1. DL manuals
  2. Echo
  3. Blower
  4. PB-265LN
  5. Operator's Manual

Echo PB-265LN Operator's Manual

Summary of PB-265LN

  • Page 1

    X7501186202 © 3/2018 echo inc. English specifications, descriptions and illustrative material in this literature are as accurate as known at the time of publication, but are subject to change without notice. Illustrations may include optional equipment and accessories, and may not include all standa...

  • Page 2: Table of Contents

    Table of contents pb-265ln 2 x7501186202 © 3/2018 echo inc. Table of contents table of contents ........................................................................................ 2 introduction ................................................................................................. 3 ...

  • Page 3: Pb-265Ln

    Pb-265ln introduction x7501186202 3 © 3/2018 echo inc. English introduction this product was designed and manufactured to provide long life and on- the-job dependability. Read and understand all provided literature. Keep manuals in a safe place for future reference. Literature contains specification...

  • Page 4: Safety

    Safety pb-265ln 4 x7501186202 © 3/2018 echo inc. Echo consumer product support if you require assistance or have questions concerning the application, operation, or maintenance of this product, call the echo consumer product support department at 1-800-673-1558 from 8:00 am to 5:00 pm (central stand...

  • Page 5: Pb-265Ln

    Pb-265ln safety x7501186202 5 © 3/2018 echo inc. English the safety alert symbol accompanied by the word “warning” calls attention to an act or condition which can lead to serious personal injury or death if not avoided. The safety alert symbol accompanied by the word “caution” calls attention to an...

  • Page 6: Safety

    Safety pb-265ln 6 x7501186202 © 3/2018 echo inc. Hot surface fuel and oil mixture idle speed fast speed finger severing primer bulb do not allow flames or sparks near fuel ignition on / off do not smoke near fuel choke control “cold start” position (choke closed) choke control “run” position (choke ...

  • Page 7: Pb-265Ln

    Pb-265ln safety x7501186202 7 © 3/2018 echo inc. English personal condition and safety equipment cancer and reproductive harm www.P65warnings.Ca.Gov the muffler or catalytic muffler and surrounding cover may become extremely hot. Always keep clear of exhaust and muffler area, otherwise serious perso...

  • Page 8: Safety

    Safety pb-265ln 8 x7501186202 © 3/2018 echo inc. Hand protection wear sturdy, no-slip, rubber work gloves to improve your grip on the handles. Gloves also provide protection against cuts and scratches, cold environments, and reduce the transmission of machine vibration to your hands. Hearing/ear pro...

  • Page 9: Pb-265Ln

    Pb-265ln safety x7501186202 9 © 3/2018 echo inc. English the components of this machine generate an electromagnetic field during operation, which may interfere with some pacemakers. To reduce the risk of serious or fatal injury, persons with pacemakers should consult with their physician and the pac...

  • Page 10: Safety

    Safety pb-265ln 10 x7501186202 © 3/2018 echo inc. Repetitive stress injuries (rsi) it is believed that overusing the muscles and tendons of the fingers, hands, arms, and shoulders may cause soreness, swelling, numbness, weakness, and extreme pain in those areas. Certain repetitive hand activities ma...

  • Page 11: Pb-265Ln

    Pb-265ln safety x7501186202 11 © 3/2018 echo inc. English read the manual • provide all users of this equipment with the operator’s manual for instruc- tions on safe operation. Clear the work area • clear the area of children, bystanders, and pets. At a minimum, keep all children, bystanders, and pe...

  • Page 12: Safety

    Safety pb-265ln 12 x7501186202 © 3/2018 echo inc. • check unit for loose/missing nuts, bolts, and screws. Tighten and/or replace as needed. • do not use blower if any part is missing or damaged. • have repairs done only by an authorized echo service dealer. Moving parts can amputate fingers or cause...

  • Page 13: Pb-265Ln

    Pb-265ln emission control x7501186202 13 © 3/2018 echo inc. English emission control (exhaust & evaporative) carb and epa emissions control information the emission control system for the engine is em (engine modification) and, if the second to last character of the engine family on the emission con...

  • Page 14: Description

    Description pb-265ln 14 x7501186202 © 3/2018 echo inc. Description locate the safety decal(s) on your unit. Make sure the decal(s) is legible and that you understand and follow the instructions on it. If a decal cannot be read, a new one can be ordered from your echo dealer. 11 12 13 14 1 2 3 4 5 6 ...

