- DL manuals
- IBM
- Laptop
- A21e - ThinkPad 2628 - Celeron 600 MHz
- Hardware Maintenance Manual
IBM A21e - ThinkPad 2628 - Celeron 600 MHz Hardware Maintenance Manual
Summary of A21e - ThinkPad 2628 - Celeron 600 MHz
Page 1
Ibm mobile systems thinkpad computer hardware maintenance manual.
Page 2
Note before using this information and the product it supports, be sure to read the general information under “notices” on page 100. Second edition (december 2000) the following paragraph does not apply to the united kingdom or any country where such provisions are inconsistent with local law: inter...
Page 3: Contents
Contents introduction . . . . . . . . . . . . . 1 important service information . . . . . . . . . 1 strategy for replacing frus . . . . . . . . 1 how to use error messages . . . . . . . . 2 diskette compatibility matrix . . . . . . . . . 2 safety notices: multilingual translations . . . . . . 3 safe...
Page 4
1060 ultrabay 2000 device . . . . . . . . 58 1070 keyboard . . . . . . . . . . . 60 1080 keyboard cru insulator . . . . . . . 63 1090 hinge cover . . . . . . . . . . . 64 1100 keyboard bezel and speaker . . . . . . 65 1110 speaker cable . . . . . . . . . . 67 1120 sub card . . . . . . . . . . . . 68...
Page 5: Introduction
Introduction important service information important diskette fixes are customer-installable. The diskette fixes are posted on the ibm support site ( http://www.Pc.Ibm.Com/support/ ). Advise customers to contact the pc company helpcenter at 800-772-2227 if they need assistance in obtaining or instal...
Page 6
Attention the setup configuration on the computer you are servicing may have been customized. Running automatic configuration may alter the settings. Note the current configuration settings (using the view configuration option); then, when service has been completed, verify that those settings remai...
Page 7
Safety notices: multilingual translations in this manual, safety notices appear in english with a page number reference to the appropriate translation in this section. The safety notices are provided in english, french, german, italian, and spanish, as follows: safety notice 1 before the computer is...
Page 8
Safety notice 2 some standby batteries contain a small amount of nickel and cadmium. Do not disassemble a standby battery, recharge it, throw it into fire or water, or short-circuit it. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate par...
Page 9
Continuation of safety notice 2 alcune batterie di riserva contengono una piccola quantità di nichel e cadmio. Non smontarle, ricaricarle, gettarle nel fuoco o nell’acqua né cortocircuitarle. Smaltirle secondo la normativa in vigore (dpr 915/82, successive disposizioni e disposizioni locali). Quando...
Page 10
Safety notice 3 the battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pac...
Page 11
Safety notice 4 the lithium battery can cause a fire, an explosion, or a severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100°c (212°f), incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regula...
Page 12
Continuation of safety notice 4 la batería de repuesto es una batería de litio y puede provocar incendios, explosiones o quemaduras graves. No la recargue, ni quite el conector polarizado, ni la desmonte, ni caliente por encima de los 100°c (212°f), ni la incinere ni exponga el contenido de sus celd...
Page 13
Safety notice 5 if the lcd breaks and the fluid from inside the lcd gets into your eyes or on your hands, immediately wash the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are present after washing. Si le panneau d’affichage à cristaux liquides ...
Page 14
Safety notice 6 to avoid shock, do not remove the plastic cover that protects the lower part of the inverter card. Afin d’éviter tout risque de choc électrique, ne retirez pas le cache en plastique protégeant la partie inférieure de la carte d’alimentation. Aus sicherheitsgründen die kunststoffabdec...
Page 15
Safety notice 8 before removing any fru, power off the computer, unplug all power cords from electrical outlets, remove the battery pack, and then disconnect any interconnecting cables. Avant de retirer une unité remplaçable en clientèle, mettez le système hors tension, débranchez tous les cordons d...
Page 16
Safety information the following section contains the safety information that you need to be familiar with before servicing an ibm mobile computer. General safety follow these rules to ensure general safety: v observe good housekeeping in the area of the machines during and after maintenance. V when...
