Garmin 011-01257-00 Installation Manual

Summary of 011-01257-00

  • Page 1

    190-00303-21 january, 2010 revision c (gma 1347d -00 shown) gma 1347d installation manual.

  • Page 2

    Page a gma 1347d installation manual revision c 190-00303-21 © copyright 2005 - 2010 garmin ltd. Or its subsidiaries all rights reserved except as expressly provided herein, no part of this manual may be reproduced, copied, transmitted, disseminated, downloaded or stored in any storage medium, for a...

  • Page 3

    Gma 1347d installation manual page i 190-00303-21 revision c current revision description revision page number(s) section number description of change 1-1 1.2 added “dme, adf, mkr, tel, aux” to equipment description 1-2 1.2.2 added to interface summary 1-7 1.6 updated warranty statement 2-1 2.1 & 2....

  • Page 4

    Page ii gma 1347d installation manual revision c 190-00303-21 this manual reflects the operation of software version 4.00. Some differences in operation may be observed when comparing the information in this manual to earlier or later software versions. Information subject to export control laws thi...

  • Page 5

    Gma 1347d installation manual page iii 190-00303-21 revision c table of contents paragraph page 1 general description..............................................................................................................1-1 1.1 introduction........................................................

  • Page 6

    Page iv gma 1347d installation manual revision c 190-00303-21 paragraph page appendix a assembly and installation drawings...................................................... A-1 appendix b interconnect drawings .................................................................................... B...

  • Page 7

    Gma 1347d installation manual page v 190-00303-21 revision c list of tables table page 2-1 pin and crimp tool part numbers.....................................................................................................2-3 3-1 pin contact part numbers................................................

  • Page 8

    Page vi gma 1347d installation manual revision c 190-00303-21 gma 1347d hardware mod level history the following table identifies hardware modification (mod) levels for the gma 1347d audio panel. Mod levels are listed with the associated service bulletin number, service bulletin date, and the purpos...

  • Page 9

    Gma 1347d installation manual page 1-1 190-00303-21 revision c 1 general description 1.1 introduction this manual presents mechanical and electrical installation requirements for installing the garmin gma 1347d audio panel, as part of the garmin integrated flight deck. The gma 1347d can be incorpora...

  • Page 10

    Page 1-2 gma 1347d installation manual revision c 190-00303-21 1.2.1 features summary • logical front panel layout • led annunciators indicate selected function • five position intercom: pilot and four passengers • two stereo headset amplifiers: one for the pilot and one for the passengers • two ste...

  • Page 11

    Gma 1347d installation manual page 1-3 190-00303-21 revision c 1.3 technical specifications it is the responsibility of the installing agency to obtain the latest revision of the gma 1347d environmental qualification form. This form is available directly from garmin under the following part number: ...

  • Page 12

    Page 1-4 gma 1347d installation manual revision c 190-00303-21 1.3.2 electrical characteristics characteristic specification regulatory compliance rtca/do-160d environmental conditions and eurocae/ed-14d unit software rtca/do-178b level c cld (custom logic devices) compliance rtca/do-254 level c tem...

  • Page 13

    Gma 1347d installation manual page 1-5 190-00303-21 revision c 1.4 certification the conditions and tests required for tso approval of this article are minimum performance standards. It is the responsibility of those installing this article either on or within a specific type or class of aircraft to...

  • Page 14

    Page 1-6 gma 1347d installation manual revision c 190-00303-21 1.5 reference documents the following publications are sources of additional information for installing the gma 1347d. Before installing the unit, the technician should read all referenced materials along with this manual. Part number do...

  • Page 15

    Gma 1347d installation manual page 1-7 190-00303-21 revision c 1.6 limited warranty all garmin avionics products are warranted to be free from defects in materials or workmanship for: two years from the date of purchase for new remote-mount and panel-mount products; one year from the date of purchas...

  • Page 16

    Page 1-8 gma 1347d installation manual revision c 190-00303-21 this page intentionally left blank.

  • Page 17

    Gma 1347d installation manual page 2-1 190-00303-21 revision c 2 installation overview 2.1 introduction this section provides hardware equipment information for installing the gma 1347d audio panel, related hardware and suggestions relating to the marker beacon antenna. Installation of the gma 1347d...

