- DL manuals
- Holman
- Toaster
- DT14 SERIES
- Installation And Operation Instructions Manual
Holman DT14 SERIES Installation And Operation Instructions Manual
Summary of DT14 SERIES
Page 1
1 ® double conveyor toaster model dt14 series installation and operation instructions 2m-hg0194 rev. D 8/6/07 dt14.
Page 2
2 2 these symbols are intended to alert the user to the presence of important operating and maintenance instructions in the manual accompanying the appliance. Retain this manual for future reference notice using any part other than genuine star factory supplied parts relieves the manufacturer of all...
Page 3
3 specifications: 9h-dt14 type: double conveyor toaster 208v, 4,800 watts, 60 hz, 23.6 amp, nema 6-30p 220v, 4,800 watts, 60 hz, 22.3 amp, nema 6-30p 240v, 4,800 watts, 60 hz, 20.5 amp, nema 6-30p 220v, 4,800 watts, 50 hz, 22.3 amp, not supplied with cord or plug 240v, 4,800 watts, 50 hz, 20.5 amp, ...
Page 4
4 inspection & assembly uncrating and inspecting unpack the unit and components from the shipping container. Remove all visible packing material and those from inside the cooking chamber. If damage is discovered, fi le a claim immediately with the carrier that handled the shipment. Do not operate th...
Page 5
5 caution allow enough space around the toaster for adequate ventilation. Do not operate the unit without the crumb tray properly positioned. Overheating and poor toasting may occur. Read all labels on the unit and follow their instructions. Electrical connection warning before making any electrical...
Page 6
6 warning be sure the ground connection for the receptacle is properly wired. Never connect unit to power without proper ground connections. Improper ground may result in severe injury or fatality. Daily operation check the power cord to insure that it is plugged into a proper outlet. Set the heat c...
Page 7
7 caution certain surfaces are extremely hot during operation and care should be taken while using this unit. Cooking procedures a. Bread toasting 1) turn the top and bottom heat controls to full power. 2) set the conveyor speed to high. 3) if your toaster is equipped with separate top and bottom he...
Page 8
8 cleaning preventive maintenance for your holman toaster consists of the following recommended cleaning procedures. To keep your toaster in its top operating condition, these steps should be performed on a daily or weekly as indicated. A. Clean air intake on the front of the unit using a damp cloth...
Page 9
9 maintenance procedures a. Replacing heater tubes 1) disconnect unit from power source. 2) remove the side panels. 3) remove heater tube wire from terminal block connection, keeping top and bottom wires separate. 4) lift heater tube retainers by loosening retaining screws and sliding the retainer p...
Page 10
10 troubleshooting guide a. Unit will not heat, conveyor belt will not turn. 1) be sure the main circuit breaker is switched to the on position. 2) check to see if the toaster is plugged in and all controls are turned to the on position. 3) if this does not resolve the problem, call the star service...
Page 11
11 part# 2m-4497-2 05/06 rb the foregoing warranty is in lieu of any and all other warranties expressed or implied and constitutes the entire warranty. For assistance should you need any assistance regarding the operation or maintenance of any star equipment; write, phone, fax or email our service d...
Page 12
12 contactor/relay on/off toggle reset main power terminal block fan motor fuse block blue blue blue red yellow orange orange black red black orange purple black white yellow black black black yellow orange red pilot h1 l1 l2 h2 pilot h1 l1 l2 h2 upper top upper bottom pilot h1 l1 l2 h2 pilot h1 l1 ...
Page 13
13 contactor/relay on/off toggle reset fan motor fuse block blue blue blue red yellow orange orange black red orange purple red yellow black black yellow orange red pilot h1 l1 l2 h2 pilot h1 l1 l2 h2 upper top upper bottom pilot h1 l1 l2 h2 pilot h1 l1 l2 h2 lower deck top heat lower deck bottom he...
Page 14
14 this drawing contains information confidential to star manufacturing international, inc. No reproduction or disclosure of its certain instances may not be available illustrative purposes only and in some items are included for contents is permitted. Star manufacturing international, inc. Sk2136 r...
Page 15: Parts List
15 parts list august 6, 2007, rev. D dt14 double conveyor toasters important: when ordering, specify voltage or type gas desired page include model and serial number of some items are included for illustrative purposes only and in certain instances may not be available. Number per unit description &...
Page 16: Parts List
16 47 hm-120034 1 chassis, dt14 48 2c-1487 2 screw 6-32x1/4 rhp st. Fuseholder 49 2c-h8669 2 washer #6 int stl np 50 2c-2553 2 nut 6-32 hex stl np 51 2a-202902 2 fuse, 5a - class g 52 2e-z5681 1 fuseholder, class g ni 2e-200757 1 label, on/off ni 2e-200468 2 clamp, nylon wire 7/8 ni 2k-200465 1 bush...