Page 17
Electrical safety observe the following rules when working on electrical equipment. Important use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have, near their e...
Page 18
Safety sections of maintenance information. Use extreme care when measuring high voltages. V regularly inspect and maintain your electrical hand tools for safe operational condition. V do not use worn or broken tools and testers. V never assume that power has been disconnected from a circuit. First,...
Page 19
To determine whether there are any potentially unsafe conditions, use the following checklist at the beginning of every service task. Begin the checks with the power off, and the power cord disconnected. Checklist: 1. Check exterior covers for damage (loose, broken, or sharp edges). 2. Power-off the...
Page 20
V prevent the part from touching your clothing. Most clothing is insulative and retains a charge even when you are wearing a wrist strap. V use the black side of a grounded work mat to provide a static-free work surface. The mat is especially useful when handling esd-sensitive devices. V select a gr...
Page 21
When a cd-rom drive or dvd drive is installed, note the following: use of controls or adjustments or performance of procedures other than those specified herein might result in hazardous radiation exposure. O uso de controles, ajustes ou desempenho de procedimentos diferentes daqueles aqui especific...
Page 22
Some cd-rom drives or dvd drives contain an embedded class 3a or class 3b laser diode. Note the following: emits visible and invisible laser radiation when open. Do not stare into the beam, do not view directly with optical instruments, and avoid direct exposure to the beam. Radiação por raio laser ...
Page 23: General Descriptions
General descriptions this chapter includes descriptions for any thinkpad model that has the pc-doctor dos diagnostics program. Some descriptions might not apply to your particular computer. Read this first before you go to the checkout guide, be sure to read this section. Important notes v only cert...
Page 24
__ 6. Procedure index and page number in which the failing fru was detected __ 7. Failing fru name and part number __ 8. Machine type, model number, and serial number __ 9. Customer’s name and address note for warranty: during the warranty period, the customer may be responsible for repair costs if ...
Page 25
Related service information this section provides information about the following: v “service web site” v “using recovery cd” v “passwords” on page 22 v “power management” on page 24 service web site when the latest maintenance diskette and the system program service diskette are available, a notice...
Page 26
8. If a menu appears asking which operating system to install, highlight proper operating system and press “enter”. 9. A menu will appear stating “full recovery:”. Press “enter” to select. 10. Enter “y” at the three windows which follow. 11. Follow prompts to complete recovery. Passwords as many as ...
Page 27
Without knowing the password, nobody can change the configuration of the computer. Attention if the svp has been forgotten, there is no way to reset it. How to remove the power-on password to remove a pop that you have forgotten, do the following: (a) if svp is not installed: 1. Turn off the compute...
Page 28
To remove the user hdp that you have forgotten, do the following: 1. Power on the computer by pressing and holding f1. 2. Enter the svp. The ibm bios setup utility menu appears. 3. Select password, using the cursor keys to move down the menu. 4. Select hard-disk x password, where x is the letter of ...
Page 29
Will not suspend even if lcd is closed in the power management properties window. Then only the lcd turns off.) in certain circumstances, the computer goes into standby mode automatically: v if a “suspend time” has been set on the timer, and the user does not do any operation with the keyboard, the ...
Page 30
V the system status, ram, vram, and setup data are stored on the hard disk. V the system is powered off. Notes: the computer cannot enter hibernation mode when it is powered with ac power and a communication pc card is used. Any one of the following events causes the computer to enter hibernation mo...
Page 31
Checkout guide use the following procedures as a guide in identifying and correcting problems with the thinkpad computer. Note: the diagnostic tests are intended to test only ibm products. The use of non-ibm products, prototype cards, or modified options can lead to false indications of errors and i...
Page 32
If an error code appears, go to “symptom-to-fru index” on page 41. On the first screen, select the model and press enter. Follow the instructions on the screen. 2. The main panel of pc-doctor appears. 3. Select diagnostics with the arrow keys, and press enter. A pull-down menu appears. (its exact fo...
