Holmes HAP240 Owner's Manual - Operating Instructions
OPERATING INSTRUCTIONS
1. Plug into a 120V AC electrical outlet.
2. Select the desired operating speed; HI, NORMAL, or QUIET, by sliding
the switch to the appropriate setting. The red power light will now
illuminate.
3. To release negative ions into the filtered air, slide the ion button to
ON the green ion light will now illuminate.
4. For optimum air filtration, it is recommended to operate the air puri-
fier continuously. Its rugged motor has been designed to give many
years of use.
For continuous use, it is recommended to operate the air purifier at the
NORMAL setting. For quieter operation or use in a bedroom, select the
QUIET setting. When high levels of air pollution are present, select the
HI setting to quickly circulate and filter the room air.
PRE-OPERATING INSTRUCTIONS
TROUBLESHOOTING
1. Carefully unpack your Air Purifier. Select a firm, level place where there
are no obstructions to the air inlet (front grill) or filtered air outlet
(top of unit). A good location in a room is about 2 feet above the
floor, and approximately 1 foot away from the wall, in a central location
of your home.
2. Remove front grill by pressing in the grill release buttons on either
side of the grill and pulling it forward towards you (See fig. 1).
3. Remove the HEPA Filter by gripping on both sides and pulling forward
(fig. 2).
4. Remove protective plastic bag from the filter cartridge. Write the
installation date on the cartridge then re-install the cartridge by tilting
the cartridge top toward you as you insert the bottom of the cartridge
fully into the filter recess.
NOTE: Air Flow arrows on the cartridge must face away from you towards
the filter recess.
5. Replace front grill into unit.
CLEANING AND MAINTENANCE INSTRUCTIONS
CLEANING INSTRUCTIONS
Turn off and unplug the unit before cleaning
1. The outside of the air purifier can be cleaned with a soft, clean,
dampened cloth.
2. The front grill can be removed and washed in warm, soapy water
(NOT dishwasher safe). Dry before replacing in the unit.
3. The top air outlet grill can be cleaned of dust with a small, soft brush.
WARNING: Do not allow moisture to come in contact with the main
housing of the air purifier.
FILTER REPLACEMENT INSTRUCTIONS
1. Every few weeks, check the condition of the filters.
2. Remove the front grill. Examine the foam pre-filter. If the pre-filter
has collected a noticeable amount of dust or lint, remove it from the
inlet of the grill and wash it in warm, soapy water. Rinse and drip dry
the pre-filter thoroughly before replacing it into the inlet of the grill.
3. With the front inlet removed, check the HEPA filter. Match the color of
the pleated filter to the colors shown on the Filter Condition Indicator
label. If the filter has changed from white to a dark gray or brown
color, it is time to replace the filter. Remove the used HEPA cartridge
and dispose of in the garbage. DO NOT try to wash and re-use the
HEPA filter. Replace with a new HEPA HAPF30 filter, removing the pro-
tective polybag before inserting into the air purifier.
4. Filter Life - Under normal conditions of continuous use, the HEPA filter
will operate efficiently for 6 to 8 months.
5. Replacement filter (HAPF30) are available from your local supplier or
by calling 1-800-5-Holmes.
OPTIONAL BOOSTER FILTER (HAPF31)
1. An optional booster filter can be installed in your air purifier. This
booster filter will help remove unpleasant odors, and extend the life
of your main HEPA filter.
2. Under normal conditions of odor removal, the activated carbon layer
in the main filter cartridge may lose its efficiency in 2 to 3 months.
The use of the booster filter can extend the odor removal for another
2 to 3 months, for a total of 4 to 6 months of odor removal. In addi-
tion, the booster filter helps trap larger particles, thereby extending
the life of the HEPA filter.
3. The booster filter should be removed from its protective bag and
inserted into the recess between the foam pre-filter and the HEPA fil-
ter, as shown in figure 1.
4. The booster filters are available in packs of 2, and are only available
through The Customer Service Department at The Holmes Group, Inc.
To order the booster filter, please see page 4.
Please Note: The HAPF30 filter consists of the HEPA filter and an
activated carbon layer.
PROBLEM
SOLUTION
UNIT WILL NOT OPERATE
• Check to make sure the unit is plugged in
• Check to make sure the unit is on by
pressing the power switch.
DECREASED AIR FLOW
• Compare the color of the HEPA filter to the
filter indicator in the unit. If the filter is
gray or black, it is time to change the filter.
