- DL manuals
- Eaton
- UPS
- Powerware 5130
- User Manual
Eaton Powerware 5130 User Manual
Summary of Powerware 5130
Page 1
Powerware 5130 rack/tower ups 1250–3000 va user’s guide ®.
Page 2
Requesting a declaration of conformity units that are labeled with a ce mark comply with the following harmonized standards and eu directives: s harmonized standards: en 62040-1-1 and en 62040-2; iec 60950-1 s eu directives: 73/23/eec, council directive on equipment designed for use within certain v...
Page 3
Class a emc statements (low-voltage models) fcc part 15 note this equipment has been tested and found to comply with the limits for a class a digital device, pursuant to part 15 of the fcc rules. These limits are designed to provide reasonable protection against harmful interference when the equipme...
Page 4
Special symbols the following are examples of symbols used on the ups or accessories to alert you to important information: risk of electric shock - observe the warning associated with the risk of electric shock symbol. Caution: refer to operator’s manual - refer to your operator’s manual for additi...
Page 5
Eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com i table of contents 1 introduction 1 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 2 safety warnings 3 . . . . . . . . . . . . . ....
Page 6
Table of contents eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com ii replacing batteries 46 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . How to replace int...
Page 7
Eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 1 chapter 1 introduction eaton’s powerware ® 5130 uninterruptible power system (ups) protects your sensitive electronic equipment from basic power problems such as power failures, power sags, power ...
Page 8
Introduction eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 2 providing outstanding performance and reliability, the powerware 5130’s unique benefits include: s hours of extended runtime with up to four ebms. S start-on-battery capability for po...
Page 9
Eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 3 chapter 2 safety warnings important safety instructions save these instructions this manual contains important instructions that you should follow during installation and maintenance of the ups an...
Page 10
Safety warnings eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 4 c a u t i o n s batteries can present a risk of electrical shock or burn from high short-circuit current. Observe proper precautions. Servicing should be performed by qualified ser...
Page 11
Safety warnings eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 5 a d v a r s e l s batterierne kan give risiko for elektrisk stød eller brandsår forårsaget af høj kortslutningsstrøm. Overhold gældende forsigtighedsregler. Servicering skal udføre...
Page 12
Safety warnings eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 6 s teneinde de kans op brand of elektrische schok te verminderen dient deze ups in een gebouw met temperatuur- en vochtigheidregeling te worden geïnstalleerd, waar geen geleidende v...
Page 13
Safety warnings eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 7 tarkeita turvaohjeita tÄrkeitÄ turvaohjeita - suomi sÄilytÄ nÄmÄ ohjeet tämä käyttöohje sisältää tärkeitä ohjeita, joita on noudatettava ups-virtalähteen ja akkujen asennuksen ja h...
Page 14
Safety warnings eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 8 consignes de sécurité consignes de sÉcuritÉ importantes conserver ces instructions ce manuel comporte des instructions importantes que vous êtes invité à suivre lors de toute procé...
Page 15
Safety warnings eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 9 a t t e n t i o n ! S les batteries peuvent présenter un risque de choc électrique ou de brûlure provenant d’un courant de court-circuit haute intensité. Observez les précautions a...
Page 16
Safety warnings eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 10 s um die brand- oder elektroschockgefahr zu verringern, diese usv nur in gebäuden mit kontrollierter temperatur und luftfeuchtigkeit installieren, in denen keine leitenden schmutz...
Page 17
Safety warnings eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 11 a v v e r t e n z a s l’ups contiene la propria fonte di energia (batterie). Le prese d’uscita possono essere sotto tensione anche quando l’ups non è collegato all’alimentazione e...
Page 18
Safety warnings eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 12 viktig sikkerhetsinformasion viktige sikkerhetsinstruksjoner gjem disse instruksjonene denne håndboken inneholder viktige instruksjoner som du bør overholde ved montering og vedli...
Page 19
Safety warnings eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 13 f o r s i k t i g s batterier kan utgjøre en fare for elektrisk støt eller brannsår pga. Høy kortsluttingsstrøm. Treff passende forholdsregler. Service bør utføres av kvalifisert ...
Page 20
Safety warnings eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 14 s para reduzir o risco de incêndios ou choques elétricos, instale a ups em ambiente interno com temperatura e umidade controladas e livres de contaminadores condutíveis. A tempera...
Page 21
Safety warnings eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 15 П Р Е Д У П Р Е Ж Д Е Н И Е s В данном ИБП установлены собственные источники энергии (батареи). На выходных розетках может бытьнапряжение, даже если ИБП не подключен к сети переме...
Page 22
Safety warnings eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 16 advertencias de seguridad instrucciones de seguridad importantes guarde estas instrucciones este manual contiene instrucciones importantes que debe seguir durante la instalación y...
