1. DL manuals
  2. Falcon
  3. Cookers
  4. 100
  5. User's Manual & Installation Instructions

Falcon 100 User's Manual & Installation Instructions

Manual is about: Kitchener 100 Dual Fuel

Summary of 100

  • Page 1

    Professional+ 100 dual fuel kitchener 100 dual fuel user guide & installation instructions.

  • Page 2: Raspberry Soufflƒé

    Method 1. For the soufflŽ, press the raspberries through a fine sieve to produce 180 g of purŽe. Put this into a heavy- bottomed pan, add the lemon juice and reduce down to a thick jam, stirring from time to time and being careful not to let it catch and burn. 2. Put 45 g of the sugar in a separate ...

  • Page 3: Contents

    I 1. Before you start... 1 important! 1 installation and maintenance 1 peculiar smells 1 if you smell gas 1 ventilation 1 personal safety 1 cooker care 2 cleaning 2 2. Cooker overview 3 hotplate burners 3 wok burner 4 the wok cradle (optional) 5 the griddle (optional) 5 the grill / glide-out grill (...

  • Page 4

    Ii.

  • Page 5: 1.  Before You Start...

    1 this user guide covers a number of different models. Although some of the illustrations will look different to your particular model the functions will be the same. We hope the meaning is clear. Your cooker should give you many years of trouble-free cooking if installed and operated correctly. It ...

  • Page 6

    2 n n do not use a steam cleaner on your cooker. Always be certain that the controls are in the off position when the oven is not in use, and before attempting to clean the cooker. N n when the oven is on, do not leave the oven door open for longer than necessary, otherwise the control knobs may bec...

  • Page 7: 2.  Cooker Overview

    3 artno.270-0001 proplus control to high 2. Cooker overview the 100 dual fuel cooker (fig.2-1) has the following features: a. 5 hotplate burners including a wok burner b. A control panel incorporting a timer c. A glide-out grill d. Main fan oven e. Tall fan oven hotplate burners the drawing by each ...

  • Page 8

    4 artno.311-0002 pan with rim if, when you let go of the control knob, the burner goes out, then the fsd has not been bypassed. Turn the control knob to the off position and wait for one minute before you try again, this time making sure to hold in the control knob for slightly longer. Adjust the fl...

  • Page 9

    5 artno.090-0002 90 griddle position artno.090-0004 incorrect griddle position artno.311-0006 correct wok sizes the wok cradle (optional) the wok cradle is designed to fit a 35 cm wok. If you use a different wok, make sure that it fits the cradle. Woks vary very widely in size and shape. It is impor...

  • Page 10

    6 the grill / glide-out grill (optional) open the door and, using the handle, pull the grill pan (fig.2-15) or carriage (fig.2-16) forward. The grill has two elements that allow either the whole area of the pan to be heated or just the right-hand half. Adjust the heat to suit by turning the knob. To...

  • Page 11

    7 artno.270-0006 proplus oven control light 140 100 180 220 0 the clock you can use the clock to turn the left-hand oven on and off. The clock must be set to the time of day before the oven will work. The 2-button clock (professional+) setting the time of day the 2-button lcd clock is shown in (fig....

  • Page 12

    8 use the adjusting knob to set the ‘stop time’ required (fig.2-28). The ‘stop time’ is displayed, followed by ‘auto’. Set the oven to the cooking temperature you need. Turn the timer knob to the ‘auto’ setting. When your cooking is finished, the beeper sounds. Turn the timer knob to the vertical [ ...

  • Page 13

    9 the 6-button clock (kitchener) setting the time of day the 6-button lcd clock is shown in fig.2-34. When the clock is first connected the display flashes ( 0.00 ) and ( ) alternately. Press and hold both the [] and [] buttons down (fig.2-35). Now press the [+] button (or the [–] button) until th...

  • Page 14

    10 now press and hold the [] button (fig.2-42) and then press the [+] button (or [–] button) until the required ‘stop time’ shows (fig.2-43). Release the buttons. Auto will now show in the display. Set the oven to the required temperature. When cooking is finished the beeper will sound. Turn the ov...

  • Page 15

    11 accessories oven shelves – left-hand (main) oven in addition to the flat shelves, some models are supplied with a drop shelf (fig.2-49). The drop shelf increases the possibilities for oven shelf spacing. The oven shelves can be easily removed and refitted. Pull the shelf forward until the back of...

  • Page 16: 3.  Cooking Tips

    12 tips on cooking with the timer if you want to cook more than one dish, choose dishes that require approximately the same cooking time. However, dishes can be ‘slowed down’ slightly by using small containers and covering them with aluminium foil, or ‘speeded up’ slightly by cooking smaller quantit...

  • Page 17: 4.  Cooking Table

    13 4. Cooking table artno.050-0007 oven shelf positions oven shelf positions top (t) centre (c) base (b) the oven control settings and cooking times given in the table below are intended to be used as a guide only. Individual tastes may require the temperature to be altered to provide a preferred re...

  • Page 18: 5.  Cleaning Your Cooker

    14 artno.311-0032 burner layout fsd a b c d e artno.311-0033 wok burner details fsd a b c d e artno.311-0016 fitting the burner inner head a b fig.5-1 fig.5-2 fig.5-3 fig.5-4 a – cap, b – head, c – notch, d – base , e – electrode a – inner burner cap, b – outer burner cap, c – inner burner head, d –...

