1. DL manuals
  2. FPI
  3. Indoor Fireplace
  4. Dell-Point GF45
  5. Owners & Installation Manual

FPI Dell-Point GF45 Owners & Installation Manual

Summary of Dell-Point GF45

  • Page 1

    Fpi fireplace products international, ltd. 6988 venture st., delta, bc, canada v4g 1h4 918-625 11/29/06 important: save these instructions. Owners & installation manual warning: please read this entire manual before installation and use of this pellet fuel-burning room heater. Failure to follow thes...

  • Page 2

    Greenfi re gf45 bioenergy stove 2 gf45 to the new owner congratulations! You are the owner of a state-of-the-art stove by fpi. Thank-you for purchasing a fpi fireplace product. The pride of workmanship that goes into each of our products will give you years of trouble-free enjoyment. Should you have ...

  • Page 3: Table of Contents

    Greenfi re gf45 bioenergy stove 3 table of contents safety label safety label ..................................................................4 installation important: save these instructions ................................5 before you start ...........................................................

  • Page 4: Safety Label

    Greenfi re gf45 bioenergy stove 4 safety label this is a copy of the label that accompanies each gf45. We have printed a copy of the contents here for your review. The safety label is located on the back panel of the stove. Note: fpi units are constantly being improved. Check the label on the unit an...

  • Page 5: Installation

    Greenfi re gf45 bioenergy stove 5 inst alla tion important: save these instructions the gf45 stove must be installed in accordance with these instructions. Carefully read all the instructions in this manual fi rst. Consult the building authority having jurisdiction to determine the need for a permit p...

  • Page 6: Installation

    Greenfi re gf45 bioenergy stove 6 inst alla tion chimney installation important: always use an approved 3” (76mm) pl type vent system which is approved for venting while burning corn. Using a different size vent will result in poor performance or eventual malfunction of your appliance which is not co...

  • Page 7: Installation

    Greenfi re gf45 bioenergy stove 7 inst alla tion installation unit dimensions clearances alcove ceiling height is 60" (324mm) (measured from bottom of the unit.) floor protector of 0.84k factor minimum is required beneath the hearth. (please check with local authorities and regulations.).

  • Page 8: Installation

    Greenfi re gf45 bioenergy stove 8 inst alla tion installation vent termination requirements 1. Do not terminate the vent in any enclosed or semi-enclosed areas that can build up a concentration of fumes. 2. Vent surfaces can become extremely hot. Keep children away from such areas. Non-combustible sh...

  • Page 9: Installation

    Greenfi re gf45 bioenergy stove 9 inst alla tion installation horizontal termination top view side view.

  • Page 10: Installation

    Greenfi re gf45 bioenergy stove 10 inst alla tion outside vertical termination installation side view.

  • Page 11: Installation

    Greenfi re gf45 bioenergy stove 11 inst alla tion installation vertical termination top view side view diagram 6.

  • Page 12: Installation

    Greenfi re gf45 bioenergy stove 12 inst alla tion existing class "a" chimney installation diagram 7.

  • Page 13: Installation

    Greenfi re gf45 bioenergy stove 13 inst alla tion installation existing masonry chimney diagram 8.

  • Page 14: Installation

    Greenfi re gf45 bioenergy stove 14 inst alla tion installation optional 12 volt battery installation this battery back-up will ensure uninterupted operation of your stove in the event of unexpected loss of electrical power. Note that this does not replace the regular 120 volt power supply to the stov...

  • Page 15: Operating Instructions

    Greenfi re gf45 bioenergy stove 15 opera tion operating instructions control panel functions prime stove this button is used only to prime the auger when the hopper is empty. Select fuel this button is used to select the appropriate fuel type that is going to be burned. Heat level settings select the...

  • Page 16: Operating Instructions

    Greenfi re gf45 bioenergy stove 16 opera tion operating instructions priming stove: empty hopper 1) open the hopper lid and fi ll with desired fuel to be burned. Note: the hopper can hold up to a 45 pound bag of fuel. 2) close hopper lid. 3) open the front door and place the measuring cup in the cente...

  • Page 17: Operating Instructions

    Greenfi re gf45 bioenergy stove 17 opera tion operating instructions burning corn or wheat: primed hopper note: if the hopper is empty, follow steps 1 to 8 to prime stove. 1) open the control panel cover, if the greenkey has not yet been inserted gently push the key into the keyhole on the control pa...

  • Page 18: Maintenance

    Greenfi re gf45 bioenergy stove 18 maintenance maintenance maintenance maintenance schedule using wood pellets maintenance schedule using corn or wheat components of stove each start up every 2-3 days weekly monthly annually r emove ash from within b urn - pot x c heck the ash removal system x e mpty...

  • Page 19: Maintenance

    Greenfi re gf45 bioenergy stove 19 maintenance before each start-up, always check the level of ashes in the ash pan and remove if necessary. “be sure to dispose of in a metal container and remove to outside of the building.” embers can stay hot for a long time after the fi re has been extinguished. To...

  • Page 20: Maintenance

    Greenfi re gf45 bioenergy stove 20 maintenance diagram 17 diagram 18 top ring maintenance of the burn-pot step 1: use a 9/16 wrench to unscrew the two nuts (diagram 17). Then to raise the ring, it may be necessary to insert a fl at screwdriver between the outside of the burn-pot and the top ring (diag...

  • Page 21: Maintenance

    Greenfi re gf45 bioenergy stove 21 maintenance maintenance on the combustion fan (connected to the chimney) diagram 21 diagram 22 to clean the fl ywheel, use a steel brush shown on diagram 22. Clean each wing of the fl ywheel, which will increase the pressure on the calibration indicator and will reduc...

  • Page 22: Maintenance

    Greenfi re gf45 bioenergy stove 22 maintenance maintenance minimum burning capacity 7,096 btu/h (when burning wood pellets) 1 lb/h maximum burning capacity 28,387 btu/h (when burning wood pellets) 4 lb/h combustion fan power varies from 25 cfm to 45 cfm convection fan power varies from 35 cfm to 125 ...

  • Page 23: Troubleshooting

    Greenfi re gf45 bioenergy stove 23 tr oubleshoo ting troubleshooting troubleshooting error code problem solution system cooling temp overshoot the thermodisc temperature has exceeded 250f. 1st time; hardware takes over and the unit goes into shutdown mode. 2nd time; when the unit is restarted, hardwa...

  • Page 24: Troubleshooting

    Greenfi re gf45 bioenergy stove 24 tr oubleshoo ting troubleshooting electrical diagram (12 volts) high temperature thermodisk 250f (installed on the wall) auger feed motor vacuum switch ash extraction motor combustion fan a power supply converts the ac power to 12 volts dc thermodisk 110-20f white w...

  • Page 25: Notes

    Greenfi re gf45 bioenergy stove 25 ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ______...

  • Page 26: Notes

    Greenfi re gf45 bioenergy stove 26 notes ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ___________________________________________________ ...

  • Page 27: Warranty

    Greenfi re gf45 bioenergy stove 27 warranty gf45 manufacturers warranty fpi offers a limited lifetime warranty, consisting of fi ve years parts and *subsidized labor and parts only thereafter against manufacturers defects on the steel structure of the appliance and the burn pot. Fpi offers two years p...

  • Page 28

    Printed in canada © copyright 2006, fpi fireplace products international ltd. All rights reserved..