Page 23
Safety warnings eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 17 p r e c a u c i Ó n s las baterías pueden constituir un riesgo de descarga eléctrica o quemaduras por corriente alta de corto circuito. Adopte las precauciones debidas. Personal c...
Page 24
Safety warnings eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 18 s minska risken för brand eller elektriska stötar genom att installera denna ups-enhet inomhus, där temperatur och luftfuktighet är kontrollerade och där inga ledande föroreningar...
Page 25
Eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 19 chapter 3 installation this section explains: s equipment inspection s ups internal battery connection s ups setup and installation, including extended battery modules (ebms) s remote power-off (...
Page 26
Installation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 20 checking the accessory kit verify that the following additional items are included with the ups: table 1. Ups accessory kit item description ups user’s guide or cd quick start instru...
Page 27
Installation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 21 the high-voltage models include the following additional items: table 2. Additional high-voltage model accessory items item description two cord-retention brackets two equipment powe...
Page 28
Installation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 22 connecting the ups internal battery to ensure proper battery operation: 1. Verify that the ups is off and unplugged. 2. Connect the internal battery connectors by firmly pressing the...
Page 29
Installation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 23 ups setup the powerware 5130 ups is designed for flexible configurations and can be installed in a rack or as a standalone cabinet. If you are installing the ups in a rack, continue ...
Page 30
Installation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 24 installing the rail kit c a u t i o n the ups and ebm are heavy (see page 52). A minimum of two people are required to lift the cabinets into the rack. Note mounting rails are requir...
Page 31
Installation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 25 6. Place the ups on a flat, stable surface with the front of the ups facing you. 7. Attach the supplied mounting brackets to the cabinet and secure with four m4 screws on each side (...
Page 32
Installation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 26 2. For one 2u cabinet, the pedestals must be installed. Continue to step 3. For one 3u cabinet, continue to “installing the ups” on page 28. For two or more cabinets, the joining bra...
Page 33
Installation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 27 5. Align each joining bracket with the adjacent cabinet screw holes and secure with the supplied screws (see figure 7). Note joining brackets are required for installations with two ...
Page 34
Installation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 28 installing the ups note do not make unauthorized changes to the ups or accessories; otherwise, damage may occur to your equipment and void your warranty. See “ups rear panels” on pag...
Page 35
Installation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 29 3. If you plan to install power management software, connect your computer to the usb port or rs-232 communication port using the supplied communication cable. Or figure 9. Installin...
Page 36
Installation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 30 5. Plug the equipment to be protected into the appropriate ups output receptacles (see page 42 for more information on load segments). See figure 10. Note do not protect laser printe...
Page 37
Installation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 31 rpo and roo installation the powerware 5130 includes a two-position terminal (see figure 11) that can be either left closed or configured one of two ways: s rpo: allows a remote cont...
Page 38
Installation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 32 w a r n i n g the rpo/roo circuit is an iec 60950 safety extra low voltage (selv) circuit. This circuit must be separated from any hazardous voltage circuits by reinforced insulation...
Page 39
Installation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 33 ups rear panels this section shows the rear panels of the powerware 5130 models. Usb port rs-232 port ebm battery connector power cord (15a, 5-15 plug - 1250 va 20a, 5-20 plug - 1750...
Page 40
Installation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 34 usb port rs-232 port ebm battery connector power cord (20a, l6-20 plug) rpo/roo connector (1) l6-30 receptacle communication bay ground bonding screw ebm rj-11 connector (2) l6-20 re...
Page 41
Eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 35 chapter 4 operation this section describes: s turning the ups on and off s starting the ups on battery s initiating the self-test s operating modes turning the ups on to turn the ups on: 1. Plug ...
Page 42
Operation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 36 starting the ups on battery note before using this feature, the ups must have been powered by utility power at least once. To turn on the ups without using utility power, press and hold...
Page 43
Operation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 37 operating modes the powerware 5130 front panel indicates the ups status through the ups indicators. Figure 17 shows the ups front panel indicators and controls. Battery charge level ind...
Page 44
Operation eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 38 battery mode when the ups is operating during a power outage, the alarm beeps once every 10 seconds and the button, the μ , and indicators are on. The bar graph indicators show the leve...
Page 45
Eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 39 chapter 5 additional ups features this section describes: s usb port s rs-232 communication port s communication card s load segments (powershare) the powerware 5130 ups includes a usb port, a rs...
Page 46
Additional ups features eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 40 figure 20. The usb port 2. Install the powerware lansafe power management software and usb drivers according to the instructions provided at www.Powerware.Com..
Page 47
Additional ups features eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 41 contact communication port (optional) when a signal is activated, the contact is closed between the common (pin 4) and the pin for the corresponding signal. Contact charac...
Page 48
Additional ups features eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 42 load segments (powershare) each ups has programmable outlets as shown in figure 22 through figure 24. During a power outage, you can keep key pieces of equipment running w...
