- DL manuals
- Ecom Instruments
- Flashlight
- Lite-Ex PL 10
- Operating Instructions Manual
Ecom Instruments Lite-Ex PL 10 Operating Instructions Manual
Summary of Lite-Ex PL 10
Page 1
Operating instructions lite-ex pl 10 produktbereich portable handlampen 120 g kg led zone 0/20 0 1 2 3 4 5 6 7 147 x 36 x 36 mm 3.000 lux 1m abstand.
Page 2
17 note: the current operating manual, the ec declarati- on of conformity and the ec-type examination certificate can be downloaded from the relevant product page at www.Ecom-ex.Com, or alterna- tively they can be requested directly from the manufacturer. Table of contens 1. Application 18 2. Safety...
Page 3
18 1. Application the lite-ex pl 10 is a compact, robust and easy-to-use led flashlight for industrial applica- tion in ex-hazardous areas classified as zone 2, 1 and 0, as well as zone 22, 21 and 20, in ac- cordance with directive 1999/92/ec (atex 137). 2. Safety precautions these operating instruc...
Page 4
19 - unit markings or inscriptions are illegible. - malfunctions occur. - permitted limit values have been exceeded. 4. Safety regulations use of this unit assumes that the operator obser- ves the conventional safety regulations and has read the certificate in order to eliminate faulty operation of ...
Page 5
20 5. Safety precautions risk of blinding! - do not look directly into the light beam - do not aim the light directly into the eyes of another person 6. Ex-data ec type approval test certificate no.: zelm 05 atex 0272 x ex-designation: ii 1g ex ia op is iic t4 ga ii 1d ex ia iiic t130 °c da approved...
Page 6
21 7. Technical specifications ambient temperature ta: -20 °c ... +50 °c storage temperature: -30 °c ... +60 °c batteries / power supply: 3 x lr03 according to iec, aaa lamp: high performance led: 3000 lx operating time: 1200 lx after 3 hours, approx. 150 lx after 6 hours (at a distance of 1 m) dime...
Page 7
22 8. Functional description / operating instructions please read these operating instructions care- fully so that you are familiar with, and are able to use, all of the functions of your lite-ex pl 10. For your own safety and informa- tion please read the instructions on the following pages careful...
Page 8
23 8.3 battery replacement the batteries should be replaced if the level of luminance is no longer deemed to be satisfac- tory. It is advisable to change all 3 batteries at the same time. Only the appropriate, approved types of batteries may be used (refer to the table with details of the type-teste...
Page 9
24 can now be removed and cleaned. When it has been cleaned replace the ring switch and rotate it until it engages firmly in place (magnet must be positioned on the shaft - ecom address side). The lamp head can then be screwed back onto the flashlight. 8.5 led replacement the lite-ex pl 10 is equipp...
Page 10
25 ring is set in a groove under the protective disc). When replacing the lamp head on the led housing make sure the seal and disc are seated properly. After assembly no part of the seal should be visible through the opening where the beam is emitted. If the led housing or lens has been damaged, the...
Page 11
26 9. Repair repairs are to be conducted by ecom instru- ments gmbh or by personnel or service centres authorised by ecom instruments gmbh, because the safety of the unit needs to be tested after repairs are implemented. 10. Disposal old electrical devices as well as „historical“ old electrical devi...
Page 12
27 hazard and can cause chemical injuries if it is used improperly. Neither the battery nor the battery cells should be opened or disassembled and they should not be burned or exposed to temperatures exceeding 100 °c. If the battery needs to be disposed of, it can be removed as described under point...
Page 13
28 12. Warranty and liability in accordance with our general terms and conditions ecom instruments gmbhprovides a warranty for this product for a period of two ye- ars regarding its function and material under the specified and permitted operating and mainte- nance conditions. This excludes all part...
Page 14
29 tioned limitations and exclusions are not valid for every purchaser. Should any such clause of these warranty conditions be declared ineffective or unenforceable by a competent court, then the effectiveness or enforceability of any of the other conditions of these warranty conditions shall remain...
Page 15
30 13. Ec declaration of conformity mobile experts ecom instruments gmbh · industriestraße 2 · 97959 assamstadt · germany tel.: +49(0) 62 94 / 42 24-0 · fax: +49(0) 62 94 / 42 24-100 · e-mail: sales@ecom-ex.Com · www.Ecom-ex.Com communication portable lighting mobile computing measuring & calibratio...
Page 16
31 14. Ec-type examination certificate 1) the following special conditions according to the ec type approval test certificate must be observed: opening the housing within the explosive area is not permitted. 1. The installed batteries may only be exchanged outside the explosive area and only by thos...
Page 17
Pa000384 / 7500 / 10 / 2010 weee-reg.-nr. De 934 99306 900004al02a02 10 / 2010 Änderungen vorbehalten! Subject to change without notice! Ecom instruments gmbh industriestraße 2 • 97959 assamstadt • germany • tel.: +49 (0) 62 94 / 42 24-0 fax: +49 (0) 62 94 / 42 24-100 • e-mail: sales@ecom-ex.Com • w...