Page 33
To cancel the test, press esc. Note: after executing pc-doctor, check the system time/date and reset them if needed. Detecting system information with pc-doctor pc-doctor can detect the following system information: hardware info v system configuration v memory contents v physical disk drives v logi...
Page 34
V “checking the backup battery” on page 32 checking the ac adapter you are here because the computer fails only when the ac adapter is used: v if the power problem occurs only when the port replicator is used, replace the port replicator. V if the power-on indicator does not turn on, check the power...
Page 35
Checking the battery pack battery charging does not start until the power meter shows that less than 95% of the total power remains; under this condition the battery pack can charge to 100% of its capacity. This protects the battery pack from being overcharged or from having a shortened life. To che...
Page 36
For nickel metal hydride battery; v if the voltage is more than +8.0 v dc, measure the resistance between battery terminals 4 and 5. The resistance must be 4 to 30 k ohm. If the resistance is not correct, replace the battery pack. If the resistance is correct, replace the system board. Checking the ...
Page 37: Thinkpad A21E
Thinkpad a21e product overview . . . . . . . . . . . . 35 specifications . . . . . . . . . . . . 35 status indicators . . . . . . . . . . . 36 fru tests . . . . . . . . . . . . . 38 fn key combinations . . . . . . . . . . 40 symptom-to-fru index . . . . . . . . . . 41 numeric error codes . . . . . ....
Page 38
12.1-in. Svga tft . . . . . . . . . 93 14.1-in. Xga tft . . . . . . . . . . 93 15.0-in. Xga tft . . . . . . . . . . 93 15.0-in. Xga tft (lg) . . . . . . . . 94 keyboard . . . . . . . . . . . . . 95 miscellaneous parts . . . . . . . . . . 96 optional frus. . . . . . . . . . . . 98 common parts list. ...
Page 39
Product overview this section presents the following product-unique information: v “specifications” v “status indicators” on page 36 v “fru tests” on page 38 v “fn key combinations” on page 40 specifications the following table lists the specifications of the thinkpad a21e series: feature descriptio...
Page 40
Status indicators the system status indicators show the status of the computer, as follows: indicator meaning 1 battery green: the battery is fully charged. Blinking green: the battery has enough power to operate, but is being charged. Orange: the battery power is low. The battery is to being charge...
Page 41
Indicator meaning 3 drive in use green: data is being read from or written to the hard-disk drive, the diskette drive, or the drive in the ultrabay 2000. When this indicator is on, do not put the computer into standby mode or turn off the computer. Note: do not move the system while the green drive ...
Page 42
Fru tests the following table shows the test for each fru. Fru applicable test system board 1. Diagnostics --> cpu/coprocessor 2. Diagnostics --> systemboard power diagnostics --> other devices --> ibm ac adapter, ibm battery 1 (ibm battery 2) lcd unit 1. Diagnostics --> video adapter 2. Interactive...
Page 43
Fru applicable test diskette drive 1. Diagnostics --> diskette drives 2. Interactive tests --> diskette cd-rom or dvd drive 1. Diagnostics --> other devices --> cd-rom/dvd 2. Interactive tests --> cd-rom/dvd test memory 1. If two dimms are installed, remove one of them and run diagnostics --> memory...
Page 44
Fn key combinations the following table shows the function of each combination of fn with a function key. The fn key works independently from the operating system. Key combination description fn + f1 reserved. Fn + f2 reserved. Fn + f3 turn off the lcd display, leaving the screen blank. To turn the ...
Page 45
Symptom-to-fru index the symptom-to-fru index in this section lists symptoms and errors and their possible causes. The most likely cause is listed first, in boldface type. Note: do the fru replacement or other actions in the sequence shown in the column headed “fru or action, in sequence.” if replac...
Page 46
Symptom or error fru or action, in sequence 0190 critical low battery error. 1. Charge the battery pack. 2. Battery pack. 0200 hard disk error — the hard disk is not working. 1. Reseat the hard-disk drive. 2. Load setup defaults in ibm bios setup utility. 3. Hard-disk drive. 4. System board. 021x st...