• The Ionizer may increase performance. Put
the Ionizer in the ON position to assist the
filter in particle removal.
A. AIR PURIFIER HOUSING
B. HEPA FILTER CARTRIDGE (HAPF-30)
Figure 2
A
B
Figure 1
C D
E
F
A B
G
H
I
J
K
L
M
A. INLET GRILL
B. WASHABLE FOAM
PRE-FILTER
C. FAN SPEED SLIDE
CONTROL
D. POWER LIGHT
E. FILTERED AIR OUTLET
F. ION NEEDLES
G. ION LIGHT
H. LINE CORD
I. SLIDE ION CONTROL
J. FILTER CHANGE
INDICATOR
K. HEPA FILTER
L. OPTIONAL BOOSTER
FILTER HAPF31
M. GRILL RELEASE
BUTTON
Page 3
THREE (3) YEAR LIMITED WARRANTY
SAVE THIS WARRANTY INFORMATION
A. The quality controls used in the manufacture of this Holmes product are to
ensure your satisfaction.
B. This Warranty applies only to the original purchaser of this product.
C. This Warranty applies ONLY to repair or replacement of any supplied or manu-
factured parts of this product that, upon inspection by Holmes authorized per-
sonnel, proves to have failed in normal use due to defects in material or work-
manship. Holmes will determine whether to repair or replace the unit. This
Warranty does not apply to installation expenses.
D. Operating this unit under conditions other than those recommended or at
voltages other than the voltage indicated on the unit, or attempting to service
or modify the unit, will render this WARRANTY VOID.
E. Unless otherwise proscribed by law, Holmes shall not be liable for any personal
injury, property or any incidental or consequential damages of any kind
(including water damage) resulting from malfunctions, defects, misuse,
improper installation or alteration of this product.
F. All parts of this Holmes product are guaranteed for a period of 3 years as
follows:
1. Within the first 30 days from date of purchase, the store from which you
purchased your Holmes product should replace this product if it is defective
in material or workmanship (provided the store has in-stock replacement.)
2. Within the first thirty six months from date of purchase, subject to the condi-
tions in paragraph H, Holmes will repair or replace the product if it is defective
in material or workmanship providing it is returned to Holmes, freight prepaid,
with PROOF OF PURCHASE date, together with $6.00 for handling and return
packing/shipping charges.
G. If you have any problem with this product, please write our Customer Service
Department.
H. IMPORTANT Return INSTRUCTIONS Your warranty depends on your following
these instructions if you are returning the unit more than 30 days after
the date of purchase:
1. Carefully pack the item in its original carton or other suitable box to avoid
damage in shipping.
2. Before packing your unit for return; be sure to enclose:
a) your name, full address with zip code and telephone number,
b) a dated sales receipt or PROOF OF PURCHASE,
c) your $6.00 check for return packaging, and
d) The model number of the unit and the problem you are having. (Enclose in
an envelope and tape directly to the unit before the box is sealed.)
3. Holmes recommends you insure the package (as damage in shipment is not
covered by your warranty).
4. All shipping charges must be prepaid by you (as noted in paragraph F).
5. Mark the outside of your package:
CONSUMER RETURNS
THE HOLMES GROUP, INC.
2 PULLMAN STREET
WORCESTER, MA 01606
SHIPPING AND HANDLING CHARGES: $6.00
This warranty gives you specific legal rights, and you may have other rights which
vary from state to state. The provisions of this warranty are in addition to, and not
a modification of, or subtraction from, the statutory warranties and other rights
and remedies contained in any applicable legislation. To the extent that any provi-
sion of this warranty is inconsistent with any applicable law, such provision shall be
deemed voided or amended, as necessary, to comply with such law.
HAP240/240400UM-1
Printed in CHINA
Page 4
1. Do NOT attempt to repair or adjust any electrical or mechanical functions on this
unit. Doing so will void the warranty.
2. If you need to exchange the unit, please return it in its original carton, with a
sales receipt, to the store you purchased it. If you are returning the unit more
than 30 days after the date of purchase, please see the enclosed warranty.
3. If you have any other questions or comments, feel free to write us:
The Holmes Group, Inc.
P.O. Box 769, Milford, MA 01757-0769
For your own records, staple or attach your sales receipt to this manual. Also,
please take a moment to write the store name/location and date purchased below.
STORE NAME
LOCATION:
DATE PURCHASED:
(STAPLE RECEIPT HERE)