- DL manuals
- Echo
- Pole Saw
- Power Pruner PPF-225
- Operator's Manual
Echo Power Pruner PPF-225 Operator's Manual - page 20
20
X7502308106
© 09/2013 ECHO Inc.
OPERATION
PPF-225
Move stop switch button (A) forward away from the STOP
position.
2. Purge Bulb
Pump purge bulb (C) until fuel is visible in the “Clear” fuel
return line. Pump bulb an additional 4 or 5 times.
3. Recoil Starter
Lay the unit on a flat area and keep movable attachment parts
clear of all obstacles. Firmly grip throttle handle and throttle
trigger lockout with left hand. Rapidly pull recoil starter
handle/rope (D) until engine fires.
Note: If engine does not start after 5 pulls, use Cold Start
Procedure.
Stopping Engine
1. Throttle
Release throttle trigger and allow engine to return to idle
before shutting off engine.
2. Stop Switch
Move stop switch button (A) backward to STOP position.
If engine does not stop when stop switch is moved to STOP
position, close choke - COLD START position - to stall
engine. Have your ECHO dealer repair stop switch before using unit again.
C
D
A
Summary of Power Pruner PPF-225
Page 1
Specifications, descriptions and illustrative material in this literature are as accurate as known at the time of publication, but are subject to change without notice. Illustrations may include optional equipment and accessories, and may not include all standard equipment. Operator’s manual x750230...
Page 2: Table of Contents
2 x7502308106 © 09/2013 echo inc. Table of contents ppf-225 table of contents table of contents .............................................................................................................................. 2 introduction .................................................................
Page 3: Introduction
Ppf-225 introduction x7502308106 3 © 09/2013 echo inc. Introduction welcome to the echo family. This echo product was designed and manufactured to provide long life and on-the-job dependability. Read and understand this manual and the safety manual. You will find both easy to use and full of helpful...
Page 4: Safety
4 x7502308106 © 09/2013 echo inc. Safety ppf-225 additional or replacement manuals replacement operator, safety manuals, and parts catalogs are available from your echo dealer or at www.Echo-usa.Com or by contacting echo inc., 400 oakwood road, lake zurich, il 60047 (800-673-1558). Always check the ...
Page 5
Ppf-225 safety x7502308106 5 © 09/2013 echo inc. International symbols personal condition and safety equipment users of this product risk injury to themselves and others if the unit is used improperly and/or safety precautions are not followed. Proper clothing and safety gear must be worn when opera...
Page 6
6 x7502308106 © 09/2013 echo inc. Safety ppf-225 hearing protection echo recommends wearing hearing protection whenever unit is used. Proper clothing wear snug fitting, durable clothing; • pants should have long legs, shirts with long sleeves. • do not wear shorts, • do not wear ties, scarves, jewel...
Page 7
Ppf-225 safety x7502308106 7 © 09/2013 echo inc. Repetitive stress injuries it is believed that overusing the muscles and tendons of the fingers, hands, arms, and shoulders may cause soreness, swelling, numbness, weakness, and extreme pain in those areas. Certain repetitive hand activities may put y...
Page 8
8 x7502308106 © 09/2013 echo inc. Safety ppf-225 keep a solid stance • maintain footing and balance at all times. Do not stand on slippery, uneven or unstable surfaces. Do not work in odd positions or on ladders. Do not over reach. • operate the power pruner tm only from the ground or out of an appr...
Page 9
Ppf-225 safety x7502308106 9 © 09/2013 echo inc. Equipment use only echo approved attachments. Serious injury may result from the use of a non-approved attachment combination. Echo, inc. Will not be responsible for the failure of cutting devices, attachments or accessories which have not been tested...
Page 10
10 x7502308106 © 09/2013 echo inc. Emission control (exhaust & evaporative) ppf-225 emission control (exhaust & evaporative) epa 2010 and later and/or c.A.R.B. Tier iii the emission control system for the engine is em (engine modification) and, if the second to last character of the engine family on...
Page 11: Description
Ppf-225 description x7502308106 11 © 09/2013 echo inc. Description locate the safety decal(s) on your unit. Make sure the decal(s) is legible and that you understand and follow the instructions on it. If a decal cannot be read, a new one can be ordered from your echo dealer. See parts ordering instr...