Page 47
Symptom or error fru or action, in sequence 0280 previous boot incomplete — default configuration used. 1. Load setup defaults in ibm bios setup utility. 2. Dimm. 3. System board. 02b2 incorrect drive a type. 1. Diskette drive. 2. External fdd cable. 3. I/o card. 02f4 eisa cmos not writable. 1. Load...
Page 48
Error messages symptom or error fru or action, in sequence device address conflict. 1. Load setup defaults in ibm bios setup utility. 2. Backup battery. 3. System board. Allocation error for device. 1. Load setup defaults in ibm bios setup utility. 2. Backup battery. 3. System board. Failing bits: n...
Page 49
Beep symptoms symptom or error fru or action, in sequence one beep and a blank, unreadable, or flashing lcd. 1. Reseat the lcd connector. 2. Lcd assembly. 3. External crt. 4. System board. One long and two short beeps, and a blank or unreadable lcd. 1. System board. 2. Lcd assembly. 3. Dimm. Two sho...
Page 50
Lcd-related symptoms important the tft lcd for the notebook computer contains many thin-film transistors (tfts). A small number of dots that are missing, discolored, or always lighted is characteristic of tft lcd technology, but excessive pixel problems can cause viewing concerns. The lcd should be ...
Page 51
3. If any error is detected, replace the fru shown by the fru code. Rerun the test to verify that no more errors exist. Undetermined problems you are here because the diagnostic tests did not identify which adapter or device failed, wrong devices are installed, a short circuit is suspected, or the s...
Page 52
V they are harder to tighten. V they should be used only once. Do the following when you service this machine: v keep the screw kit (for reference the p/n, see “miscellaneous parts” on page 96) in your tool bag. V always use new screws. V use a torque screwdriver if you have one. Tighten screws as f...
Page 53
Restoring the serial number of the system unit when the computer was manufactured, the eeprom on the system board was loaded with the serial numbers of the system and all major components. These numbers need to remain the same throughout the life of the computer. If you replace the system board, you...
Page 54
Removing and replacing a fru this section presents information and drawings for use in removing and replacing a fru. Be sure to observe the following general rules: 1. Do not try to service the computer unless you have been trained and certified. An untrained person runs the risk of damaging parts. ...
Page 55
1010 battery pack caution: if the rechargeable battery pack is incorrectly replaced, there is danger of an explosion. The battery pack contains a small amount of harmful substances. To avoid possible injury: (1) replace only with a battery of the type recommended by ibm, or an equivalent, (2) keep t...
Page 56
1020 dimm note: loosen the screw 1 , but do not remove it. When installing: with the notched end of the dimm toward the socket, insert the dimm into the socket, then press it firmly. Pivot the dimm until it snaps into place. Make sure that the card is firmly fixed in the slot and does not move easil...
Page 57
1030 mini pci adapter note: loosen the screw 1 , but do not remove it. 2 1 (continued) v battery pack (1010) removing and replacing a fru thinkpad a21e 53.
Page 58
Note: the illustration shows the combo card. Connector (a) is for the lan feature and (b) is for the modem feature. This slot also supports a mini pci modem card or mini pci network card. Step 5 depends on the card type. Disconnect either (a), (b) or both. When installing the card, do the following:...
Page 59
1040 backup battery caution: there is a danger of an explosion if the backup battery is incorrectly replaced. The lithium battery (ibm p/n 02k6572 ul-recognized component [file no. Mh12210]) contains lithium and can explode if it is not properly handled or disposed of. Replace only with a battery of...
Page 60
1050 hard-disk drive attention do not drop or apply any shock to the hard-disk drive. The hard-disk drive is sensitive to physical shock. Incorrect handling can cause damage and permanent loss of data. Before removing the drive, have the user make a backup copy of all the information on the drive if...
Page 61
When installing: make sure that the hdd connector is firmly connected. Removing and replacing a fru thinkpad a21e 57.