Page 49
Additional ups features eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 43 customizing the ups with the ups configuration tool to customize the ups settings: 1. Download the ups configuration tool from www.Powerware.Com. 2. Follow the on-screen i...
Page 50
Additional ups features eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 44 table 6. Voltage threshold options (continued) pw5130g3000-xl2u function factory setting other available settings high threshold for transfer to battery 263 vac — low thre...
Page 51
Eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 45 chapter 6 ups maintenance this section explains how to: s care for the ups and batteries s transport the ups s store the ups and batteries s replace the batteries s test new batteries s recycle u...
Page 52
Ups maintenance eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 46 storing the ups and batteries if you store the ups for a long period, recharge the battery every 6 months by plugging the ups into a power outlet. The batteries charge to 90% capa...
Page 53
Ups maintenance eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 47 how to replace internal batteries c a u t i o n s pull the battery out onto a flat, stable surface. The battery is unsupported when you pull it out of the ups. S to ensure safety ...
Page 54
Ups maintenance eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 48 3. Unscrew and remove the metal battery cover (see figure 27). 1 2 figure 27. Removing the battery cover 4. Pull the battery block out onto a flat, stable surface (see figure 28)....
Page 55
Ups maintenance eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 49 how to replace extended battery modules to replace the extended battery modules (ebms): 1. Unplug the ebm cable from the ups. If additional ebms are installed, unplug the ebm cabl...
Page 56
Ups maintenance eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 50 4. Replace the ebm. See “recycling the used battery or ups” on page 50 for proper disposal. 5. For tower models only. Install the joining bracket between cabinets. 6. Plug the new...
Page 57
Eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 51 chapter 7 specifications filter transformer “avr” charger inverter battery figure 30. Block diagram table 10. Low-voltage model specifications model number power levels (rated at nominal inputs) ...
Page 58
Specifications eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 52 table 11. High-voltage model specifications model number power levels (rated at nominal inputs) ac input output on battery power nominal voltage voltage range 1 frequency range 2 v...
Page 59
Specifications eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 53 table 12. Weights and dimensions (continued) ebm model number dimensions (wxhxd) weight pw5130n1750-ebm2u 440 ×86×509 mm 17.3” ×3.4”×20.0” 29.1 kg (64.2 lb) pw5130n3000-ebm2u 440 ×...
Page 60
Specifications eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 54 table 14. Environmental and safety low voltage models high voltage models operating temperature 0°c to 40°c (32°f to 104°f) storage temperature -25°c to 40°c (-13°f to 104°f) relat...
Page 61
Specifications eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 55 table 16. Battery runtimes half load ups internal batteries +1 ebm +2 ebms +3 ebms +4 ebms 1250 va/575w 15 min 22 sec 58 min 1 hr 40 min 2 hr 23 min 3 hr 5 min 1750 va/800w 9 min 3...
Page 62
Specifications eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 56.
Page 63
Eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 57 chapter 8 troubleshooting this section explains: s ups alarms and conditions s service and support audible alarms and ups conditions the ups has an audible alarm feature to alert you of potential...
Page 64
Troubleshooting eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 58 table 17. Troubleshooting guide alarm or condition possible cause action when starting the ups with the button, all the indicators turn on once, the alarm beeps once, and then ind...
Page 65
Troubleshooting eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 59 service and support if you have any questions or problems with the ups, call your local distributor or the help desk at one of the following telephone numbers and ask for a ups te...
Page 66
Troubleshooting eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 60
Page 67
Eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 61 chapter 9 warranty two-year limited warranty (us and canada) powerware ups models: 5110, 5115, 5125, and 5130 warrantor: the warrantor for the limited warranties set forth herein is eaton electri...
Page 68
Warranty eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 62 what this limited warranty does not cover: this warranty does not cover any defects or damages caused by: (a) failure to properly store the product before installation, including the cha...
Page 69
Warranty eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 63 costs not related to warranty: the end-user shall be invoiced for, and shall pay for, all services not expressly provided for by the terms of this warranty, including without limitation,...
Page 70
Warranty eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 64 what this limited warranty does not cover: this warranty does not cover any defects or damages caused by: (a) failure to properly store the product before installation, including the cha...
Page 71
Warranty eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 65 other limitations: company’s obligations under this warranty are expressly conditioned upon receipt by company of all payments due to it (including interest charges, if any). During such...
Page 72
Warranty eaton powerware ® 5130 rack/tower ups (1250–3000 va) user’s guide s 164201730 rev 2 www.Powerware.Com 66 what this guaranty does not cover: any reimbursement or repair to end-user’s equipment does not include reimbursement for or restoration of any data loss. This guaranty does not cover an...
Page 74
Mau-00070 ac *1642017302* 164201730 2.