- DL manuals
- Eaton
- Power Tool
- NRX
- Instruction Manual
Eaton NRX Instruction Manual - page 61
55
Section 7: Inspection and maintenance
Series NRX with PXR - type RF low voltage power (air) circuit breakers instruction manual MN013002ENH03 September 2016 www.eaton.com
Figure 62. Step 1.
Step 2: (Drawout breakers) Once both latches are released
the inner cradle can be compressed until the tool slot is
visible. Insert a screwdriver vertically into the slot to hold
the inner cradle in place and improve arc chute access. On
the RF frame, repeat Steps 1 and 2 on the second contact
assembly.
Figure 63. Step 2.
Step 3: Using a Phillips screwdriver, remove the four top-
inserted mounting screws from each arc chute.
Figure 64. Step 3.
Shown without breaker for clarity
Tool slot
Step 4: Lift the arc chute up and out of the arc chamber.
Figure 65. Step 4.
Step 5: Follow the same procedure to remove the remaining
two arc chutes.
Step 6: Inspect the arc chutes for obvious damage and turn
them over to inspect the inside for obvious damage or dirt
accumulation. Series NRX arc chutes cannot be replaced.
If damage or dirt accumulation is observed, contact Eaton
for additional information.
Figure 66. Step 6.
Summary of NRX
Page 1
Series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual instruction manual mn013002enh03 instructions apply to: ul489 series nrx rf frame iec izmx40 typical drawout circuit breaker and cassette typical fixed circuit breaker.
Page 2
Ii series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com table of contents section 1: introduction . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 1 purpose . . . . . . . . . . . . . . . ...
Page 3
Iii instruction manual mn013002enh03 series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com right accessory tray . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .19 shunt t...
Page 4
Iv instruction manual mn013002enh03 series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com section 8: troubleshooting . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 56 introduction . . . . . . . . ...
Page 5
V instruction manual mn013002enh03 series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com warning the warnings and cautions included as part of the procedural steps in this manual are for personnel safety and protection of...
Page 6
Vi instruction manual mn013002enh03 series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com.
Page 7
1 section 1: introduction series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com section 1: introduction purpose this instructional manual is intended to generally cover the installation, operation, and maintenance of seri...
Page 8
2 section 1: introduction series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com product labeling and identification the circuit breaker nameplate, located on the right side of the breaker, provides complete rating informa...
Page 9
3 section 1: introduction series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com the circuit breaker configuration is fully described by a 20-digit catalog number located on the name plate. The dra- wout cassette can be id...
Page 10
4 section 1: introduction series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 2. Typical nrx type rf drawout circuit breaker. Ote: n refer to figure 5 for more visual details of front cover. 1. Arc chute cover 2....
Page 11
5 section 1: introduction series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 3. Typical nrx type rf drawout cassette. 1. Drawout extension rail (shown in extended and locked position) 2. Secondary connectors 3. ...
Page 12
6 section 1: introduction series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 4. Typical nrx type rf fixed circuit breaker. Ote: n refer to figure 5 for more visual details of front cover. 1. Front cover 2. Secon...
Page 13
7 section 1: introduction series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 5. Typical nrx type rf drawout circuit breaker front cover. 1. Nameplate 2. Charging handle 3. Operations counter (optional) 4. Positi...
Page 14
8 section 2: receiving, unpacking, and inspection series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com section 2: receiving, unpacking, and inspection suggested tools ● flat-blade/phillips head screwdrivers ● 3/8-inch le...
Page 15
9 section 2: receiving, unpacking, and inspection series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 9. Suggested lifting procedures and precautions ote: n when using an appropriate lifting device, attach the li...
Page 16
10 section 2: receiving, unpacking, and inspection series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 10. Step 3. Step 5: carefully place a breaker or cassette on a solid work surface capable of handling their w...
Page 17
11 section 3: general operation and circuit breaker description series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com section 3: general operation and circuit breaker description introduction caution make certain that the...
Page 18
12 section 3: general operation and circuit breaker description series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 14. Step 3. Keep in mind that all drawout circuit breakers are provided with safety interlocks t...
Page 19
13 section 3: general operation and circuit breaker description series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 17. Disconnect position. Figure 18. Test position. Figure 19. Connect position. breaker in cas...
Page 20
14 section 3: general operation and circuit breaker description series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com step 3: carefully push the circuit breaker into its compart- ment until it stops. The extension rails c...
Page 21
15 section 3: general operation and circuit breaker description series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com operating mechanism the series nrx operating mechanism is a two-stage stored energy trip-free mechanism...
Page 22
16 section 4: circuit breaker features and accessories series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 27. Step 3. Optional electrically operated accessories are available to automatically close/trip a manual...
Page 23
17 section 4: circuit breaker features and accessories series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 28. Installed pxr trip unit. Table 2. Series nrx trip units. Functions pxr20 pxr 25 lsig protection yes y...
Page 24
18 section 4: circuit breaker features and accessories series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 29. Secondary point identification. Secondary contacts and connection diagrams a maximum of 96 secondary ...
Page 25
19 section 4: circuit breaker features and accessories series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com 15. The two-point blue plugs house two female crimp con- tacts 67c3249, with the odd assigned numbers having the...
Page 26
20 section 4: circuit breaker features and accessories series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com shunt trip (st) the shunt trip opens the circuit breaker instantaneously when its coil is energized by a voltage...
Page 27
21 section 4: circuit breaker features and accessories series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com interlocked pop-out mechanical trip indicator an interlocked, red mechanical trip indicator is an optional featu...
Page 28
22 section 4: circuit breaker features and accessories series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com table 5. Series nrx publications. Description publication number frame series nrx with pxr - instructions for ne...