Page 62
1060 ultrabay 2000 device any of several devices can be inserted into the ultrabay 2000. The procedure for installing and removing is the same for every device. Note: when you release the switch in step 1 the lever pops out. Pull the lever a little in step 2 to release the device from the bay. Remov...
Page 63
(continued) removing and replacing a fru thinkpad a21e 59.
Page 64
1070 keyboard 11 step screw (quantity) torque 1 m2.5 × 15 mm, nylon-coated (3) 39.2 ncm (4 kgfcm) (continued) v battery pack (1010) v hard-disk drive (1050) v ultrabay 2000 device (1060) removing and replacing a fru 60 thinkpad a21e.
Page 65
(continued) removing and replacing a fru thinkpad a21e 61.
Page 66
When installing: when installing the keyboard, do as follows: 1. Install the new keyboard, following the directions in the figure. Make sure that the keyboard edges, shown in the figure as (a), (b), and (c), are under the frame. 2. Push the y key 1 to connect the keyboard to the connector on the und...
Page 67
1080 keyboard cru insulator v battery pack (1010) v hard-disk drive (1050) v ultrabay 2000 device (1060) v keyboard (1070) removing and replacing a fru thinkpad a21e 63.
Page 68
1090 hinge cover step screw (quantity) torque 1 m2.5 × 15 mm, nylon-coated (1) 39.2 ncm (4 kgfcm) v battery pack (1010) v hard-disk drive (1050) v ultrabay 2000 device (1060) v keyboard (1070) v keyboard cru insulator (1080) removing and replacing a fru 64 thinkpad a21e.
Page 69
1100 keyboard bezel and speaker step screw (quantity) torque 1 m2.5 × 4.8 mm, nylon-coated (7) 39.2 ncm (4 kgfcm) (continued) v battery pack (1010) v hard-disk drive (1050) v ultrabay 2000 device (1060) v keyboard (1070) v keyboard cru insulator (1080) v hinge cover (1090) removing and replacing a f...
Page 70
Step screw (quantity) torque 2 m2.5 × 15 mm, nylon-coated (2) 39.2 ncm (4 kgfcm) cable routing: when replacing the cable, see the preceding figure for its cable routing. Removing and replacing a fru 66 thinkpad a21e.
Page 71
1110 speaker cable when installing: make sure that you fasten the connector firmly. V battery pack (1010) v hard-disk drive (1050) v ultrabay 2000 device (1060) v keyboard (1070) v keyboard cru insulator (1080) v hinge cover (1090) v keyboard bezel and speaker (1100) removing and replacing a fru thi...
Page 72
1120 sub card step screw (quantity) torque 1 special, nylon-coated (2) — (continued) v battery pack (1010) v hard-disk drive (1050) v ultrabay 2000 device (1060) v keyboard (1070) v keyboard cru insulator (1080) v hinge cover (1090) v keyboard bezel and speaker (1100) removing and replacing a fru 68...
Page 73
Step screw (quantity) torque 2 m2.5 × 4.8 mm, nylon-coated (1) 39.2 ncm (4 kgfcm) removing and replacing a fru thinkpad a21e 69.
Page 74
1130 pc card slot assembly step screw (quantity) torque 1 m2.0 × 9.5 mm, nylon-coated (2) 24.5 ncm (2.5 kgfcm) v battery pack (1010) v hard-disk drive (1050) v ultrabay 2000 device (1060) v keyboard (1070) v keyboard cru insulator (1080) v hinge cover (1090) v keyboard bezel and speaker (1100) v sub...
Page 75
1140 fan assembly step screw (quantity) torque 1 m2.5 × 4.8 mm, nylon-coated (3) 39.2 ncm (4 kgfcm) v battery pack (1010) v hard-disk drive (1050) v ultrabay 2000 device (1060) v keyboard (1070) v keyboard cru insulator (1080) v hinge cover (1090) v keyboard bezel and speaker (1100) removing and rep...
