1. DL manuals
  2. Echo
  3. Blower
  4. Power Blower PB-230LN
  5. Operator's Manual

Echo Power Blower PB-230LN Operator's Manual

Other manuals for Power Blower PB-230LN: Training Manual, Operator's Manual

Summary of Power Blower PB-230LN

  • Page 1

    Power blower operator's manual model pb-230ln x753001682 04/06 x7531134102 warning danger read rules for safe operation and all instructions carefully. Echo provides this operator's manual which must be read and understood for proper and safe operation..

  • Page 2

    2 copyright© 2006 by echo, incorporated all rights reserved. T able of c ontents introduction ............................................................... 2 - the operator's manual ....................................... 2 safety ......................................................................

  • Page 3

    3 p ower b lower o perator ' s m anual important the enclosed message provides information necessary for the protection of the unit. Note this enclosed message provides tips for use, care and maintenance of the unit. S afety manual safety symbols and important information important note throughout t...

  • Page 4

    4 physical condition your judgment and physical dexterity may not be good: • if you are tired or sick, • if you are taking medication, • if you have taken alcohol or drugs. Operate unit only if you are physically and mentally well. Eye protection wear eye protection that meets ansi z87.1 or ce requi...

  • Page 5

    5 p ower b lower o perator ' s m anual repetitive stress injuries it is believed that overusing the muscles and tendons of the fingers, hands, arms, and shoulders may cause soreness, swelling, numbness, weakness, and extreme pain in those areas. Certain repetitive hand activities may put you at a hi...

  • Page 6

    6 equipment check warning danger use only echo approved attachments. Serious injury may result from the use of a non-approved attachment combination. Echo, inc. Will not be responsible for the failure of cutting devices, attachments or accessories which have not been tested and approved by echo. Rea...

  • Page 7: Category I

    7 p ower b lower o perator ' s m anual 2 3 5 6 8 9 10 11 7 4 d escription locate these safety decals on your unit. Make sure the decals are legible and that you understand and follow the instructions on them. If a decal cannot be read, a new one can be ordered from your echo dealer. See parts order-...

  • Page 8

    8 1. Stop switch - "slide switch" mounted on top of handle. Push forward to start and run. Slide back to stop. 2. Throttle trigger - spring loaded to return to idle when released. During acceleration, press trigger gradually for best operating technique. 3. Spark arrestor - catalytic muffler / muffl...

  • Page 9

    9 p ower b lower o perator ' s m anual a ssembly warning danger never perform maintenance or assembly procedures with engine running or serious personal injury may result. Install blower pipes 1. Align grooves in straight pipe with pegs on blower housing and slide pipe onto housing. 2. Turn straight...

  • Page 10

    10 important spilled fuel is a leading cause of hydrocarbon emissions. Some states may require the use of automatic fuel shut-off containers to reduce fuel spillage. After use • do not store a unit with fuel in its tank. Leaks can occur. Return unused fuel to an approved fuel storage container. Stor...

  • Page 11

    11 p ower b lower o perator ' s m anual important recoil starter: use short pulls - only 45 ~ 60 cm (18 ~ 24 in.) of rope for starting. Do not allow the rope to snap back in. Always hold the unit firmly. 5. Recoil starter place the unit on a flat, clear area. Firmly grasp throttle grip with left han...

  • Page 12

    12 stopping engine 1. Throttle trigger/throttle position lever release throttle trigger (f). Move throttle position lever (b) forward to idle position and allow engine to return to idle before shutting engine off. 2. Stop switch move stop switch (a) to “stop” position. Warning danger if engine does ...

  • Page 13

    13 p ower b lower o perator ' s m anual m aintenance your echo blower is designed to provide many hours of trouble free service. Regular scheduled maintenance will help your blower achieve that goal. If you are unsure or are not equipped with the necessary tools, you may want to take your unit to an...

  • Page 14

    14 air filter level 1. Tools required: 25-50 mm (1-2 in.) medium bristle paint brush. Parts required: 90030 repower tm air and fuel filter kit note clean daily. 1. Close choke (cold start position [ ]). This prevents dirt from entering the carburetor throat when the air filter is removed. Brush accu...

  • Page 15

    15 p ower b lower o perator ' s m anual 0.65 mm (0.026 in.) cooling system level 2. Tools required: 25-50 mm (1-2 in.) medium bristle brush, 3 mm hex wrench, cross head screwdriver. Parts required: none, if you are careful. Important to maintain proper engine operating temperatures, cooling air must...

  • Page 16

    16 cleaning cylinder fins 1. Remove spark plug lead. 2. Remove two upper 3 mm hex screws at recoil starter. 3. Remove engine cover (four screws), pull cover away from engine. Clean cylinder fins to allow cooling air to pass freely. 4. Loosely reassemble engine cover with four cross head and two hex ...

  • Page 17

    17 p ower b lower o perator ' s m anual carburetor adjustment engine break-in new engines must be operated a minimum duration of two tanks of fuel break-in before carburetor adjustments can be made. During the break-in period your engine performance will increase and exhaust emissions will stabilize...

  • Page 18

    18 t roubleshooting t r a h c g n i t o o h s e l b u o r t m e l b o r p k c e h c s u t a t s e s u a c y d e m e r - s k n a r c e n i g n e / d r a h s tr a t s t' n s e o d tr a t s r o t e r u b r a c t a l e u f r o t e r u b r a c t a l e u f o n d e g g o l c r e n i a rt s l e u f d e g g ...

  • Page 19

    19 p ower b lower o perator ' s m anual s torage warning danger during operation the muffler or catalytic muffler and surrounding cover becomes hot. Always keep exhaust area clear of flammable debris during transportation or when storing, otherwise serious property damage or personal injury may resu...

  • Page 20

    20 s pecifications model ----------------------------------------------------- pb-230ln hand held length ------------------------------------------------------- 335 mm (13.2 in.) (w/o pipes) width -------------------------------------------------------- 235 mm (9.3 in.) height ----------------------...

  • Page 21

    21 p ower b lower o perator ' s m anual notes.

  • Page 22

    22 notes.

  • Page 23

    23 p ower b lower o perator ' s m anual notes.

  • Page 24

    Dealer? Call 1-800-432-echo or www.Echo-usa.Com consumer product support 1-800-673-1558 8:30 - 4:30 mon - fri c.S.T. S ervicing i nformation parts / serial number genuine echo parts and echo repower™ parts and assemblies for your echo products are available only from an authorized echo dealer. When ...