  • Page 15: Pb-265Ln

    Pb-265ln description x7501186202 15 © 3/2018 echo inc. English 1. Spark plug - provides spark to ignite fuel mixture. 2. Spark arrestor muffler or spark arrestor muffler with catalyst -the muffler controls exhaust noise and emission. The spark arrestor screen prevents hot, glowing particles of carbo...

  • Page 16: Contents

    Contents pb-265ln 16 x7501186202 © 3/2018 echo inc. Contents the echo product you purchased has been factory pre-assembled for your convenience. Due to packaging restrictions, some assembly may be necessary. After opening the carton, check for damage. Immediately notify your retailer or echo dealer ...

  • Page 17: Pb-265Ln

    Pb-265ln assembly x7501186202 17 © 3/2018 echo inc. English assembly never perform maintenance or assembly procedures with engine running or serious personal injury may result. Install blower pipes / stick handle 1. Assemble clamps (a) onto both ends of flexible pipe (b). 2. Assemble straight pipe w...

  • Page 18: Operation

    Operation pb-265ln 18 x7501186202 © 3/2018 echo inc. 8. Assemble straight pipe (j) onto swivel pipe (c), until you feel light resistance. Hold swivel pipe and turn straight pipe clockwise, engaging positive locking channels, until connection is firm. Do not force connection. 9. Assemble straight pip...

  • Page 19: Pb-265Ln

    Pb-265ln operation x7501186202 19 © 3/2018 echo inc. English engine exhaust is hot, and contains carbon monoxide (co), a poison gas. Breathing co can cause unconsciousness, serious injury, or death. Exhaust can cause serious burns. Always position unit so that exhaust is directed away from your face...

  • Page 20: Operation

    Operation pb-265ln 20 x7501186202 © 3/2018 echo inc. 2-stroke engine oil contains petroleum distillates and other additives that may be harmful if swallowed. Heated oil can release vapors that can cause flash fire, or ignite with explosive force. Read and follow the oil manufacturer’s instructions, ...

  • Page 21: Pb-265Ln

    Pb-265ln operation x7501186202 21 © 3/2018 echo inc. English ? Inspect for fuel leakage. If fuel leakage is found, do not start or operate unit until leakage is repaired. ? Move at least 3 m (10 ft.) from refueling location before starting the engine. Gasoline vapor is heavier than air, and can trav...

  • Page 22: Operation

    Operation pb-265ln 22 x7501186202 © 3/2018 echo inc. Stored two-stroke fuel may separate. Always shake fuel container thoroughly before each use. Used oil and gasoline, and soiled towels are hazardous waste materials. Disposal laws vary by locality. Starting cold engine • recoil starter: use short p...

  • Page 23: Pb-265Ln

    Pb-265ln operation x7501186202 23 © 3/2018 echo inc. English 4. Recoil starter pull recoil starter handle (d) until engine fires, or a maximum of 5 pulls 5. Choke after engine fires (or 5 pulls), move choke lever back to run ( ) position, then pull starter handle/rope until engine starts and runs. A...

  • Page 24: Operation

    Operation pb-265ln 24 x7501186202 © 3/2018 echo inc. 3. Recoil starter pull recoil starter handle (d) and engine should start. Note: if engine does not start after 5 pulls, use cold start procedure. Stopping engine 1. Throttle position lever move throttle position lever (a) to start/idle ( ) positio...

  • Page 25: Pb-265Ln

    Pb-265ln operation x7501186202 25 © 3/2018 echo inc. English always wear safety glasses, hearing protection and a face filter mask or serious personal injury may result. Do not point the blower pipe in the direction of people or pets. Use reduced speed only when performing light-duty tasks or to com...

  • Page 26: Maintenance

    Maintenance pb-265ln 26 x7501186202 © 3/2018 echo inc. Note: never use a higher speed setting than necessary to perform a task. Remember, the higher the engine speed, the louder the blower noise. Minimize dust by using blower at lower speeds. Keep debris on your property. 8. Minimize dust by using b...

