1. DL manuals
  2. Edelbrock
  3. Automobile Parts
  4. 1596
  5. User Manual

Edelbrock 1596 User Manual

Manual is about: 2010-2012 Camaro SS Supercharger

Summary of 1596

  • Page 1

    Edelbrock 2010-2012 camaro ss supercharger part #’s: 1596, 1597, 1598, 1599, 15997.

  • Page 2: Introduction

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 1 edelbrock llc, 2700 california street, torrance, ca 90503 toll-free tech line: 1-800-416-8628 office/sales line:...

  • Page 3: Important Warnings

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 2 due to the complexity of the edelbrock e-force supercharging system, it is recommended that this system only be ...

  • Page 4

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 3 bag #1 bag #2 (2x) - m8 washer (3x) - m8 x 1.25 x 20mm hex flange bolt (1x) - m10 x 1.5 x 65mm hex flange bolt (...

  • Page 5

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 4 bag #3 (11x) - m8 x 1.25 x 25mm countersunk socket head bolt (8x) - m6 x 1 x 45mm hex flange bolt (4x) - m6 x 1 ...

  • Page 6

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 5 bag #5 (4x) - coil cover bracket (1x) - coil cover dipstick grommet (4x) - coil cover retainer stud (4x) - coil ...

  • Page 7

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 6 intercooler hose assembly heater core hose assembly intercooler reservoir to water pump hose manifold to evap so...

  • Page 8

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 7 test flash procedure use the supplied programmer to flash the ecu and verify its compatibility. • confirm that y...

  • Page 9

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 8 • use directional pad to highlight return to stock option and press select button. • follow the on screen instru...

  • Page 10

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 9 8. Use a 10mm socket to remove the two bolts retaining the bottom of the fascia. 9. Use a panel puller to remove...

  • Page 11

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 10 18. Push down the white tab on the front evap hose fittings and disconnect them from the manifold and the evap ...

  • Page 12

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 11 26. Use an 8mm socket to remove the manifold bolt on the driver side retaining the fuel rail bracket. 27. Use a...

  • Page 13

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 12 34. Use a clean shop rag to wipe down the intake flange of both cylinder heads then put a small strip of maskin...

  • Page 14

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 13 46. Install the new valley plate on the engine carefully so as not to dislodge the o-rings and line up the bolt...

  • Page 15

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 14 54. Apply blue loctite to the threads of the m8 x 20mm bolt supplied in bag #1 then use a 12mm socket and washe...

  • Page 16

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 15 62. Use a 12mm socket and an m8 x 20mm bolt supplied in bag #1 to secure the ground strap to the back side of t...

  • Page 17

    76. Loosen the bolt holding the drill guide and rotate it until the second hole lines up with the hole drilled in the crank. Use the back side of the ream tool to verify the guide is correctly aligned. 77. Tighten the guide bolt then use compressed air to clean out any metal flakes in the drill hole...

  • Page 18

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 17 92. Install the m8 nuts and m8 x 20mm bolts supplied in bag #2 into the holes in the lower heat exchanger brack...

  • Page 19

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 18 101. Slide the short section of the intercooler hose assembly through the hole and onto the heat exchanger outl...

  • Page 20

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 19 104b. For 2012 model year only use a 10mm wrench to install the standoff, supplied in bag #2, to the stud locat...

  • Page 21

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 20 110. Install the factory o-ring intake seals into the machined grooves of the supercharger flanges. 111. Instal...

  • Page 22

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 21 118. Apply o-ring lube to the seals of each of the fuel rail fittings. Use a 13/16” wrench to install the plug ...

  • Page 23

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 22 127. Install the supplied rubber grommets into the supplied coil cover brackets. 128. Use a 10mm socket to remo...

  • Page 24

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 23 140. Connect the etc extension harness to the stock etc electrical connector and route the extension harness so...

  • Page 25

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 24 149. Use a 10mm socket to remove the passenger side fender bolt, install the ground strap ring connector undern...

  • Page 26

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 25 162. Reinstall the front wheels and snug the lug nuts. Lower the vehicle to the ground then torque the lug nuts...

  • Page 27

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 26 179. Lubricate the grommet on the passenger side coil cover then install it by sliding the grommet down and aro...

  • Page 28

    ©2012 edelbrock llc part #1596, 1597, 1598, 1599 brochure #63-1598 rev. A - 2/12 - cp/mc edelbrock e-force supercharger system for the 2010-2012 camaro ss installation instructions page 27 email edelbrock your stock vehicle calibration in the rare occurrence that you encounter an error message that ...