Page 76
When installing: when installing the fan assembly, apply the thermal grease (05k5751) on the a -part of the fan as shown in the following figure. Removing and replacing a fru 72 thinkpad a21e.
Page 77
1150 diskette drive note: remove the diskette drive spacer 1 gently; it will be reused when installing the new diskette drive. Step screw (quantity) torque 2 m2.5 × 4.8 mm, nylon-coated (1) 39.2 ncm (4 kgfcm) 3 m2.5 × 15 mm, nylon-coated (2) 39.2 ncm (4 kgfcm) when installing: do not press the a -pa...
Page 78
1160 upper shield step screw (quantity) torque 1 m2.5 × 15 mm, nylon-coated (2) 39.2 ncm (4 kgfcm) 2 m2.5 × 4.8 mm, nylon-coated (2) 39.2 ncm (4 kgfcm) v battery pack (1010) v hard-disk drive (1050) v ultrabay 2000 device (1060) v keyboard (1070) v keyboard cru insulator (1080) v hinge cover (1090) ...
Page 79
1170 system board step screw (quantity) torque 1 m2.5 × 15 mm, nylon-coated (3) 39.2 ncm (4 kgfcm) (continued) v battery pack (1010) v dimm (1020) v mini pci adapter (1030) v backup battery (1040) v hard-disk drive (1050) v ultrabay 2000 device (1060) v keyboard (1070) v keyboard cru insulator (1080...
Page 80
Step screw (quantity) torque 3 m2.5 × 4.8 mm, nylon-coated (2) 39.2 ncm (4 kgfcm) removing and replacing a fru 76 thinkpad a21e.
Page 81
2010 lcd assembly step screw (quantity) torque 1 m2.5 × 4.8 mm, nylon-coated (4) 39.2 ncm (4 kgfcm) (continued) v battery pack (1010) v hard-disk drive (1050) v ultrabay 2000 device (1060) v keyboard (1070) v keyboard cru insulator (1080) v hinge cover (1090) v keyboard bezel and speaker(1100) remov...
Page 82
Step screw (quantity) torque 2 special, nylon-coated (2) — 4 m2.5 × 4.8 mm, nylon-coated (2) 39.2 ncm (4 kgfcm) removing and replacing a fru 78 thinkpad a21e.
Page 83
2020 front bezel step screw (quantity) torque 1 m2.5 × 4.8 mm, nylon-coated (2) 39.2 ncm (4 kgfcm) v battery pack (1010) v hard-disk drive (1050) v ultrabay 2000 device (1060) v keyboard (1070) v keyboard cru insulator (1080) v hinge cover (1090) v keyboard bezel and speaker (1100) v lcd assembly (2...
Page 84
Note: only the front bezel for the 15.0-in. Xga tft (lg) has a identifying mark ( v ), as in the following figure. For reference fru list, see “15.0-in. Xga tft (lg)” on page 94 removing and replacing a fru 80 thinkpad a21e.
Page 85
2030 inverter card 12.1-in. Panel step screw (quantity) torque 1 m2.5 × 4.8 mm, nylon-coated (1) 39.2 ncm (4 kgfcm) (continued) v battery pack (1010) v hard-disk drive (1050) v ultrabay 2000 device (1060) v keyboard (1070) v keyboard cru insulator (1080) v hinge cover (1090) v keyboard bezel and spe...
Page 86
14.1-in. And 15.0-in. Panels step screw (quantity) torque 1 m2.5 × 4.8 mm, nylon-coated (1) 39.2 ncm (4 kgfcm) removing and replacing a fru 82 thinkpad a21e.
Page 87
2040 lcd panel 12.1-in. Panel step mt screw (quantity) torque 1 2628-cxx m2.5 × 7.0 mm, nylon-coated (4) 39.2 ncm (4 kgfcm) (continued) v battery pack (1010) v hard-disk drive (1050) v ultrabay 2000 device (1060) v keyboard (1070) v keyboard cru insulator (1080) v hinge cover (1090) v keyboard bezel...
Page 88
(continued) removing and replacing a fru 84 thinkpad a21e.
