines, 14-20kw unit 2.2 — protection systems the generator may have to run for long periods of time with no operator present to monitor the engine/generator conditions. Therefore, the gen- erator is equipped with a number of sy...

  • Page 11

    Automatic standby generator owner’s manual 7 2.3 — emission information the u.S. Environmental protection agency (epa) requires that this generator comply with exhaust emission standards. This generator is certified to meet the applicable epa emission levels and is certified for use as a stationary ...

  • Page 12

    8 automatic standby generator owner’s manual 2.4 — specifications 2.4.1 — generator 2.4.2 — engine model 8kw 11kw 14kw 17kw 20kw rated voltage 240 rated maximum load current (amps) at 240 volts (lp)* 33.3 45.8 58.3 70.8 83.3 main circuit breaker 35 amp 50 amp 60 amp 65 amp 90 amp phase 1 rated ac fr...

  • Page 13

    Automatic standby generator owner’s manual 9 the specification sheet for your generator was included in the documentation provided with the unit at the time of purchase. For additional cop- ies, consult your local authorized service dealer for your specific generator model. 2.4.3 — fuel requirements...

  • Page 14

    10 automatic standby generator owner’s manual this page intentionally left blank..

  • Page 15: Operation

    Section 3 operation automatic standby generator owner’s manual 11 3.1 — control panel interface the control panel on this unit is intended to only be operated by qualified service personnel. The control panel interface is located under the lid of the enclosure. Before attempting to lift the lid of t...

  • Page 16

    12 automatic standby generator owner’s manual figure 3-2: generator control panel 3.2 — using the auto/off/manual buttons note: damage caused by mis-wiring of the interconnect wires is not warrantable. 3.3 — interface menu displays the lcd display: 3.3.1— menu system navigation to get to the menu, u...

  • Page 17

    Automatic standby generator owner’s manual 13 figure 3-3: navigation menu 2013 evolution/sync2.0 hsb menu map 0198170gst -d 05/22/13 page 1 of 4 up arrow = + down arrow = - “run log” esc enter enter esc system ba tter y da te/time sub menus hist or y edit maint dealer example: inspect battery 200 rn...

  • Page 18

    14 automatic standby generator owner’s manual 3.4 — automatic transfer operation to select automatic operation: 1. Make sure the transfer switch main contacts are set to their utility position (loads connected to the utility power source). 2. Be sure that normal utility power source voltage is avail...

  • Page 19

    Automatic standby generator owner’s manual 15 3.5 — turning the generator off when operating under load note: important! To turn the generator off during prolonged utility outages to perform maintenance or conserve fuel, follow these simple, but important steps: to turn the generator off (while runn...

  • Page 20

    16 automatic standby generator owner’s manual 3.6.2— transfer back to utility power source when utility power has been restored, transfer back to utility source and shut down the generator. To manually transfer back to utility power and shut down the generator: 1. Set the main circuit breaker (gener...

  • Page 21

    Automatic standby generator owner’s manual 17 3.7.3— 120v gfci outlet/15 amp breaker (17 & 20 kw only) all units are equipped with an external 15 amp, 120 volt gfci convenience outlet located in the top corner of the compartment. When the generator is running, in the absence of utility power, this o...

  • Page 22

    18 automatic standby generator owner’s manual this page intentionally left blank..

  • Page 23: Maintenance

    Automatic standby generator owner’s manual 19 section 4 maintenance note: proper maintenance and proper and safe operation is crucial to the life of the generator. Genuine generac parts must be used to ensure warranty coverage. Note: since most maintenance alerts will occur at the same time (most ha...

  • Page 24

    20 automatic standby generator owner’s manual 4.2.1— maintenance log 1. Battery inspection and charge check (recommended every 6 months for the life of the battery) dates performed: 2. Oil, oil filter, air filter and spark plug replacement (recommended every 200 hours or 2 years, whichever occurs fi...

  • Page 25

    Automatic standby generator owner’s manual 21 4.3.1— engine oil recommendations to maintain the warranty, genuine generac replacement parts must be used, including generac oil kits (which include an oil and air filter). Gen- erac oil kits can be obtained through an authorized dealer or purchased on-...

  • Page 26

    22 automatic standby generator owner’s manual figure 4-2: oil filter and drain location 4.4 — changing the engine air cleaner 1. With the generator shut down, lift the lid and remove the front panel. 2. Remove the cover clips and air cleaner cover (11-20kw), or disengage the wire clip and open the a...

  • Page 27

    Automatic standby generator owner’s manual 23 4.6 — valve lash adjustment after the first six (6) months or 500 hours of operation, check the valve clearance. Adjust if necessary. Important: please contact the dealer for service assistance. This is a very important step to ensure longest life for th...

  • Page 28

    24 automatic standby generator owner’s manual figure 4-4: valve clearance adjustment 4.7 — battery maintenance the battery should be regularly inspected per the service schedule: 1. With the generator shut down, lift the lid and remove the front panel. 2. Inspect the battery posts and cables for tig...

  • Page 29

    Automatic standby generator owner’s manual 25 do not open or mutilate the battery. Released electrolyte has been known to be harmful to the skin and eyes, and to be toxic. The electrolyte is a dilute sulfuric acid that is harmful to the skin and eyes. It is electrically conduc- tive and corrosive. S...

  • Page 30

    26 automatic standby generator owner’s manual 11. Remove the battery and store it in a cool, dry room on a wooden board. Never store the battery on any concrete or earthen floor. 12. Clean and wipe down the entire generator. 4.10.2— return to service to return the unit to service after storage: 1. V...

  • Page 31: Troubleshooting

    Automatic standby generator owner’s manual 27 section 5 troubleshooting problem cause correction the engine will not crank. 1. Fuse blown. 1. Correct short circuit condition by replacing 7.5 amp fuse in generator control panel. 2. Loose, corroded or defective 2. Tighten, clean or replace battery cab...

  • Page 32

    28 automatic standby generator owner’s manual this page intentionally left blank..

  • Page 33: Quick Reference Guide

    Automatic standby generator owner’s manual 29 section 6 quick reference guide problem led things to check active alarm solution unit running in auto but no power in house. Green check mlcb. None check mlcb. Contact servicing dealer if mlcb is in the on position. Unit shuts down during operation. Red...

  • Page 34

    30 automatic standby generator owner’s manual unit will not start in auto with utility loss. Red check the leds/screen for alarms. Stepper overcurrent contact servicing dealer. Unit will not start in auto with utility loss. Red check the leds/screen for alarms. Miswire contact servicing dealer. Unit...

  • Page 36

    Part no. 0j9943y10 rev. D 08/13/2013 printed in usa © generac power systems, inc. All rights reserved specifications are subject to change without notice. No reproduction allowed in any form without prior written consent from generac power systems, inc. Generac power systems, inc. S45 w29290 hwy. 59...