EZ Lite Cruiser Regular Manual
Summary of Regular
Page 1
1 website: www.Ezlitecruiser.Com e ‐ mail: support@ezlitecruiser.Com phone (toll free): 1 ‐ (888) 544 ‐ 6054 deluxe models slim, regular and wide.
Page 2: Thank
2 thank you for purchasing the ez lite cruiser. We sincerely hope that it will bring convenience and enjoyment to your daily life. Please read the instruc ons before using the chair in order to operate and maintain it properly. Ez lite cruiser assumes no responsibility for personal injury or propert...
Page 3: Front
3 front cover ————————————————————————— 1 precau ons ————————————————————————— 2 iden fi ca on of components ————————————————— 4 safe usage guide —————————————————————— ‐ 6 ba ery guide ———————————————————————— 11 charging guide ——————————————————————— ‐ 12 using two ba eries ————————————————————— ‐...
Page 4: Identification
4 identification of components dx12 model s hown for illust rativ e purposes . Yo ur m odel com pone nt s m ay vary sl ig ht ly ..
Page 5: Identification
5 identification of components dx12 model s hown for illust rativ e purposes . Yo ur m odel com pone nt s m ay vary sl ig ht ly ..
Page 6: Before
6 before driving — read this section carefully. The user must be of sound mind and judgment. They must be conscious and have unimpaired motor func ons in their hand to use the controller. The user must read this user’s guide before opera ng the chair and get fa ‐ miliar with its components and featu...
Page 7: Prac Ce
7 prac ce avoiding obstacles lightly push the joys ck in either direc ons to avoid and maneuver around the obstacle/s. Again, prac ce speed control. Driving faster push the joys ck all the way in the direc on you want to go. Pull the joys ck back to the middle/center if you do not feel you are not 1...
Page 8: Driving
8 driving uphill keep your body lted forward to keep the center of gravi ‐ ty stable. Drive slowly and calmly. We recommend the slope be less than 8 degrees for op ‐ mal performance. Driving downhill make sure the electromagne c brake is engaged before driving downhill. We recommend the slope be les...
Page 9: Entering
9 entering & exi ng an elevator the user should pay a en on to the opening and closing intervals of the elevator door to avoid a collision while en ‐ tering or exi ng the elevator. Driving over train or railroad tracks we highly discourage you from ever crossing railroad/ train tracks alone in the e...
Page 10: Seat
10 seat belt we recommend using the seat belt. Self repair of the ez lite cruiser avoid a emp ng to repair the product on your own. It may cause permanent damage to the chair and could put yourself at risk of injury. We strongly recommend that the product should be re ‐ paired by a professional repa...
Page 11: Battery
11 battery guide ba ery handling and care do not leave the ba ery in direct sunlight. It will cause permanent damage, or a vola le reac on. Store the ba ery in a cool, dry area. Do not remove any wrapping, whether it is blue, clear, plas c or otherwise, from the ba ery pack. Do not allow children ac...
Page 12: Charging
12 charging guide general informa on on charging the ba ery please use the lithium ba ery charger supplied by ez lite cruiser and never use a charger from another power chair! Unless instructed by an ez lite cruiser technical support technician, do not turn on the controller power or use the chair d...
Page 13: Charging
13 charging guide charging the ba ery “on board” “on board” charging means the ba ery is connected to the ez lite cruiser’s power input connec on, to supply the chair with power. First, plug the ba ery in to the chair. Next, insert the charger into an electrical outlet, which will cause the charger ...
Page 14: Charging
14 charging guide charging the ba ery “o ff board” “o ff board” charging means the ba ery is not connected to the ez lite cruiser’s power input connec on, and it is not supplying the chair with power. In this scenario, you will fi rst connect the charger into an electrical outlet, which will cause the...
Page 15: Using
15 using two batteries using the dual ba ery connector cable you can connect and use two ba eries at the same me. The power will be drawn from both ba eries. In order to do this, you must have purchased a second ba ery (your chair only comes with one) and a dual ba ery connector. As described on the...
Page 16: Using
16 using in the powered (electric) mode flip the red levers (the electromagne c locks, iden fi ed in the compo ‐ nents of the ez lite cruiser on page 5) on both of the rear wheels and ensure that the wheels are locked in place, and are not moving at all. When the chair is powered electrically, the c...
Page 17: Addi Onal
17 addi onal warnings & precau ons if the ez lite cruiser is not locked in the open posi on, it can collapse when a emp ng to sit on the chair. This can cause damage to the chair and also hurt the user. Please ensure that the chair is fully unfolded before si ng in it. Check, double ‐ check and trip...
Page 18: Transport
18 transport & storage to pick up the chair, stand it up when it is folded. Li the chair by metal frame parts always, never by any cushions, straps or plas c parts. The ba ery should be fully charged and the chair should be placed in cool, dry, and ven lated place in case of the chair will long ‐ te...
Page 19: Quick
19 quick start guide you must read all of the informa on on the previous pages before star ng to use your ez lite cruiser. The previous pages contain ex ‐ tremely important safety informa on, proper usage, care & maintenance of your ez lite cruiser. Failure to read the informa on can lead to prob ‐ ...
