1. DL manuals
  2. Echo
  3. Tools
  4. PB-755H
  5. Operator's Manual

Echo PB-755H Operator's Manual

Other manuals for PB-755H: Operator's Manual
Manual is about: Echo Power Blower Operator's Manual

Summary of PB-755H

  • Page 1

    Power blower operator's manual model: pb-755h pb-755t warning read rules for safe operation and all instructions carefully. Echo provides this op- erator's manual which must be read and understood for proper and safe operation. X7531122402 x753002812 12/08.

  • Page 2

    2 copyright© 2008 by echo, incorporated all rights reserved. T able of c ontents introduction ................................................................2 - the operator's manual .......................................2 safety .......................................................................

  • Page 3

    3 p ower b lower o perator ' s m anual s afety manual safety symbols and important information throughout this manual and on the product itself, you will find safety alerts and helpful, informational messages preceded by symbols or key words. The following is an explanation of those symbols and key ...

  • Page 4

    4 physical condition your judgment and physical dexterity may not be good: • if you are tired or sick, • if you are taking medication, • if you have taken alcohol or drugs. Operate unit only if you are physically and mentally well. Eye protection wear eye protection that meets ansi z87.1 or ce requi...

  • Page 5

    5 p ower b lower o perator ' s m anual danger do not operate this product indoors or in inadequately ventilated areas. Engine exhaust contains poisonous emissions and can cause serious injury or death. Read the manuals • provide all users of this equipment with the operator’s manual and safety manua...

  • Page 6

    6 an emission control label is located on the unit. (this is an example only, information on label varies by engine family). Equipment check warning use only echo approved attachments. Serious injury may result from the use of a non-approved attachment combi- nation. Echo, inc. Will not be responsib...

  • Page 7: Category III

    7 p ower b lower o perator ' s m anual 1 2 7 8 9 10 4 3 d escription pb-755h locate these safety decals on your unit. Make sure the decals are legible and that you understand and follow the instruc- tions on them. If a decal cannot be read, a new one can be ordered from your echo dealer. See parts o...

  • Page 8

    8 1. Air cleaner - contains replaceable air filter element. 2. Spark plug - provides spark to ignite fuel mixture. 3. Safety decal - lists important safety precautions. 4. Spark arrestor - catalytic muffler / muffler - the muffler or catalytic muffler controls exhaust noise and emission. The spark a...

  • Page 9: Category III

    9 p ower b lower o perator ' s m anual pb-755t locate these safety decals on your unit. Make sure the decals are legible and that you understand and follow the instruc- tions on them. If a decal cannot be read, a new one can be ordered from your echo dealer. See parts ordering instructions for speci...

  • Page 10

    10 1. Air cleaner - contains replaceable air filter element. 2. Spark plug - provides spark to ignite fuel mixture. 3. Safety decal - lists important safety precautions. 4. Spark arrestor - catalytic muffler / muffler - the muffler or catalytic muffler controls exhaust noise and emission. The spark ...

  • Page 11

    11 p ower b lower o perator ' s m anual c ontents pb-755h ___ 1 - power head ___ 1 - flex pipe ___ 1 - pipe w/swivel ___ 1 - straight pipe ___ 1 - straight pipe ___ 1 - operator's manual ___ 1 - warranty registration card ___ 1 - echo emissions and warranty statement ___ 1 - plastic bag ___ 2 - clam...

  • Page 12

    12 a ssembly pb-755h warning never perform maintenance or assembly procedures with engine running or serious personal injury may result. Install blower pipes / stick handle 1. Assemble clamps (a) onto both ends of flexible pipe (b). 2. Assemble swivel pipe (c) into flexible pipe (b) and tighten clam...

  • Page 13

    13 p ower b lower o perator ' s m anual pb-755t warning never perform maintenance or assembly procedures with engine running or serious personal injury may result. Install blower pipes 1. Place guide loop (g) across elbow clamp, and turn until clips fully engage clamp band. 2. Assemble clamps (a) on...

  • Page 14

    14 o peration warning moving parts can amputate fingers or cause severe injuries. Keep hands, clothing and loose objects away from all openings. Always stop engine, disconnect spark plug, and make sure all moving parts have come to a complete stop before removing obstructions, clearing debris, or se...

  • Page 15

    15 p ower b lower o perator ' s m anual mixing instructions 1. Fill an approved fuel container with half of the required amount of gasoline. 2. Add the proper amount of 2-stroke oil to gasoline. 3. Close container and shake to mix oil with gasoline. 4. Add remaining gasoline, close fuel container, a...