Page 12
12 x7502308106 © 09/2013 echo inc. Description ppf-225 1. Power head - factory assembled to the driveshaft assembly. Includes the engine, clutch, fuel system, ignition system and recoil starter. 2. Throttle handle - for right hand - contains stop switch, throttle lockout, and throttle trigger. 3. Th...
Page 13: Contents
Ppf-225 contents x7502308106 13 © 09/2013 echo inc. Contents due to packaging restriction the echo product you have purchased requires some assembly. After opening the carton, check for damage. Immediately notify your retailer or echo dealer of damaged or missing parts. Use the contents list to chec...
Page 14: Assembly
14 x7502308106 © 09/2013 echo inc. Assembly ppf-225 assembly cutting attachment to drive shaft installation saw chain is sharp! Always wear gloves when handling assembly, otherwise serious personal injury may result 1. Loosen the two (2) screws (a) and remove locator screw (b) on cutting attachment....
Page 15
Ppf-225 assembly x7502308106 15 © 09/2013 echo inc. 4. Hold the bar nose up, and turn the adjuster screw (b) clockwise until the chain fits snugly against the underside of the bar, as shown. Cold chain only - turn adjuster screw cw an additional 1/8 - 1/4 turn. 5. Tighten both guide bar nuts with no...
Page 16: Operation
16 x7502308106 © 09/2013 echo inc. Operation ppf-225 operation moving parts can amputate fingers or cause severe injuries. Keep hands, clothing and loose objects away from all openings. Always stop engine, disconnect spark plug, and make sure all moving parts have come to a complete stop before remo...
Page 17
Ppf-225 operation x7502308106 17 © 09/2013 echo inc. • fuel tanks/cans may be under pressure. Always loosen fuel caps slowly allowing pressure to equalize. • never refuel a unit when the engine is hot or running! • do not fill fuel tanks indoors. Always fill fuel tanks outdoors over bare ground. • d...
Page 18
18 x7502308106 © 09/2013 echo inc. Operation ppf-225 lubricating the guide bar and saw chain automatic oiling system 1. Wipe debris from around oil fill cap. 2. Remove oil fill cap and fill reservoir with a quality, low viscosity guide bar and saw chain oil. To prevent plastic deterioration, do not ...
Page 19
Ppf-225 operation x7502308106 19 © 09/2013 echo inc. Move choke lever (b) to cold start position ( ). 3. Purge bulb pump purge bulb (c) until fuel is visible and flows freely in the clear fuel tank return line. Pump bulb an additional 4 or 5 times. 4. Recoil starter lay the unit on a flat area and k...
Page 20
20 x7502308106 © 09/2013 echo inc. Operation ppf-225 move stop switch button (a) forward away from the stop position. 2. Purge bulb pump purge bulb (c) until fuel is visible in the “clear” fuel return line. Pump bulb an additional 4 or 5 times. 3. Recoil starter lay the unit on a flat area and keep ...
Page 21
Ppf-225 operation x7502308106 21 © 09/2013 echo inc. Pruning techniques engine exhaust is hot, and contains carbon monoxide (co), a poison gas. Breathing co can cause unconsciousness, serious injury, or death. Exhaust can cause serious burns. Always position unit so that exhaust is directed away fro...
Page 22: Maintenance
22 x7502308106 © 09/2013 echo inc. Maintenance ppf-225 maintenance moving parts can amputate fingers or cause severe injuries. Keep hands, clothing and loose objects away from all openings. Always stop engine, disconnect spark plug, and make sure all moving parts have come to a complete stop before ...
Page 23
Ppf-225 maintenance x7502308106 23 © 09/2013 echo inc. * replacement is recommended based on the finding of damage or wear during inspection. Air filter level 1. 1. Close choke (cold start position [ ]). This prevents dirt from entering the carburetor throat when the air filter is removed. Brush acc...
Page 24
24 x7502308106 © 09/2013 echo inc. Maintenance ppf-225 spark plug level 2. Use only ngk bpm-8y spark plug (bpmr-8y in canada) otherwise severe engine damage may occur. 1. Remove spark plug and check for fouling, worn and rounded center electrode. 2. Clean the plug or replace with a new one. Do not s...
