1. DL manuals
  2. Echo
  3. Blower
  4. PB-2100
  5. Operator's Manual

Echo PB-2100 Operator's Manual

Other manuals for PB-2100: Service Data, Parts Catalog
Manual is about: MODEL Type 1E

Summary of PB-2100

  • Page 1

    Power blower operator's manual model type 1e pb-2100 serial number 001001 & up warning danger read rules for safe operation and all instructions carefully. Echo provides this operator's manual which must be read and understood for proper and safe operation. X7501135101 89861020561 05/99 warning the ...

  • Page 2

    2 warning danger read rules for safe operation and instructions carefully. Echo provides this operator's manual which must be read and understood for proper and safe operation. T able of c ontents introduction.

  • Page 3

    3 p ower b lower o perator ' s m anual throughout this manual and on the product itself, you will find safety alerts and helpful, information messages preceded by symbols or key words. The following is an explanation of those symbols and key words and what they mean to you. This symbol accompanied b...

  • Page 4

    4.

  • Page 5: Attachments

    5 p ower b lower o perator ' s m anual symbol description/application symbol form/shape symbol description/application symbol form/shape hot surface carburetor adjustment - idle speed carburetor adjustment - high speed mixture symbol description/application symbol form/shape symbol description/appli...

  • Page 6

    6 after refueling; • wipe any spilled fuel from the unit. • move at lease 3m (10 ft.) from refueling location before starting the engine. After use; • do not store a unit with fuel in its tank. Leaks can occur. Return unused fuel to an approved fuel storage container. 3 m (10 ft.) personal condition...

  • Page 7

    7 p ower b lower o perator ' s m anual proper clothing -- wear snug fitting, durable clothing. • pants should have long legs, shirts with long sleeves. • do not wear shorts, • do not wear ties, scarves, jewelry. Wear sturdy work shoes or boots with non-skid soles; • do not wear open toed shoes, • do...

  • Page 8

    8 noise control • follow local noise regulations on sound levels and hours of operations. Use only during appropriate hours. • never use a higher speed setting then necessary to perform a task. The higher the engine speed the louder the blower noise. • be a good neighbor. Avoid hot surfaces • during...

  • Page 9

    9 p ower b lower o perator ' s m anual d escription after opening the carton, check for damage. Immediately notify your retailer or echo dealer of damaged or missing parts. Use the contents list to check for missing parts. Emission control the emission control system for this engine is em (engine mo...

  • Page 10

    10 1. Stop switch - "slide switch" mounted on top of handle. Push forward to start and run. Slide back to stop. 2. Throttle trigger - spring loaded to return to idle when released. During acceleration, press trigger gradually for best operating technique. 3. Blower pipes - twist lock design. 4. Muff...

  • Page 11

    11 p ower b lower o perator ' s m anual s pecifications specifications, descriptions and illustrative material in this literature are as accurate as known at the time of publication, but are subject to change without notice. Illustrations may include optional equipment and accessories, and may not i...

  • Page 12

    12 a ssembly warning danger never perform maintenance or assembly procedures with engine running or serious personal injury may result. Install blower pipes 1. Align grooves in straight pipe with pegs on blower housing and slide pipe onto housing. 2. Turn straight pipe clockwise to lock it into plac...

  • Page 13

    13 p ower b lower o perator ' s m anual handling fuel -- warning danger fuel is very flammable. Use extreme care when mixing, storing or handling or serious personal injury may result. • use an approved fuel container. • do not smoke near fuel. • do not allow flames or sparks near fuel. • fuel tanks...

  • Page 14

    14 o peration warning danger do not operate this product indoors or in inadequately ventilated areas. Engine exhaust contains poisonous emissions which can cause serious injury or death. • provide all operators of this equipment with the operator's manual and instructions for safe operation. • befor...

  • Page 15

    15 p ower b lower o perator ' s m anual starting warm engine 1. Stop switch - start/run. Move stop switch button (a) away from the stop position. 2. Start - pull rope. Lay the blower on a flat clear area and pull the starter handle (d) until the engine fires. Note if engine does not start after 4 pu...

  • Page 16

    16 1. Use only during appropriate hours. 2. Make sure bevel at end of pipe faces outward. 3. Allow the engine to warm up at a fast idle for a few minutes. 4. Set engine speed with throttle position knob (f). Note the pb-2100 can be run at any speed between 2500 rpm to 7400 rpm once the engine has br...

  • Page 17

    17 p ower b lower o perator ' s m anual maintenance intervals important time intervals shown are maximum. Actual use and your experience will determine the frequency of required maintenance. (1) replacement will be required for commercial use after 600 hours. For consumer use, cleaning every 6 month...

  • Page 18

    18 air filter level 1. Tools required: cleaning brush, 25-50mm (1in.-2in.) medium bristle paint brush. Parts required: 90008 repower air & fuel filter kit. 1. Close choke (cold start position). This prevents dirt from entering the carburetor throat when the air filter is removed. Brush accumulated d...

  • Page 19

    19 p ower b lower o perator ' s m anual spark plug level 2. Tools required: 3/4" spark plug deep socket, feeler gauge. Preferably a wire gauge. Parts required: spark plug, ngk bpm-7y, p/n 99944500071 1. Remove spark plug and check for fouling, worn and rounded center electrode. 2. Clean the plug or ...

  • Page 20

    20 exhaust system spark arrestor screen level 2. Tools required: cross head screwdriver. 20mm (3/4in.) spark plug deep socket. Soft metal brush. Wooden carbon scraper. Parts required: spark arrestor screen p/n 14586240630, gasket p/n 14586642031. 1. Remove spark plug and engine cover see "cooling sy...

  • Page 21

    21 p ower b lower o perator ' s m anual initial adjustment 1. With engine off, turn hi speed screw (c) counterclockwise to stop. 2. Turn lo speed screw (b) midway between stops. 3. Turn idle screw (a) until tip of screw just touches throttle plate; then turn three (3) turns clockwise. Final adjustme...

  • Page 22

    22 problem engine - starts hard engine - does not start cause remedy engine cranks fuel at carburetor no fuel at carburetor fuel strainer clogged fuel line clogged carburetor clean clean see your echo dealer fuel at cylinder no fuel at cylinder carburetor see your echo dealer muffler wet with fuel f...

  • Page 23

    23 p ower b lower o perator ' s m anual s torage long term storage (over 30 days) do not store your unit for a prolonged period of time (30 days or longer) without performing protective storage mainte- nance which includes the following: 1. Store unit in a dry, dust free place, out of the reach of c...

  • Page 24: Dealer?

    Echo, i ncorporated 400 oakwood road lake zurich, il 60047 echo incorporated 400 oakwood road lake zurich, il 60047 technical publications orders dealer? Call 1-800-432-echo 1-800-432-3246 consumer support 1-800-673-1558 8 - 5 mon - fri c.S.T. S ervicing i nformation parts genuine echo parts and ech...

  • Page 25

    Suplemento del manual del operador nÚmero de pieza x7501135101 (89861020561) para los modelo: pb-2100 serie número 898201 y superior utilice por favor este suplemento manual del operador al ensamblar y manteniendo su pb-2100 1 d escription page 9 emission control 99922203471 01/02 sup22203471 supple...