Page 20: Quick
20 quick start guide charging two ba eries you can not charge two ba eries at the same me using the dual ba ery connector. For more informa on on charging two ba eries, see page 14. To charge two ba eries, the easiest way is to have two chargers and charge each ba ery o ff board. Or charge one ba ery...
Page 21: Quick
21 quick start guide toolkit the toolkit is supplied is so you can get your chair setup. Simply follow the guide on the next few pages to put the fi nishing touches on your chair. From me to me, ghten certain hinge joints on which the chair folds. This will help make it func on as it was when it was...
Page 22: Quick
22 quick start guide keep it clean & take good care of your ez lite cruiser the key to a long life out of the ez lite cruiser, like anything else, is to keep it clean and take good care of it. Keeping it clean will keep it look ‐ ing like new again,. Taking good care of it will ensure the longest li...
Page 23: Quick
23 quick start guide install the kickstand set screw a er the fi rst me you unfold the chair, and before folding the chair, you must install the kickstand set screw on both sides of the chair. This screw elevates the kickstand away from the frame. If it is not installed, and you go to fold the chair...
Page 24: Quick
24 quick start guide fasten the cover in the front using the provided hex wrench and 2 black screws, fasten the covers on each side to the frame part, in the front. Make sure these are properly fastened, and move on to the next step. Fasten the cover in the back using the provided screw driver, and ...
Page 25: Quick
25 quick start guide insert the an ‐ tipping wheels take the smaller wheels provided and push the small metal bu on closer to the top of it, and insert it into the frame housing along the back of the chair. The metal bu on will pop out of the drilled hole in the frame part, se ‐ curing the an ‐ tipp...
Page 26: Quick
26 quick start guide storing the ba ery the ba ery will be stored in the zip ‐ pered compartment found underneath the seat. Simply unzip the compart ‐ ment & place the ba ery inside there. Tuck the cables inside the bag, and a er connec ng the ba ery (explained below), you can zip up this storage co...
Page 27: Quick
27 quick start guide charging the ba ery on–board the charger that comes with your ez lite cruiser by default only charges the ba ery while it is on ‐ board, connected to the chair. To charge the ba ery, make sure the ba ery is connected un ‐ derneath the seat. Then, plug the round metal p of the ch...
Page 28: Quick
28 quick start guide standing the ez lite cruiser upright the chair comes with kickstands that can be used to stand the chair up ver ‐ cally for easy li ing, when folded. The kickstand may or may not be mounted. If not mounted, install them at the back of chair near the rear wheels. In ‐ struc ons f...
Page 29: Helpful
29 helpful links online we have a number of videos online to help you get started. If there is something you don’t know how to do, please visit the website and browse our frequently asked ques ons page, or contact us , and we will be glad to help. Website: www.Ezlitecruiser.Com e ‐ mail: support@ezl...
Page 30: Joystick
30 func on descrip on of func onality 1 power on bu on pressing this bu on will power on the ez lite cruiser 2 power o ff bu on pressing this bu on will power o ff the ez lite cruiser 3 speed increase bu on pressing this bu on will increase the speed of the chair, and illuminate the speed indicator le...
Page 31: Fault
31 fault indicators aside from indica ng the speed se ng of the ez lite cruiser, the speed indicator leds (number 8 on the fi gure shown on the previous page) acts as an indicator of common faults in the controller system. When these leds fl ash with the following display as indicated below, the mos...
Page 32: Troubleshooting
32 troubleshooting guide a. Problem: the power won't turn on possible reasons: 1. The ba ery is not properly connected. 2. The joys ck is not connected to the cpu. 3. The ba ery power is too low. Possible solutions: 1. Connect or reconnect the ba ery. 2. If previous disconnected, reconnect the joys ...
Page 33: Troubleshooting
33 troubleshooting guide e. Problem: charger light doesn't go on. Possible reasons: 1. The charger is not plugged in to a wall outlet, or wall outlet has no electricity. 2. The charger cable that plugs into outlet is loosely connected to the charger base. Possible solutions: 1. Plug in the charger, ...
Page 34: Specifications
34 parameter deluxe models device weight ~56 — ~62 lbs (without battery) max capacity ~280 — ~330 lbs unfolded dimensions ~37" x ~23.5/26" x ~39" (l x w x h) folded dimensions ~32" x ~26" x ~14" (l x w x h) seat dimensions ~17" x ~15.5/17.5" (l x w) seating height ~21.5" (from ground) turning radius...
Page 35: Service
35 service history date descrip on of service part coverage remarks frame 10 years non ‐ deliberate damage motor 5 years non ‐ deliberate damage ba ery 2 years non ‐ deliberate damage cpu 2 year non ‐ deliberate damage joys ck 2 year non ‐ deliberate damage wearing parts 3 months tires, seat, backre...
Page 36: Website:
36 user manual: revision 3.01 website: www.Ezlitecruiser.Com e ‐ mail: support@ezlitecruiser.Com phone (toll free): 1 ‐ (888) 544 ‐ 6054 the informa on provided in this user manual is copyright © 2015 by ez lite cruiser. Any use of this informa on for any purposes outside of demonstra ng the use of ...