Gardena 5500/5 inox Operating Instructions Manual - page 4
For Art. 1499 only:
Bleeding:
Before putting the pump into operation or switching it on,
please note: When first put into operation, the pump takes
about 60 seconds to vent after submersion in the water.
v
Put the pump into operation only after this 60-second
submersion phase.
Once the pump has been put into operation, the end of the bleed ing
operation is indicated by a jet of water exiting the bleed openings.
For Art. 1499 only:
Automatic mode:
The pump pumps and switches off automatically as soon as
no more water is drawn. Due to the check valve, the pressure is
maintained in the hose until water is drawn via the hose.
When water is drawn via the hose (the pressure in the hose falls
below 3.5 bar), the pump switches on automatically.
For Art. 1499 only:
Dry run protection
(flow control):
The pump switches off automatically when there is no fluid
pumped (the pump operates in cycles 30 secs. on – 5 secs. off
(4x). This cycle is repeated in 1 hr, 5 hrs, 24 hrs, 24 hrs ... ).
As soon as the inlet filter of the pump is again submersed at least
15cm in the water, the pump is ready to operate again.
For Art. 1499 only:
Flow control:
The flow control switches off automatically as soon as no more
water is drawn. In the event of leakage on the pressure side
(e. g. leaking pressure hose or tap) switches the pump on and off at
short intervals. If the pump is switched on and off more frequently
than 7 x in 2 min. (with a leakage < 200 l/hr), the pump switches off
completely. When the leakage on the pressure side is eliminated,
the pump must be unplugged and plugged in again in order to be
operational again.
For Art. 1499 only:
Non-return valve:
The built-in non-return valve prevents the water flowing back
through the pump.
5. Putting into Storage
Storage:
The storage location must not be accessible to children.
v
Store the pump away from frost before the first frost sets in.
Disposal:
(in accordance with
RL2002/96/EC)
The product must not be added to normal household waste.
It must be disposed of in line with local environmental regulations.
6. Maintenance
Clean priming area:
0
!
DANGER! Electric shock!
There is a risk of injury from electric
shocks.
V
Disconnect the Deep Well Pump from the mains
power supply before carrying out maintenance.
1. Unscrew both screws
0
and remove the inlet filter
q
.
2. Clean priming area of the pump and inlet filter
q
.
3. Fix inlet filter
q
around the priming area again and screw tight
with the two screws
0
.
7. Trouble-Shooting
DANGER! Electric shock!
There is a risk of injury from electric
shocks.
V
Before eliminating faults, disconnect the Deep
Well Pump from the mains power supply.
Fault
Possible cause
Remedy
Pump is running,
but doesn’t deliver.
Air cannot escape as the
pressure line is closed.
v
Open pressure line
(e. g. bent pressure hose).
Priming area blocked.
v
Disconnect mains plug
and clean priming area
(see 6. Maintenance).
When starting the pump,
water height falls below the
min. water level.
v
Immerse pump deeper
(observe minimum water
level: see 9. Technical Data).
Non-return valve blocked.
v
Art. 1499:
Contact GARDENA Service.
Pump doesn’t start or
suddenly stops during
operation.
Thermal protection switch
switched pump off due to
overheating.
v
Disconnect mains plug
and clean priming area
(see 6. Maintenance).
Observe max. media
temperature (35 °C).
Power supply interrupted.
v
Check fuses and electrical
plug-in connections.
Dirt particles are trapped in
priming area.
v
Disconnect mains plug
and clean priming area
(see 6. Maintenance).
Pump runs, but output
suddenly decreases.
Priming area blocked.
v
Disconnect mains plug
and clean priming area
(see 6. Maintenance).
For Art. 1499 only: Lack of
water: Dry run protection
switched the pump off due to
insufficient water level.
The pump is only operational
when it is submerged at least
15 cm.
v
Submerge pump at least
15 cm in water.
For any other malfunctions please contact the GARDENA service department.
Repairs must only be carried out by GARDENA service departments or specialist
dealers authorised by GARDENA.
12
GB
13
GB