  • Page 18

    Page 2-2 gma 1347d installation manual revision c 190-00303-21 2.3 installation considerations the gma 1347d interfaces with the g1000 system, and with various avionics equipment. Fabrication of a wiring harness is required. Sound mechanical and electrical methods and practices are required for inst...

  • Page 19

    Gma 1347d installation manual page 2-3 190-00303-21 revision c 2.3.1.4 marker beacon antenna cable installation this section provides guidance for terminating the coaxial cable into the d-sub connector. See the system interconnect section for pin assignments. Note use coaxial cable meeting the appli...

  • Page 20

    Page 2-4 gma 1347d installation manual revision c 190-00303-21 2.4 cabling & wiring use awg #24 or larger wire for all connections unless otherwise specified by the aircraft manufacturer or garmin. The standard pin contacts supplied in the connector kit are compatible with up to awg #22 wire. In cas...

  • Page 21

    Gma 1347d installation manual page 2-5 190-00303-21 revision c 2.6 mounting requirements the gma 1347d mounting surface must be capable of providing structural support and electrical bond to the aircraft to minimize radiated emi and provide protection from high-intensity radiation fields (hirf). The...

  • Page 22

    Page 2-6 gma 1347d installation manual revision c 190-00303-21 2.7 installation approval considerations for pressurized aircraft antenna and cable installations on pressurized cabin aircraft require faa approved installation design and engineering substantiation data whenever such installations inco...

  • Page 23

    Gma 1347d installation manual page 3-1 190-00303-21 revision c 3 installation procedure 3.1 unpacking unit carefully unpack the equipment and make a visual inspection of the unit for evidence of damage incurred during shipment. If the unit is damaged, notify the carrier and file a claim. To justify ...

  • Page 24

    Page 3-2 gma 1347d installation manual revision c 190-00303-21 table 3-2. Recommended crimp tools 18-20 awg 22-28 awg manufacturer hand crimping tool positioner insertion/ extraction tool (note 2) positioner insertion/ extraction tool military p/n m22520/2-01 n/a m81969/1-04 m22520/2-09 m81969/1-04 ...

  • Page 25

    Gma 1347d installation manual page 3-3 190-00303-21 revision c 3.6 gma 1347d unit installation caution do not use excessive force when inserting the gma 1347d into the rack. This may damage the connectors, unit, and/or unit rack. If heavy resistance is felt during installation, stop! Remove the gma ...

  • Page 26

    Page 3-4 gma 1347d installation manual revision c 190-00303-21 this page intentionally left blank.

  • Page 27

    Gma 1347d installation manual page 4-1 190-00303-21 revision c 4 system interconnects 4.1 connector description the gma 1347d has two 78-pin connectors located at the rear of the unit designated j3471 and j3472. J3471 and j3472 are clearly marked on the back of the rack. J3471 and j3472 pins are con...

  • Page 28

    Page 4-2 gma 1347d installation manual revision c 190-00303-21 table 4-1. J3471 pin assignments pin pin name i/o 1 fail safe warn audio in (-00) fail safe pilot summed audio out hi (-20) in out 2 oxygen mask mic select* in 3 tel ringer audio in hi in 4 tel ringer audio in lo in 5 remote pass ics out...

  • Page 29

    Gma 1347d installation manual page 4-3 190-00303-21 revision c table 4-1. J3471 pin assignments (continued) pin pin name i/o 38 unswitched audio in 3 hi in 39 unswitched audio in lo in 40 remote pass ics audio in hi in 41 remote pass ics audio in lo in 42 tel audio in hi in 43 tel audio in lo in 44 ...

  • Page 30

    Page 4-4 gma 1347d installation manual revision c 190-00303-21 table 4-2. J3472 pin assignments pin pin name i/o 1 reserved -- 2 reserved -- 3 program ground -- 4 reserved -- 5 program ground -- 6 rs-232 out 1 out 7 rs-232 in 1 in 8 on-side com mic digital audio out out 9 on-side com digital audio i...

  • Page 31

    Gma 1347d installation manual page 4-5 190-00303-21 revision c table 4-2. J3472 pin assignments (continued) pin pin name i/o 38 rs-232 out 2 out 39 rs-232 in 2 in 40 reserved -- 41 speaker audio out lo out 42 speaker audio out hi out 43 reserved -- 44 program ground -- 45 reserved -- 46 program grou...

