1 7058-206e august 30, 2016 notice: do not discard this manual owner’s manual operation & care installer: leave this manual with party responsible for use and operation. Owner: retain this manual for future reference. Contact your dealer with questions on installation, operation, or service. Hot sur...
2 7058-206e august 30, 2016 heatilator eco choice confidential property of hearth & home technologies inc. Part name: drawn by: scale: material: sheet: part number: rev: this print is checked and controlled by the engineering departments of hearth & home technologies inc. Eco # date by rev unless ot...
August 30, 2016 7058-206e 3 heatilator eco choice table of contents safety alert key: • danger!Indicates a hazardous situation which, if not avoided will result in death or serious injury. • warning! Indicates a hazardous situation which, if not avoided could result in death or serious injury. • cau...
4 7058-206e august 30, 2016 heatilator eco choice warranty period heatilator eco-choice appliances components covered parts labor pellet epa wood 1 year x x all parts and material except as covered by conditions, exclusions, and limitations listed 3 years x firepots and burnpots 3 years 1 year x x c...
August 30, 2016 7058-206e 5 heatilator eco choice warranty coverage: • this warranty only covers hht appliances that are purchased through an hht authorized dealer or distributor. A list of hht authorized dealers is available on th hht branded websites. • this warranty is only valid while the hht ap...
6 7058-206e august 30, 2016 heatilator eco choice model eco-adv-ps35, eco-adv-ps50 and eco-cab50 laboratory intertek report no. 4001508 type solid fuel room heater/pellet fuel burning type standard astm e1509-04 and ulc s627-00, ulc/ord-c1482-m1990 room heater pellet fuel burning type and (um) 84- h...
August 30, 2016 7058-206e 7 heatilator eco choice user guide 2 operating instructions a. Fire safety to provide reasonable fire safety, the following should be given serious consideration: • install at least one smoke detector and co monitor on each floor of your home. • locate detectors away from t...
8 7058-206e august 30, 2016 heatilator eco choice hot while in operation. Keep children, clothing and furniture away. Contact may cause skin burns. Caution changing to different fuel type • empty the hopper of the previous fuel • thoroughly vacuum hopper before filling with the new fuel • select the...
August 30, 2016 7058-206e 9 heatilator eco choice hopper lid latch hopper switch push bottom of latch inward to release g. Hopper lid latch and hopper switch 1. Lift up the hopper lid and lock into open position. Now you can fill the hopper with fuel. 2. The hopper switch is designed to shut down th...
10 7058-206e august 30, 2016 heatilator eco choice i. Fire characteristics a properly adjusted fire with the heat output control switch set on “high” has a short active flame pattern that extends out of the firepot approximately 4 to 8 inches (102 to 203mm). If the fire has tall flames with black ta...
August 30, 2016 7058-206e 11 heatilator eco choice m. Quick start guide eco choice quick start guide *before you plug in this appliance, follow these instructions* once a fi re has been established in the unit, leave the unit burning on the “high” setting for 30 min- utes to allow the paint to cure....
12 7058-206e august 30, 2016 heatilator eco choice n. Frequently asked questions contact your dealer for additional information regarding operation and troubleshooting. Visit www.Heatilator.Com to find a dealer. What causes my glass to become dirty? If the glass has white ash build up it is normal a...
August 30, 2016 7058-206e 13 heatilator eco choice 3 maintenance and service c. General maintenance 1. Types of fuel depending on the type of fuel you are burning will dictate how often you have to clean your firepot. If the fuel you are burning has a high dirt or ash content, it may be necessary to...
14 7058-206e august 30, 2016 heatilator eco choice 3. Ash removal from firebox • frequency: weekly or more frequently depending on ash build-up. • by: homeowner a. There must not be any hot ashes in the firebox during cleaning so allow the appliance to completely cool. The firebox ash should be remo...
August 30, 2016 7058-206e 15 heatilator eco choice 5. Disposal of ashes • frequency: as needed • by: homeowner ashes should be placed in a metal container with a tight-fitting lid. The closed container of ashes should be placed on a non-combustible floor or on the ground, well away from all combusti...
16 7058-206e august 30, 2016 heatilator eco choice 10. Cleaning the glass • frequency: when clear view of the firepot becomes obscure • by: homeowner a. Appliance must be completely cool before cleaning glass. B. Vacuum fly ash from glass and door rope. C. Use a damp paper towel or any non-abrasive ...
August 30, 2016 7058-206e 17 heatilator eco choice d. High ash fuel content maintenance • frequency: as needed • by: homeowner poor quality pellet fuel, or lack of maintenance, can create conditions that make the firepot fill quickly with ashes and clinkers. This condition makes the appliance suscep...
18 7058-206e august 30, 2016 heatilator eco choice with proper installation, operation, and maintenance your appliance will provide years of trouble-free service. If you do experience a prob- lem, this troubleshooting guide will assist a qualified service person in the diagnosis of a problem and the...
August 30, 2016 7058-206e 19 heatilator eco choice symptom possible cause corrective action slow or smoky start-up (cont’d) dirty exhaust and/or venting system. Wet fuel / poor quality fuel check for ash build up in unit, includ- ing behind rear panels, firebox, exhaust blower and venting. Replace f...