Page 29
23 section 5: dimensional drawings for installation of drawout circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com section 5: dimensional drawings for installation of drawout circuit breakers general se...
Page 30
24 section 5: dimensional drawings for installation of drawout circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 33. Three-pole drawout cassette - rear/bottom views in inches (mm)..
Page 31
25 section 5: dimensional drawings for installation of drawout circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 34. Three-pole drawout cassette - side views connected and test positions in inc...
Page 32
26 section 5: dimensional drawings for installation of drawout circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 35. Three-pole drawout cassette - side views disconnected and withdrawn position...
Page 33
27 section 5: dimensional drawings for installation of drawout circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 36. Three-pole drawout cassette - top/side views with centered three-hole horizo...
Page 34
28 section 5: dimensional drawings for installation of drawout circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 37. Three-pole drawout cassette - top/side views with centered three-hole vertic...
Page 35
29 section 5: dimensional drawings for installation of drawout circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 38. Three-pole drawout cassette - top/side views with offset four-hole horizonta...
Page 36
30 section 5: dimensional drawings for installation of drawout circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 39. Three-pole drawout cassette - top/side views with offset four-hole vertical ...
Page 37
31 section 5: dimensional drawings for installation of drawout circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 40. Four-pole drawout cassette - rear/bottom views in inches (mm)..
Page 38
32 section 5: dimensional drawings for installation of drawout circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 41. Four-pole drawout cassette - side views connected and test positions in inch...
Page 39
33 section 5: dimensional drawings for installation of drawout circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 42. Four-pole drawout cassette - side views disconnected and withdrawn positions...
Page 40
34 section 5: dimensional drawings for installation of drawout circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 43. Four-pole drawout cassette - top/side views with centered three-hole horizon...
Page 41
35 section 5: dimensional drawings for installation of drawout circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 44. Four-pole drawout cassette-top/side views with centered three-hole vertical ...
Page 42
36 section 5: dimensional drawings for installation of drawout circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 45. Four-pole drawout cassette- top/side views with offset four-hole horizontal ...
Page 43
37 section 5: dimensional drawings for installation of drawout circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 46. Four-pole drawout cassette - top/side views with offset four-hole vertical b...
Page 44
38 section 5: dimensional drawings for installation of drawout circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 47. Three-pole/four-pole drawout cassette - front door cutout details in inches ...
Page 45
39 section 6: dimensional drawings for installation of fi xed circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com section 6: dimensional drawings for installation of fi xed circuit breakers general secti...
Page 46
40 section 6: dimensional drawings for installation of fi xed circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 48. Three-pole fixed breaker - rear/bottom views in inches (mm)..
Page 47
41 section 6: dimensional drawings for installation of fi xed circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 49. Three-pole fixed breaker - top/side views in inches (mm)..
Page 48
42 section 6: dimensional drawings for installation of fi xed circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 50. Three-pole fixed breaker - top/side views with centered three-hole horizontal ...
Page 49
43 section 6: dimensional drawings for installation of fi xed circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 51. Three-pole fixed breaker - top/side views with centered three-hole vertical bu...
Page 50
44 section 6: dimensional drawings for installation of fi xed circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 52. Three-pole fixed breaker - top/side views with offset four-hole horizontal bus...
Page 51
45 section 6: dimensional drawings for installation of fi xed circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 53. Three-pole fixed breaker - top/side views with offset four-hole vertical bus a...
Page 52
46 section 6: dimensional drawings for installation of fi xed circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 54. Four-pole fixed breaker - rear/bottom views in inches (mm)..
Page 53
47 section 6: dimensional drawings for installation of fi xed circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 55. Four-pole fixed breaker - top/side views in inches (mm)..
Page 54
48 section 6: dimensional drawings for installation of fi xed circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 56. Four-pole fixed breaker - top/side views with centered three-hole horizontal b...
Page 55
49 section 6: dimensional drawings for installation of fi xed circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 57. Four-pole fixed breaker - top/side views with centered three-hole vertical bus...
Page 56
50 section 6: dimensional drawings for installation of fi xed circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 58. Four-pole fixed breaker - top/side views with offset four-hole horizontal bus ...
Page 57
51 section 6: dimensional drawings for installation of fi xed circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 59. Four-pole fixed breaker - top/side views with offset four-hole vertical bus ad...
Page 58
52 section 6: dimensional drawings for installation of fi xed circuit breakers series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 60. Three-pole/four-pole fixed breaker - front door cutout details in inches (mm)..
Page 59
53 section 7: inspection and maintenance series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com section 7: inspection and maintenance general warning failure to inspect, clean, and maintain circuit breakers can reduce equi...
Page 60
54 section 7: inspection and maintenance series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 61. Typical nameplate information. Manual operation functional test perform the following seven steps and verify if the...
Page 61
55 section 7: inspection and maintenance series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com figure 62. Step 1. Step 2: (drawout breakers) once both latches are released the inner cradle can be compressed until the tool...
Page 62
56 section 8: troubleshooting series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com step 7: when inspections are complete, secure arc chutes in place with their mounting screws. Remove screwdriver and verify that secondar...
Page 63
57 section 8: troubleshooting series nrx with pxr - type rf low voltage power (air) circuit breakers instruction manual mn013002enh03 september 2016 www.Eaton.Com table 7. Circuit breaker troubleshooting guide. Symptom probable cause corrective action the circuit breaker trips open (red fault trip i...
Page 64
Eaton 1000 eaton boulevard cleveland, oh 44122 united states eaton.Com © 2016 eaton all rights reserved printed in usa publication no. Mn013002en/tbg001218 part number: mn013002enh02 september 2016 eaton is a registered trademark. All trademarks are property of their respective owners. Disclaimer of...