Summary of 7500W
Page 1
Owners manual 7500w www.Homedieselpower.Com home diesel power.
Page 2
5 owner’s manual safety guidelines - defi nitions this manual contains important information that you need to know and understand in order to protect your safety and to prevent equipment problems. The following symbols help you recognize this information. Please read the manual and pay attention to ...
Page 3
9 owner’s manual general precautions (cont’d) electrical safety (cont’d) • all connections and conduits from the generator to the load must only be installed by trained and licensed electricians, and in compliance with all relevant local, state, and federal electrical codes and standards, and other ...
Page 4
Owner’s manual general precautions (cont’d) mechanical (cont’d) • do not operate the generator with safety guards removed. While the generator is running, do not attempt to reach around the safety guard for maintenance or any other reason. • keep hands, arms, long hair, loose clothing, and jewelry a...
Page 5
6^uly»z 4hu\hs 6wlyh[pvu 56;,! ;/, 7(9;: 30:;,+ ()6=, (9, /,37- *65;963: 4,5;065,+ ),36> *( ;/, ,5.05, 4 -033,+ >0;/ 6036-(/0./ 8> .9(+, ,5.05, 603 ;6 +6 :6 (5+ 9,46=, ;/, ,5.05,»: 603 +07:;0*2 36*(;,+ (; ;/, )6;;64 6- ;/, ,5.05, *9(52*(:, -033 ;/, ,5.05,»: *9(52*(:, 0;/ ;/, 305, 65 ;/, +07:;0*2 ;/,...
Page 6
21 operation (cont’d) powering 12 volt dc tools and equipment: 1. Prior to powering tools and equipment, make sure the generator’s rated voltage, and amperage capacity (12v dc) is adequate to supply all electrical loads that the unit will power. If powering exceeds the generator’s capacity, it may b...
Page 7
25 owner’s manual maintenance guide • before each use, inspect the generator. Check for: periodic maintenance and adjustment is necessary to keep the generator in good operating condition. Warning! Exhaust gas contains poisonous carbon monoxide. Shut off the engine before performing any maintenance....
Page 8
29 installation note: prior to powering tools and equipment make sure the generator’s rated voltage, wattage and amperage capacity is adequate to supply all electrical loads that the unit will power. If powering exceeds the generator’s capacity, it may be necessary to group one or more of the tools ...
Page 9
7500w generator 33 apa part no. Description a apg3075-a-01-jd head cover comp. Bolt apg3075-a-02-jd head cover washer comp apg3075-a-03-jd washer cover packing apg3075-a-04-jd head cover comp apg3075-a-05-jd head cover packing apg3075-a-06-jd flange bolt (m1ox 80) apg3075-a-07-jd spark plug apg3075-...
Page 10
7500w generator piston & connecting rod assy. 37 apa part no. Description e apg3075-e-01-jd compression ring a apg3075-e-02-jd compression ring b apg3075-e-03-jd oil ring a apg3075-e-04-jd oil ring b apg3075-e-05-jd piston pin clip (20 mm) apg3075-e-06-jd piston apg3075-e-07-jd piston pin apg3075-e-...
Page 11
7500w generator carburetor assy. 41 apa part no. Description i apg3075-i-01-jd tube clip apg3075-i-02-jd tube a apg3075-i-03-jd tube b apg3075-i-04-jd wipe harness clip apg3075-i-05-jd dashpot check valve apg3075-i-06-jd manual choke stay assy apg3075-i-07-jd carburetor iron gasket apg3075-i-08-jd c...
Page 12
7500w generator control assy. 45 apa part no. Description m apg3075-m-01-jd control assy apg3075-m-02-jd control base comp apg3075-m-03-jd control adjusting spring apg3075-m-04-jd pan screw (m5 x 34) apg3075-m-05-jd flange bolt (m6 x 14) apg3075-m-06-jd governor spring apg3075-m-07-jd throttle retur...
Page 13
7500w generator control box assy. 49 apa part no. Description q apgg7500-q-01-jd control panel comp apgg7500-q-02-jd engine switch assy apgg7500-q-03-jd dc 12v output apgg7500-q-04-jd hours meter apgg7500-q-05-jd 120v receptacle(ru-22) apgg7500-q-06-jd circuit breaker apgg7500-q-07-jd 120v receptacl...
Page 14
7500w generator wheel & hand assy. 53 apa part no. Description t apgg7500-t-01-jd pin split apgg7500-t-02-jd wsher plain apgg7500-t-03-jd wheel apgg7500-t-04-jd baffle apgg7500-t-05-jd shaft apgg7500-t-06-jd flange bolt (m6x 35) apgg7500-t-07-jd flange nut (m6) apgg7500-t-08-jd rubber bolt apgg7500-...