  • Page 27: Pb-265Ln

    Pb-265ln maintenance x7501186202 27 © 3/2018 echo inc. English click here or go to http://www.Echo-usa.Com/products/maintenance-kit or here https://www.Shindaiwa-usa.Com/you-can.Aspx for information about maintenance kits. Maintenance intervals important note - time intervals shown are maximum. Actu...

  • Page 28: Maintenance

    Maintenance pb-265ln 28 x7501186202 © 3/2018 echo inc. Air filter level 1. 1. Close choke (cold start [ ] position). This prevents dirt from entering the carburetor throat when the air filter is removed. Brush accumulated dirt from air cleaner area. 2. Remove air filter cover. Brush dirt from inside...

  • Page 29: Pb-265Ln

    Pb-265ln maintenance x7501186202 29 © 3/2018 echo inc. English 1. Use a clean rag to remove loose dirt from around fuel cap and empty fuel tank. 2. Pull the fuel line and filter from the tank. 3. Remove the filter from the line and install the new filter. Note: federal epa regulations require all mo...

  • Page 30: Maintenance

    Maintenance pb-265ln 30 x7501186202 © 3/2018 echo inc. Cooling system level 2. To maintain proper engine operating temperatures, cooling air must pass freely through the cylinder fin area. This flow of air carries combustion heat away from the engine. Overheating and engine seizure can occur when: •...

  • Page 31: Pb-265Ln

    Pb-265ln maintenance x7501186202 31 © 3/2018 echo inc. English exhaust system spark arrestor screen level 2. Carbon deposits in muffler will cause a drop in engine output and overheating. Spark arrestor screen must be checked periodically. 1. Remove spark plug lead from spark plug. 2. Remove engine ...

  • Page 32: Maintenance

    Maintenance pb-265ln 32 x7501186202 © 3/2018 echo inc. 2. Place piston at top dead center. Remove muffler (a) and heat shield (b). 3. Use a wood or plastic scraping tool to clean deposits from cylinder exhaust port. Never use a metal tool to scrape carbon from the exhaust port. Do not scratch the cy...

  • Page 33: Pb-265Ln

    Pb-265ln maintenance x7501186202 33 © 3/2018 echo inc. English high altitude operation this engine has been factory adjusted to maintain satisfactory starting, emission, and durability performance up to 1,100 feet above sea level (asl) (96.0 kpa). To maintain proper engine operation and emission com...

  • Page 34: Troubleshooting

    Troubleshooting pb-265ln 34 x7501186202 © 3/2018 echo inc. Troubleshooting fuel vapors are extremely flammable and may cause fire and/or explosion. Never test for ignition spark by grounding spark plug near cylinder plug hole, otherwise serious personal injury may result. Engine problem troubleshoot...

  • Page 35: Pb-265Ln

    Pb-265ln storage x7501186202 35 © 3/2018 echo inc. English storage during operation the muffler or catalytic muffler and surrounding cover become hot. Always keep exhaust area clear of flammable debris during transportation or when storing, otherwise serious property damage or personal injury may re...

  • Page 36: Storage

    Storage pb-265ln 36 x7501186202 © 3/2018 echo inc. Long term storage (over 30 days) do not store your unit for a prolonged period of time (30 days or longer) without performing protective storage maintenance which includes the following: 1. Store unit in a dry, dust free place, out of the reach of c...

  • Page 37: Pb-265Ln

    Pb-265ln specifications x7501186202 37 © 3/2018 echo inc. English specifications model pb-265 ln length 305 mm (12.0 in.) (w/o pipes) width 410 mm (16.1 in.) height 435 mm (17.1 in.) weight (dry) 5.2 kg (11.5 lb.) engine type air cooled, two-stroke, single cylinder gasoline engine bore 34.0 mm (1.34...

  • Page 38: Product Registration

    Product registration pb-265ln 38 x7501186202 © 3/2018 echo inc. Product registration thank you for choosing echo power equipment please go to http://www.Echo-usa.Com/warranty/register-your-echo to register your new product on-line. It's fast and easy! Note: your information will never be sold or mis...

  • Page 39: Pb-265Ln

    Pb-265ln product registration x7501186202 39 © 3/2018 echo inc. English.

  • Page 40: Echo, Incorporated

    Echo, incorporated 400 oakwood road lake zurich, il 60047 www.Echo-usa.Com p43014001001/p43014999999.