- DL manuals
- Ecoplus
- Heat Pump
- SWBC-13.5H-B
- Installation Instructions Manual
Ecoplus SWBC-13.5H-B Installation Instructions Manual
Summary of SWBC-13.5H-B
Page 1
Installation & instruction manual air source heat pump water heater model: swbc-13.5h-b swbc-19.5h-b-s swbc-24.0h-a-s.
Page 2
Ⅰ .To our customers(before installation) Ⅱ .Product introducing -----------------------------------------------------------------------2 Ⅲ .Work principle ------------------------------------------------------------------------------3 Ⅳ .Performance data ---------------------------------------------...
Page 3
Dear sir: Ⅰ. To our customers water heater in order to use this machine safely, please read this intruction manual carefully before using and installation. Heat pump water heater is a professional machine, it may cause damage or hazard when wrong installed, it should be installed by a competent pers...
Page 4
Product introducing safe and reliable unlike traditional electric water heater, heat pump water heater do not directly generate heat by electricity , it use less electricity to move heat from one place to another , electric circuit is separated from water circuit ,which is also not easy for electric...
Page 5
Work principle the low temperature and low pressure refrigerant gas come from the evaporate to the compressor, after the compressor compress it , the refrigerant gas became high temperature and high pressure. Then the gas come into the water condensation into liquid, emit a lot of condensation heat,...
Page 6
Performance data air source heat pump water heater sidewind series 380v/3ph/50hz swbc-13.5h-b 13500 3.6 16.7 580 220v/1ph/50hz 1 1 1 90 950 58 1115*470*685 115 19500 4.9 7.5 x3 838 swbc-1 9 .5h-b-s 55℃ 60℃ 1 1 2 90x2 950 62 1115*470*1250 147 24000 6.7 11.2 x3 1020 swbc- 24 . 0 h- a -s 1.25 1 1 250 8...
Page 7
Swbc-13.5h-b swbc-19.5h-b-s swbc- 24.0 h- a -s b a c d e h g f a b c d e f g h model size measure: mm the dimension for air source heat pump water heater Ⅴ .Dimension water heater 5 780 7 8 0 1 0 3 5 1 0 0 2 7 5 440 760 425 470 1115 685 310 59 swbc-13.5h-b 440 760 425 470 1115 265 55 1250 swbc-19.5h...
Page 8
The dimension for high efficiency tube in shell heat exchanger measure: mm measure: mm Ⅴ .Dimension water heater model size 388 310 h h1 swbc-13.5h-b 6 model size swbc-19.5h-b-s swbc-24.0h-a-s 350 265 310 220 h h1.
Page 9: 1) Controller Introduction
Ⅵ .Operation introductions water heater 1) controller introduction on/off mode up/down set timer 1 2 cooling mode set point temp heating mode tank outlet temp timer on timer off clock timer on/ off sign first timer second timer press button to turn on or turn off the unit. Press button to choose hea...
Page 10
Ⅵ .Operation introductions water heater press or to directly adjust the temperature. Press button and button at the same time, can turn on/off electrical heating. Press button and buttons for 3 seconds, force defrosting function is on. Press button once, to enter clock setting. When long press this ...
Page 11
Ⅵ .Operation introductions water heater setting about s1 & s2 switch s1 switch---second set point s2 switch---long distance demand for heating please refer to the wiring diagram for the location of above s1 & s2 switch. 1)heat pump turns on when s2 switch has well connected. While s2 has connected, ...
Page 12: Malfunction Data
Ⅵ .Operation introductions water heater 3) malfunction data malfunctions communication failure water tank sensor failure ambient temp sensor failure coil temp sensor failure exhaust temp sensor failure gas suction temp sensor failure water inlet temp sensor failure water flow switch protection high ...
Page 13
Wire circuit diagram water heater applicable model: swbc-13.5h-b 11 applicable model: swbc-19.5h-b-s electronic expansion valve wire controller hp-sw lp-sw flow-sw to ac contactor of e-heater to ac contactor of water pump from power compressor ac contactor fan motor n-linker com-linker 4-w a y fm1 c...
Page 14
Wire circuit diagram Ⅶ .Wire circuit diagram water heater applicable model: swbc-24.0h-a-s 12 electronic expansion valve t1 t2 t3 t4 t5 t6 coil temp sensor ambient temp sensor tank temp sensor t2 t3 t1 suction temp sensor water inlet temp sensor exhaust temp sensor t6 t4 t5 s1 second set point s2 lo...
Page 15
Installation instructions 1. Unit installation 1).Installation location host unit 1 should be installed in a larger & well-ventilated place. 1 installation location should ensure unhindered access outlet (inlet & outlet shown as below). 1 install gutter or set up positions near the outfall, to facil...
Page 16
Installation instructions 2. Pipeline connecting installation notes: 1 water drain pipes, overflow pipes should be installed next to the drainage inlets to facilitate drainage, vent valve should be installed on vent pipes. 1 repair valve should be installed in front of the electromagnetic valve on t...
Page 17
Installation instructions running test and operation 1. Preparatory work before the running test. A) inspection of heat pump water heater units: 1 check if the unit appearance and the pipeline system were damaged during transport. 1 check if there is air exist in the water pipes, if yes, should empt...
Page 18
Running test and operation 2.Running test this running test must be performed by professional staff! 1 overall test can be run if the entire system inspection is conformed to regulations. 1 connected to power, start the heat pump, host unit delays three minutes then auto-start. For three-phase power...
Page 19
Maintenance heat pump water heater is a high automatic equipment, please perform regular inspection termly. If the unit can be long-term and efficiently maintenance, the operating reliability and service life will have an unexpected increase. 1.The extra water filters should be cleaned regularly to ...
Page 20
Air source heat pump-water heater.