  • Page 16

    16 starting cold engine • recoil starter: use short pulls - only 1/2-2/3 of rope length for start- ing. Do not allow the rope to snap back in. Always hold the unit firmly. Pb-755h 1. Throttle lever move throttle lever (a) to idle detent position. Pb-755t 1. Throttle lever/stop switch move throttle l...

  • Page 17

    17 p ower b lower o perator ' s m anual starting warm engine pb-755h 1. Throttle lever move throttle lever (a) to idle detent position. Pb-755t 1. Throttle lever/stop switch move throttle lever (a) forward to idle position. Slide stop switch (b) forward to run position. Pb-755h, pb-755t 2. Recoil st...

  • Page 18

    18 warning always wear safety glasses, hearing protection, a face filter mask and take all safety precautions or serious personal injury may result. Do not point the blower pipe in the direction of people or pets. Read the safety section on pages 4 - 6 carefully. Important to avoid engine damage due...

  • Page 19

    19 p ower b lower o perator ' s m anual your echo blower is designed to provide many hours of trouble free service. Regular scheduled maintenance will help your blower achieve that goal. If you are unsure or are not equipped with the necessary tools, you may want to take your unit to an echo service...

  • Page 20

    20 air filter level 1. Tools required: 25 - 50mm (1 - 2 in.) cleaning brush parts required: tune up kit note always brush dirt and debris away from air cleaner area prior to cleaning air filter. 1. Brush dirt off air cleaner area. Keep dirt away from engine and air intake grid. 2. Remove air filter ...

  • Page 21

    21 p ower b lower o perator ' s m anual fuel filter level 1. Tools required: 200 - 250 mm (8 - 10 in.) length of wire with one end bent into a hook, clean rag, funnel, and an approved fuel container parts required: repower tm tune up kit danger fuel is very flammable. Use extreme care when mixing, s...

  • Page 22

    22 cooling system level 2. Tools required: 25 - 50mm (1 - 2 in.) cleaning brush, cross head screwdriver parts required: none, if you are careful. Important to maintain proper engine operating temperatures, cooling air must pass freely through the cylinder fin area. This flow of air carries com- bust...

  • Page 23

    23 p ower b lower o perator ' s m anual exhaust system spark arrestor screen level 2. Tools required: cross head screwdriver parts required: spark arrestor screen, gaskets warning do not perform maintenance on engine or muffler until engine and muffler are completely cool, otherwise serious personal...

  • Page 24

    24 exhaust port cleaning level 2 tools required: wood or plastic scraper, cross head screwdriver, 4 & 5mm hex wrench parts required: as needed: muffler gasket 1. Remove spark plug lead from spark plug, and remove engine cover (5 screws). 2. Place piston at top dead center. Remove muffler (a) and muf...

  • Page 25

    25 p ower b lower o perator ' s m anual carburetor adjustment engine break-in new engines must be operated a minimum duration of two tanks of fuel break-in before carburetor adjustments can be made. During the break- in period your engine performance will increase and exhaust emissions will stabiliz...

  • Page 26

    26 t roubleshooting danger fuel vapors are extremely flammable and may cause fire and/or explosion. Never test for ignition spark by ground- ing spark plug near cylinder plug hole, otherwise serious personal injury may result. T r a h c g n i t o o h s e l b u o r t m e l b o r p k c e h c s u t a t...

  • Page 27

    27 p ower b lower o perator ' s m anual danger do not store in enclosure where fuel fumes may ac- cumulate or reach an open flame or spark. 2. Place the stop switch in the "stop" position. 3. Remove accumulation of grease, oil, dirt and debris from exterior of unit. 4. Perform all periodic lubricati...

  • Page 28

    28 s pecifications model ---------------------------------------------------- pb-755h, pb-755t length ------------------------------------------------------ 375 mm (14.8 in.) width -------------------------------------------------------- 485 mm (19 in.) height ---------------------------------------...

  • Page 29

    29 p ower b lower o perator ' s m anual notes.

  • Page 30

    30 notes.

  • Page 31

    31 p ower b lower o perator ' s m anual notes.

  • Page 32

    Dealer? Call 1-800-432-echo 1-800-432-3246 or www.Echo-usa.Com consumer product support 1-800-673-1558 8:30 - 4:30 mon - fri c.S.T. Echo, incorporated 400 o akwood r oad l ake z urich , il 60047 www.Echo-usa.Com s ervicing i nformation parts / serial number genuine echo parts and echo repower™ parts...