  • Page 32

    Page 4-6 gma 1347d installation manual revision c 190-00303-21 4.3 j3472 connector pin assignments this section covers the pin connections of j3472 only. 4.3.1 aircraft power and lighting power input requirements and lighting bus inputs are listed in the following tables. The power-input pins accept...

  • Page 33

    Gma 1347d installation manual page 4-7 190-00303-21 revision c 4.3.3 rs-232 serial input/output table 4-5. Rs-232 pin assignments, j3472 pin pin name description i/o 6 rs-232 out 1 output level greater than ±5 volts out 7 rs-232 in 1 input level up to ±25 volts in 38 rs-232 out 2 output level greate...

  • Page 34

    Page 4-8 gma 1347d installation manual revision c 190-00303-21 4.3.6 speaker the speaker output is capable of driving up to 10 watts into a 4 Ω or 8 Ω speaker. Table 4-8. Speaker pin assignments, j3472 pin pin name description i/o 41 speaker audio out lo ground reference for speaker audio -- 42 spea...

  • Page 35

    Gma 1347d installation manual page 4-9 190-00303-21 revision c 4.4 j3471 connector pin assignments this section covers the pin connections of j3471 only. 4.4.1 mic audio inputs and mic keys table 4-11. Mic audio inputs and mic key pin assignments, j3471 pin pin name description i/o 29 pilot mic key*...

  • Page 36

    Page 4-10 gma 1347d installation manual revision c 190-00303-21 4.4.3 com audio and mic keys table 4-13. Com audio and mic keys pin assignments, j3471 pin pin name description i/o 27 on-side com mic key* out 33 cross-side com mic key* out 78 com 3 mic key* enables audio into the respective transceiv...

  • Page 37

    Gma 1347d installation manual page 4-11 190-00303-21 revision c 4.4.5 headset outputs table 4-15. Headset outputs pin assignments, j3471 pin pin name description i/o 9 pilot headset audio out left out 10 pilot headset audio out right pilot headset audio output out 11 pilot headset audio out lo groun...

  • Page 38

    Page 4-12 gma 1347d installation manual revision c 190-00303-21 4.4.9 aux, dme and adf audio table 4-19. Aux, dme and adf audio pin assignments, j3471 pin pin name description i/o 74 aux audio in hi extra switched audio input in 75 aux audio in lo ground reference for extra switched audio input in 1...

  • Page 39

    Appendix a assembly and installation drawings gma 1347d installation manual page a-1 (page a-2 blank) 190-00303-21 revision c figure a-1. Gma 1347d outline drawing.

  • Page 40

    Appendix a assembly and installation drawings gma 1347d installation manual page a-3 (page a-4 blank) 190-00303-21 revision c figure a-2. Gma 1347d connector/rack assembly drawing.

  • Page 41

    Appendix a assembly and installation drawings gma 1347d installation manual page a-5 (page a-6 blank) 190-00303-21 revision c r.063 max. 1.59 4x .130 3.30 100° .230 4x .683 17.34 .028 0.70 0 0.00 .450 11.43 3.073 78.04 2x 3.398 86.30 4.533 115.13 .300 7.62 3.073 78.04 2x 3.403 86.42 r.200 5.08 4x 0 ...

  • Page 42

    Appendix b interconnect drawings gma 1347d installation manual page b-1 (page b-2 blank) 190-00303-21 revision c figure b-1. Gma 1347d power, antenna and reversionary mode interconnect wiring diagram.

  • Page 43

    Appendix b interconnect drawings gma 1347d installation manual page b-3 (page b-4 blank) 190-00303-21 revision c figure b-2. Gma 1347d power, antenna and reversionary mode interconnect wiring diagram.

  • Page 44

    Appendix b interconnect drawings gma 1347d installation manual page b-5 (page b-6 blank) 190-00303-21 revision c figure b-3. Mic and phone jack connections, interconnect wiring diagram.

  • Page 45

    Appendix b interconnect drawings gma 1347d installation manual page b-7 (page b-8 blank) 190-00303-21 revision c figure b-4. Transceiver analog connections, interconnect wiring diagram.

  • Page 46

    Appendix b interconnect drawings gma 1347d installation manual page b-9 (page b-10 blank) 190-00303-21 revision c figure b-5. Transceiver digital connections, interconnect wiring diagram.

  • Page 47

    Appendix b interconnect drawings gma 1347d installation manual page b-11 (page b-12 blank) 190-00303-21 revision c figure b-6. Discrete lines, interconnect wiring diagram.