  • Page 19

    15 artno.331-0001grill pan pulled forwards artno.331-0003 grill frame out, no pan artno.331-0004 removing the grill frame artno.331-0005 removing the grill rail artno.331-0006 grill pan plan fig.5-5 fig.5-6 fig.5-7 fig.5-8 fig.5-9 grills the grill pan and trivet should be washed in hot soapy water. ...

  • Page 20

    16 artno.320-0022 tall oven side support glass fronted door panels the oven door front panels can be taken off so that the glass panels can be cleaned. Move the cooker forward to gain access to the sides (see the ‘moving the cooker’ section under ‘installation’). Open the oven door slightly and remo...

  • Page 21

    17 cleaning table cleaners listed (table 5-1) are available from supermarkets or electrical retailers as stated. For enamelled surfaces use a cleaner that is approved for use on vitreous enamel. Regular cleaning is recommended. For easier cleaning, wipe up any spillages immediately. Hotplate part fi...

  • Page 22: 6.  Troubleshooting

    18 hotplate ignition or hotplate burners faulty is the power on? Is the clock illuminated? If not, there maybe something wrong with the power supply. Are the sparker (ignition electrode) or burner slots blocked by debris? Are the burner trim and caps correctly located? See the section on ‘cleaning’?...

  • Page 23

    19 oven temperature getting hotter as the cooker gets older if turning the temperature down using the oven control knob has not worked, or has only worked for a short time, then you may need a new thermostat. This should be fitted by a service person. An oven light is not working the bulb has probab...

  • Page 24: 7.  Installation

    Installation check the appliance is electrically safe and gas sound when you have finished. 20 dear installer before you start your installation, please complete the details below, so that, if your customer has a problem relating to your installation, they will be able to contact you easily. Safety ...

  • Page 25

    Installation check the appliance is electrically safe and gas sound when you have finished. 21 checking the parts: you will need the following equipment to complete the cooker installation satisfactorily: • stability bracket: if the cooker is to be supplied with gas through a flexible hose, a stabil...

  • Page 26

    Installation check the appliance is electrically safe and gas sound when you have finished. 22 artno.105-0008 - 100df 2bc cooker min spacings professional + 905 mm min 930 mm max 75 mm min 75 mm min 650 mm min 130 mm min fig.7-3 positioning the cooker fig.7-1 and fig.7-2 shows the minimum recommende...

  • Page 27

    Installation check the appliance is electrically safe and gas sound when you have finished. 23 stability chain artno.070-0014 - stability bracket - wall fitting cooker stability bracket floor 3 mm min typical floor mounting cooker outer stability bracket floor wall 3 mm min typical wall mounting art...

  • Page 28

    Installation check the appliance is electrically safe and gas sound when you have finished. 24 conversion to another gas if the appliance is to be converted to another gas do the conversion at this point. See the conversion section of these instructions. Levelling you are recommended to use a spirit...

  • Page 29

    Installation check the appliance is electrically safe and gas sound when you have finished. 25 pressure testing the gas pressure can be measured at one of the hotplate burner injectors (not the wok burner). Lift off a burner head. Fit the pressure gauge to the injector. Turn on and light one of the ...

  • Page 30

    Installation check the appliance is electrically safe and gas sound when you have finished. 26 artno.350-0012 - securing the plinth fig.7-13 final checks hotplate check check each burner in turn (refer to the ‘hotplate burners’ section at the front of the instructions). Grill check turn on the grill...

  • Page 31: 8.  Conversion to Lp Gas

    Warning – servicing to be carried out only by an authorised person disconnect from electricity and gas before servicing. Check appliance is safe when you have finished. 27 a b c artno.311-0010 injectors fig.8-1 a – jet, b – internal injector, c – external injector artno.270-0032 - 90 prof+ fx - remo...

  • Page 32

    Warning – servicing to be carried out only by an authorised person disconnect from electricity and gas before servicing. Check appliance is safe when you have finished. 28 pressure testing connect the appliance to the gas supply. Connect the appliance to the gas supply. Check the appliance is gas so...

  • Page 33: 9.  Circuit Diagram

    29 9. Circuit diagram a b e f c d 1 2 p095199 1 2 p2 p1 e 1 2 1 2 p095199 1 2 p2 p1 b b b or or bk v v bk bk r r r br br r y y y w w w b b y br br br b b b b y y y or or w w b bk bk br br br br y y y y b b gy b b b b b br br br gy br br a1 a2 b1 c d1 d2 d3 d4 f1 f2 g1 h i b2 b3 b4 g2 h h i a3 j key ...

  • Page 34: 10.  Technical Data

    30 10. Technical data the cooker is category: cat ii2h3+; cat ii2e+3+; cat ii2l3b/p; cat ii2e3b/p; cat ii2ell3b/p; cat ii2h3b/p; cat ii2ell3b/p. This appliance is supplied set for group h natural gas (g20 natural gas at 20 millibar). A conversion kit from ng to lp is available for the cooker. Instal...

  • Page 35

    Consumer service if you have any product enquiries, or in the event of a problem with your appliance once it has been installed, please telephone 0870 789 5107. Consumer service lines open: monday to thursday 8amÐ6pm friday 8amÐ5pm saturday 9amÐ1pm warranty your manufacturer warranty covers goods of...

  • Page 36

    Falcon appliances clarence street royal leamington spa warwickshire cv31 2ad tel 0870 755 6490 fax 0192 631 1032 email consumers@falconappliances.Co.Uk www.Falconappliances.Co.Uk trade enquiries 0115 946 6143 email sales@falconappliances.Co.Uk registered in england and wales. Registration no. 354715...