- DL manuals
- Holman
- Toaster
- QCS-2 SERIES
- Installation And Operation Instructions Manual
Holman QCS-2 SERIES Installation And Operation Instructions Manual
Summary of QCS-2 SERIES
Page 1
1 ® conveyor toaster model qcs-2, qcs-3, rcs-2, rcs-3 series installation and operation instructions 2m-hg0651 rev. J 6/18/2007 qcs-2.
Page 2
2 2 these symbols are intended to alert the user to the presence of important operating and maintenance instructions in the manual accompanying the appliance. Retain this manual for future reference notice using any part other than genuine star factory supplied parts relieves the manufacturer of all...
Page 3
3 general installation data caution this equipment is designed and sold for commercial use only by personnel trained and experienced in its operation and is not sold for consumer use in and around the home nor for use directly by the general public in food service locations. Before using your new eq...
Page 4
4 warning do not cut or remove this plug or grounding prong from the plug. Warning connect/plug unit into dedicated a.C. Line only specified on the data plate of the unit. Daily operation rotary power saver switch for toasters equipped with a rotary power saver switch, turn clockwise or counterclock...
Page 5
5 toaster components daily operation check the power cord to insure that it is plugged into a proper outlet. Set the heat control knobs to desired temperature. Always allow 10 minutes of preheat time before loading the unit with product. Failure to allow suffi cient preheat time will result in unsat...
Page 6
6 maintenance procedures a. Replacing heater tubes 1) disconnect unit from power source. 2) remove the enclosure. 3) remove heater tube wire from terminal block connection, keeping top and bottom wires separate. 4) lift heater tube retainers by loosening retaining screws and sliding the retainer pla...
Page 7
7 troubleshooting guide a. Unit will not heat, conveyor belt will not move. 1) be sure the main circuit breaker is switched to the on position. 2) check to see if the toaster is plugged in and all controls are turned to the on position. B. Unit has heat only on one side, conveyor belt turns freely. ...
Page 8
8 part# 2m-4497-2 12/06 rms the foregoing warranty is in lieu of any and all other warranties expressed or implied and constitutes the entire warranty. For assistance should you need any assistance regarding the operation or maintenance of any star equipment; write, phone, fax or email our service d...
Page 9
9 org org blu blu brw brw yel blk red red red blk blk brw blk pur pur brw blk red br w blu model: qcs & rcs 4 tube - series this drawing contains information confidential to star mfg. Int'l. Inc. No reproduction or disclosure of its contents is permitted. Star manufacturing international inc. 065264...
Page 10
10 front heat middle heat rear heat drive motor speed control reset switch power saver fan motor fan switch brn brn whi blu blk brn blk red org blk brn brn note: drive motor, for 240v use black and blue wires, for 208v use black & white wires. Brn brn brn blk red blk blk blk brn brn maj model: qcs-2...
Page 11
11 this drawing contains information confidential to star mfg. Int'l. Inc. No reproduction or disclosure of its contents is permitted. Star manufacturing international inc. 065351 rev d 12/01/2003 ® org red blu red blk wht yel wht org red red blu blu pur pur wht wht wht blk blu blk blk models: qcs2-...
Page 12
12 blu red red red red org org blk blu blu blu blu yel wht wht wht wht maj maj red red blk blk blk blk model: qcs-3-1300 208/220/240v w/fuse q3-95arb 208/240 w/fuse this drawing contains information confidential to star mfg. Int'l. Inc. No reproduction or disclosure of its contents is permitted. Sta...
Page 13
13 models: qcs2-600, 800, 220/240v, 50hhz, 6 tube, phase control, wired series, ce qcs3-950, 1000 220/240v, 50-60hz, 6 tube, phase control, wired series, ce this drawing contains information confidential to star mfg. Int'l. Inc. No reproduction or disclosure of its contents is permitted. Star manufa...
Page 14
14 models: qcs2-300, 500, 50-60hz, 6 tube, phase control, wired parallel this drawing contains information confidential to star mfg. Int'l. Inc. No reproduction or disclosure of its contents is permitted. Star manufacturing international inc. 065200 rev b 12/11/2003 ® red red org blu blu org red red...
Page 15
15 red red red red red blu org blu org pur yel blk wht wht blk blk wht blk pur red wht blu wht 1 2 3 4 fan motor power supply cord reset/high limit drive motor speed control top heat bottom heat power saver h2 l1 pilot h1 l2 bottom heat top heat l1 h2 l2 h1 pilot model: qcs-rcs 14”, 120/208/240v - 6...
Page 16
16 29 44 45 46 47 48 q3-1300 only 1 2 4 3 5 6 7 8 9 10 12 14 13 15 11 8 27 28 16 17 18 19 20 21 23 24 25 26 30 31 32 33 34 35 36 37 39 40 22 42 43 model: qcs/rcs conveyor t o aster this dra wing cont ains informa tion confidential t o st ar mfg. Int'l. Inc. No reproduction or disclosure of its conte...
Page 17: Parts List
17 1 hc-101370 1 enclosure, qcs2/rcs 2 hf-402449 1 panel, back, qcs2/rcs 5 2u-200559 1 motor, fan 6 2u-200519 1 motor, drive, fan blade not included 2r-z8879 1 fan blade, motor 7 2a-202900 1 shaft, drive 8 ha-112261 2 bushing, rear 9 2p-z8779 1 sprocket, driven (25b11 x 5/16”) 10 2p-200645 1 sprocke...
Page 18: Parts List
18 1 hc-101370 1 enclosure, qcs/rcs-2 2 hf-402449 1 panel, back, qcs/rcs-2 5 2u-200560 1 motor, fan 6 2u-200509 1 motor, drive, fan blade not included 2u-200590 1 motor,drive,3286 bb,low, fan blade not included 50hz ce 2r-z8879 1 fan blade, motor 7 2a-202900 1 shaft, drive 8 ha-112261 2 bushing, rea...
Page 19: Parts List
19 important: when ordering, specify voltage or type gas desired page include model and serial number of 1 hh-101371 1 enclosure, qcs3 2 hh-402470 1 panel, back, qcs3 3 2e-200574 1 switch, fan ceramic 4 hg-402144 1 bracket, fan switch 5 2u-200561 1 motor, fan 6 2u-200509 1 motor, drive, fan blade no...
Page 20: Parts List
20 1 hh-101371 1 enclosure qcs/rcs-3 2 hh-402470 1 panel, back qcs/rcs-3 3 2e-200574 1 switch, fan ceramic 4 hg-402144 1 bracket, fan switch 5 2u-200561 1 motor, fan 6 2u-200509 1 motor, drive, fan blade not included 2r-z8879 1 fan blade, motor 7 2a-202902 1 shaft, drive 8 ha-112261 2 bushing, rear ...
Page 21: Parts List
21 40 r2-50, 120v 2n-209100 4 rcs-2-600h, 240v 2n-209106 4 rcs-2-600h, 208v 2n-209197 4 rcs-2-600hj, 208v 2n-209199 4 rcs-2-600hj, 240v 2n-209216 4 rcs-2-800, 240v 2n-209106 4 rcs-2-800, 208v 2n-209197 4 rcs-2-1200b, 208v 2n-209198 2 rcs-3-950h, 208v 2n-209130 4 rcs-3-950h, 240v 2n-209160 4 rcs-3-10...
Page 24
Star manufacturing 10 sunnen drive, st. Louis, mo 63143 u.S.A. (800) 807-9054 (314) 781-2777 parts & service (800) 807-9054 www.Star-mfg.Com.