- DL manuals
- Holman
- Toaster
- QCS-2-1200B
- Installation And Operation Instructions Manual
Holman QCS-2-1200B Installation And Operation Instructions Manual
Summary of QCS-2-1200B
Page 1
® ® ® ® ® conveyor toaster model qcs-2-1200b rcs-2-1200b qcs-3-1600b installation and operation instructions 2m-hg0656 rev. I 2/11/2011 qcs-2.
Page 2
2 these symbols are intended to alert the user to the presence of important operating and maintenance instructions in the manual ac- companying the appliance. Retain this manual for future reference notice using any part other than genuine star factory supplied parts relieves the manufacturer of all...
Page 3
General installation data caution this equipment is designed and sold for commercial use only by personnel trained and experienced in its operation and is not sold for consumer use in and around the home nor for use directly by the general public in food service locations. Before using your new equi...
Page 4
Warning do not cut or remove this plug or grounding prong from the plug. Warning connect/plug unit into dedicated a.C. Line only specified on the data plate of the unit. Daily operation rotary power saver switch for toasters equipped with a rotary power saver switch, turn clockwise or counterclockwi...
Page 5
Clean operate toaster components daily operation check the power cord to insure that it is plugged into a proper outlet. Set the heat control knobs to desired temperature. Always allow 20 - 30 minutes of preheat time before loading the unit with product. Failure to allow sufficient preheat time will...
Page 6
Maintenance procedures a. Replacing heater tubes 1) disconnect unit from power source. 2) remove the enclosure, by removing screws. Lift back end of enclosure up then back. 3) remove heater tube wires from terminal block connection, keeping top and bottom wires separate. 4) lift heater tube retainer...
Page 7
Troubleshooting guide a. Unit will not heat, conveyor belt will not move. 1) be sure the main circuit breaker is switched to the on position. 2) check to see if the toaster is plugged in and all controls are turned to the on position. B. Unit has heat only on one side, conveyor belt turns freely. 1)...
Page 8
Part# 2m-4497-2 05/06 rb the foregoing warranty is in lieu of any and all other warranties expressed or implied and constitutes the entire warranty. For assistance should you need any assistance regarding the operation or maintenance of any star equipment; write, phone, fax or email our service depa...
Page 9
Front heat middle heat rear heat drive motor speed control reset switch power saver fan motor fan switch brn brn whi blu blk brn blk red org blk brn brn note: drive motor, for 240v use black and blue wires, for 208v use black & white wires. Brn brn brn blk red blk blk blk brn brn maj model: qcs-2-12...
Page 10
0 brn brn brn blu brn brn brn grn blu org red maj blk blk blk blk grn blk blk grn red brn brn blk brn grn org org blu note: drive motor, for 240v use black and blue wires, for 208v use black & white wires. Wire diagram 208/220/240 volt, sired series 065021 01-31-05 wiring diagram - rcs-2 1200b serpe...
Page 11
1 2 4 3 5 6 7 8 9 10 12 14 13 15 11 8 28 16 42 18 19 20 21 23 24 25 26 30 31 32 33 34 35 36 37 39 38 22 29 40 41 17 model: qcs/ rcs-2-1200b, 1600b conveyor t oaster this dra wing cont ains informa tion confidential t o st ar mfg. Int'l. Inc. No reproduction or disclosure of its contents is permitted...
Page 12: Parts List
Parts list april 4, 2011, rev. I qcs-2-1200b conveyor toasters important: when ordering, specify voltage or type gas desired page include model and serial number of some items are included for illustrative purposes only and in certain instances may not be available. Number per unit description part ...
Page 13: Parts List
Parts list april 4, 2011, rev. I qcs-3-1600b conveyor toasters important: when ordering, specify voltage or type gas desired page include model and serial number of some items are included for illustrative purposes only and in certain instances may not be available. Number per unit description part ...
Page 14: Parts List
Parts list april 4, 2011, rev. I rcs-2-1200b conveyor toasters some items are included for illustrative purposes only and in certain instances may not be available. Number per unit description part number key number 1 hc-101370 1 enclosure 2 hf-402449 1 panel, back 3 2e-200574 1 switch, fan ceramic ...
Page 15: Parts List
Parts list april 4, 2011, rev. I rcs conveyor toasters heater tubes 38 heater tube metal, top 208v 2n-209114 2 37 heater tube metal, bottom 208v 2n-209198 2 38 heater tube metal, top 220v 2n-209113 2 37 heater tube metal, bottom 220v 2n-209192 2 38 heater tube metal, top 240v 2n-209112 2 37 heater t...