Page 25
Ppf-225 maintenance x7502308106 25 © 09/2013 echo inc. 2. Remove air cleaner cover (a). 3. Remove engine cover (b). Do not use a metal scraper to remove dirt from the cylinder fins. 4. Use brush to remove dirt from the cylinder fins. 5. Remove ignition wires from clip for cleaning. 6. Remove grass a...
Page 26
26 x7502308106 © 09/2013 echo inc. Maintenance ppf-225 exhaust port cleaning level 2. 1. Remove spark plug lead from spark plug, and remove engine cover. 2. Place piston at top dead center. Remove muffler (a) and heat shield (b). 3. Use a wood or plastic scraping tool to clean deposits from cylinder...
Page 27
Ppf-225 maintenance x7502308106 27 © 09/2013 echo inc. Note: every unit is run at the factory and the carburetor is set in compliance with emission regulations. Carburetor adjustments, other than idle speed, must be performed by an authorized echo dealer. 1. Check idle speed and reset if necessary. ...
Page 28
28 x7502308106 © 09/2013 echo inc. Maintenance ppf-225 guide bar replacement / installation level 2. 1. Remove two (2) guide bar nuts (a) and sprocket cover screw (b), and turn saw chain tension adjustment screw (c) counterclockwise to release tension. 2. Remove guide bar cover (d). 3. Remove guide ...
Page 29
Ppf-225 maintenance x7502308106 29 © 09/2013 echo inc. 2. Disconnect spark plug lead. 3. Loosen two guide bar nuts (a) until finger tight. Always loosen guide bar nuts before turning the chain tension adjuster, otherwise the clutch cover and tensioner will be damaged. 4. Hold the bar nose up, and tu...
Page 30
30 x7502308106 © 09/2013 echo inc. Maintenance ppf-225 dull or damaged cutters will result in poor cutting performance, increased vibration, and premature saw chain failure. Level 2 always stop engine and disconnect spark plug wire before servicing guide bar and saw chain. Always wear gloves when fi...
Page 31
Ppf-225 maintenance x7502308106 31 © 09/2013 echo inc. 7. Apply clean oil and rotate saw chain slowly to wash away filings. 8. If saw chain is coated or clogged with resin, clean in kerosene, then soak in oil. 6 55 top plate angle top plate cutting angle depth gague.
Page 32: Troubleshooting
32 x7502308106 © 09/2013 echo inc. Troubleshooting ppf-225 troubleshooting fuel vapors are extremely flammable and may cause fire and/or explosion. Never test for ignition spark by grounding spark plug near cylinder plug hole, otherwise serious personal injury may result. Engine problem troubleshoot...
Page 33: Storage
Ppf-225 storage x7502308106 33 © 09/2013 echo inc. Storage during operation the muffler or catalytic muffler and surrounding cover become hot. Always keep exhaust area clear of flammable debris during transportation or when storing, otherwise serious property damage or personal injury may result. Lo...
Page 34: Specifications
34 x7502308106 © 09/2013 echo inc. Specifications ppf-225 specifications model ppf-225 length 2,455 m (96.7 in.) width 246 m (9.69 in.) height 235 m (9.25 in.) weight (dry) 6.3 kg (13.9 lb.) engine type air cooled, two-stroke, single cylinder gasoline engine bore 32.2 mm (1.27 in.) stroke 26.0 mm (1...
Page 35: Warranty Statements
Ppf-225 warranty statements x7502308106 35 © 09/2013 echo inc. Warranty statements echo limited warranty statement for product sold in usa and canada beginning 01/01/2010 echo's responsibility echo incorporated’s limited warranty, provides to the original purchaser that this echo product is free fro...
Page 36
36 x7502308106 © 09/2013 echo inc. Warranty statements ppf-225 purchased repair parts, short blocks and accessories &gj** &^j* attention two-stroke engine power product owners this echo two-stroke engine power product is a quality-engineered unit which has been manufactured to exact tolerances to pr...
Page 37: Notes
Ppf-225 notes x7502308106 37 © 09/2013 echo inc. Notes.
Page 38
38 x7502308106 © 09/2013 echo inc. Notes ppf-225.
Page 39
Ppf-225 notes x7502308106 39 © 09/2013 echo inc..
Page 40
Echo, incorporated 400 oakwood road lake zurich, il 60047 www.Echo-usa.Com 40 s63311001001/s63311999999 s63212001001/s63212999990