20 7058-206e august 30, 2016 heatilator eco choice symptoms possible cause corrective action convection blower fails to start. #1 snap disc defective. Blower not plugged in. Blower is defective or object jammed in impeller. Control box is defective. Replace snap disc. Check that blower is plugged in...
August 30, 2016 7058-206e 21 heatilator eco choice a. Convection blower replacement 1. Turn down the thermostat, let appliance completely cool and then unplug appliance before servicing. 2. The convection blower is located on the floor at the rear of the appliance. 3. Lift the hopper lid up until it...
22 7058-206e august 30, 2016 heatilator eco choice b. Exhaust blower replacement 1. Turn down the thermostat, let appliance completely cool and then unplug appliance before servicing. 2. Remove both upper and lower right side curtains. Figure 22.2. On page 22. 3. Disconnect 2 white wires from the wh...
August 30, 2016 7058-206e 23 heatilator eco choice figure 23.1 remove screw snap disc bracket d. Igniter replacement 1. Shut down the appliance by turning down the thermostat and let the appliance completely cool down . After the appliance has cooled down, unplug it and remove the ash drawer. 2. The...
24 7058-206e august 30, 2016 heatilator eco choice • glass is 5mm thick high temperature heat-re- sistant ceramic glass. • do not replace with any other material. • alternate material may shatter and cause injury. Warning f. Glass replacement 1. Open the door from the appliance by lifting door off o...
August 30, 2016 7058-206e 25 heatilator eco choice 6 reference materials 2. Convection blower the convection blower is mounted at the bottom rear of the appliance. There are 2 impellers, one on each side of the motor. The convection blower pushes heated air through the heat exchange system into the ...
26 7058-206e august 30, 2016 heatilator eco choice 12. Red call light the red call light is on the side of the junction box, below the fuse. The function of the red call light is to indicate that the thermostat is calling for heat. 13. Reset button the reset button is located on the back of the appl...
August 30, 2016 7058-206e 27 heatilator eco choice figure 27.2 figure 27.1 figure 27.3 control box junction box red call light fuse convection blower located behind left side panels feed motor vacuum switch combustion blower located behind right side panels back of appliance power outlet terminal bl...
28 7058-206e august 30, 2016 heatilator eco choice service parts beginning manufacturing date: apr 2010 ending manufacturing date: active eco-adv-ps35 part number list on following page. Free standing pellet stove 1 2 4 5 6 7 3 8 9 10 14 15 16 12 13 11 17 18 19 20 21 23 25 24 26 29 30 28 27 22 08/16...
August 30, 2016 7058-206e 29 heatilator eco choice service parts beginning manufacturing date: apr 2010 ending manufacturing date: active eco-adv-ps35 important: this is dated information. Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to cons...
30 7058-206e august 30, 2016 heatilator eco choice service parts beginning manufacturing date: apr 2010 ending manufacturing date: active eco-adv-ps35 important: this is dated information. Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to cons...
August 30, 2016 7058-206e 31 heatilator eco choice service parts beginning manufacturing date: apr 2010 ending manufacturing date: active eco-adv-ps35 important: this is dated information. Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to cons...
32 7058-206e august 30, 2016 heatilator eco choice service parts beginning manufacturing date: apr 2010 ending manufacturing date: active eco-adv-ps50 part number list on following page. Free standing pellet stove 1 2 4 5 6 7 3 8 9 10 14 15 16 12 13 11 17 18 19 20 21 23 25 24 26 29 30 28 27 22 08/16...
August 30, 2016 7058-206e 33 heatilator eco choice service parts beginning manufacturing date: apr 2010 ending manufacturing date: active eco-adv-ps50 important: this is dated information. Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to cons...
34 7058-206e august 30, 2016 heatilator eco choice service parts beginning manufacturing date: apr 2010 ending manufacturing date: active eco-adv-ps50 important: this is dated information. Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to cons...
August 30, 2016 7058-206e 35 service parts beginning manufacturing date: apr 2010 ending manufacturing date: active eco-adv-ps50 important: this is dated information. Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to consumers. Provide model n...
36 7058-206e august 30, 2016 service parts eco-cab50 beginning manufacturing date: may 2011 ending manufacturing date: active part number list on following page. Pellet cabinet style stove 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 21 20 25 24 23 22 26 27 28 29 30 08/16 e. Exploded drawings & s...
August 30, 2016 7058-206e 37 service parts eco-cab50 beginning manufacturing date: may 2011 ending manufacturing date: active important: this is dated information. Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to consumers. Provide model numb...
38 7058-206e august 30, 2016 service parts eco-cab50 beginning manufacturing date: may 2011 ending manufacturing date: active important: this is dated information. Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to consumers. Provide model numb...
August 30, 2016 7058-206e 39 service parts eco-cab50 beginning manufacturing date: may 2011 ending manufacturing date: active important: this is dated information. Parts must be ordered from a dealer or distributor. Hearth and home technologies does not sell directly to consumers. Provide model numb...
40 7058-206e august 30, 2016 do not discard this manual caution • important operating and maintenance instruc- tions included. • leave this manual with party responsible for use and operation. • read, understand and follow these instruc- tions for safe installa- tion and operation. Do not discard co...
