- DL manuals
- Holman
- Toaster
- Q3-95ARB
- Installation And Operation Instructions Manual
Holman Q3-95ARB Installation And Operation Instructions Manual
Summary of Q3-95ARB
Page 1
1 ® conveyor toaster model q3-95arb installation and operation instructions 2m-z10141 rev. C 6/9/2007 9h-q3-95arb.
Page 2
2 2 these symbols are intended to alert the user to the presence of important operating and maintenance instructions in the manual accompanying the appliance. Retain this manual for future reference notice using any part other than genuine star factory supplied parts relieves the manufacturer of all...
Page 3
3 specifications q3-95arb-v02 rating/connection: 4200 watts (700w elements), 20.5 amps at 208v nema 6-30p plus with six foot oil-resistant cord electrical supply: 208vac, single phase approximate weight: installed - 60 lbs (27.22 kg) shipping - 68 lbs (30.84 kg) dimensions: width: 18.5" (47.0 cm) de...
Page 4: General Information
4 general information this equipment is designed and sold for commercial use only by personnel trained and experienced in its operation and is not sold for consumer use in and around the home nor for use directly by the general public in food service locations. Before using your new equipment, read ...
Page 5
5 assembly and installation the unit was shipped fully assembled and ready to plug into a standard outlet specifi ed for its voltage and amp draw. If improper electrical supply is determined, contact a qualifi ed electrician prior to using the unit. Removal and replacement of the power cord and plug...
Page 6
6 toasting procedures this toaster is equipped with a swinging heat shutter at the toaster entrance. This shutter will move out of the way as the product passes under it. 1) turn the power saver to full power. 2) allow warm up time of 5 to 10 minutes. 3) place a product on the conveyor belt. Crumb t...
Page 7
7 crumb tray & air intake cleaning operate il1243 clean front air intake fan cleaning preventive maintenance for your holman toaster consists of the following recommended cleaning procedures. To keep your toaster in top operating condition, these steps should be performed daily or weekly as indicate...
Page 8
8 troubleshooting guide a. Unit will not heat, conveyor belt will not move. 1) be sure the main circuit breaker is switched to the on position. 2) check to see if the toaster is plugged in and all controls are turned to the on position. B. Unit has heat only on one side, conveyor belt turns freely. ...
Page 9
9 maintenance procedures a. Replacing the heater tubes 1) disconnect unit from power source. 2) remove the enclosure. 3) remove heater tube wire from terminal block connection, keeping top and bottom wires separate. 4) lift heater tube retainers by loosening retaining screws and sliding the retainer...
Page 10
10 part# 2m-4497-2 05/06 rb the foregoing warranty is in lieu of any and all other warranties expressed or implied and constitutes the entire warranty. For assistance should you need any assistance regarding the operation or maintenance of any star equipment; write, phone, fax or email our service d...
Page 12
11 34 7 8 9 10 11 2 3 4 6 12 13 14 15 17 19 21 18 20 16 13 19 33 22 23 24 25 26 27 29 31 30 35 36 37 38 28 32 49 39 40 42 41 43 44 48 45 46 47 5 1 50 model: 9h- q3-95arb 208/240v conveyor t o aster this dra wing cont ains informa tion confidential t o st ar mfg. Int'l. Inc. No reproduction or disclo...
Page 13: Parts List
12 1 2m-z10370 1 label - toaster warning 2 hh-101371 1 enclosure, 3 hh-402470 1 panel, back, 4 2u-200561 1 motor, fan 5 2e-200566 1 switch, high limit reset 6 2u-200509 1 motor, drive, fan blade not included 2r-z8879 1 2-5/8 dia fan black fan blade, motor 7 2c-1487 2 screw 6-32x1/4 rhp st, fuseholde...
Page 14
13 blu red red red red org org blk blu blu blu blu yel wht wht wht wht maj maj red red blk blk blk blk model: qcs-3-1300 208/220/240v w/fuse q3-95arb 208/240 w/fuse this drawing contains information confidential to star mfg. Int'l. Inc. No reproduction or disclosure of its contents is permitted. Sta...
Page 16
Star manufacturing 10 sunnen drive, st. Louis, mo 63143 u.S.A. (800) 807-9054 (314) 781-2777 parts & service (800) 807-9054 www.Star-mfg.Com.