Page 89
14.1-in. And 15.0-in. Panels step mt screw (quantity) torque 1 2628-jxx m2.0 × 5.7 mm, nylon-coated (4) 24.5 ncm (2.5 kgfcm) (continued) removing and replacing a fru thinkpad a21e 85.
Page 90
Note: for 14.1-in. Lcd, the lcd cable is taped onto the connector. Tear off the tape before disconnecting the lcd cable in step 3 . Removing and replacing a fru 86 thinkpad a21e.
Page 91
Locations front view 1 system status indicators 2 battery and standby mode status indicators 3 built-in stereo speakers 4 pc card eject button 5 pc card slot 6 bay latch 7 eject button 8 ultrabay 2000 device note: the ultrabay 2000 accepts storage devices, such as a dvd drive, cd-rom drive, cd-rw, z...
Page 92
Rear view 1 security keyhole 2 parallel connector 3 modem connector 4 network connector 5 serial connector 6 external-monitor connector 7 universal serial bus (usb) connector 8 external-input-device connector 9 power jack locations 88 thinkpad a21e.
Page 93
Bottom view 1 battery pack 2 battery pack latches 3 mini pci card slot 4 docking connector 5 dimm slot 6 stereo headphone jack 7 stereo line-in jack 8 diskette drive 9 microphone jack 10 hard-disk drive 11 lcd latches locations thinkpad a21e 89.
Page 94
Parts list parts list 90 thinkpad a21e.
Page 95
The parts marked with asterisk are cru (customer replacable unit). No. Fru p/n 1 lcd unit (see “lcd fru” on page 93) 2 hinge cover for mt2628-jxx, -ixx 04p3970 for mt2628-cxx 04p3972 for mt2632 (i-series) 04p3725 3 speaker assembly for mt2628-jxx 02k5644 for mt2628-cxx and mt2632 (i-series) 02k5007 ...
Page 96
No. Fru p/n b card modem connector (see “miscellaneous parts” on page 96) 13 cover, mini pci adapter slot* 08k5673 14 battery pack (6 cell), sanyo* 02k6618 battery pack (6 cell), panasonic* 02k6614 battery pack (7 cell) nimh, panasonic* 02k6720 battery pack (9 cell), sanyo* 02k6619 battery pack (9 c...
Page 97
Lcd fru 12.1-in. Svga tft fru p/n lcd cover assembly 08k5655 for korea 08k5659 lcd cable 27l0485 lcd panel (sanyo) 05k9577 hinges 08k5664 inverter card 08k3325 14.1-in. Xga tft fru p/n lcd cover assembly for mt2628-ixx 08k5656 for mt2632 (i-series) 04p3724 lcd cable for mt2628-ixx 27l0486 for mt2632...
Page 98
15.0-in. Xga tft (lg) fru p/n lcd cover assembly 04p3048 for korea 04p3049 lcd cable 27l0578 lcd panel (lg) 05k9647 hinges 04p3488 inverter card 08k3326 misc kit (see “miscellaneous parts” on page 96.) 04p3050 parts list 94 thinkpad a21e.
Page 99
Keyboard language p/n arabic 02k5476 belgian 02k5470 canadian french 02k5456 chinese, traditional 02k5459 czech 02k5480 danish 02k5467 dutch 02k5464 european spanish 02k5469 european french 02k5463 german 02k5462 greek 02k5473 hungarian 02k5479 hebrew 02k5474 italian 02k5468 japanese 02k5458 korean ...
Page 100
Miscellaneous parts fru p/n screw kit (including nylon-coated screws): v m2 x 3.6 mm, flat head (3) v m2 x 5.1 mm, flat head (5) v m2 x 5.7 mm, flat head (5) v m2 x 16 mm, bind head (3) v m2.5 x 4.8 mm, flat head (42) v m2.5 x 5.5 mm, flat head (2) v m2.5 x 15 mm, flat head (15) v m2.6 x 2.8 mm, bin...
Page 101
Fru p/n miscellaneous parts, for diskette drive: v bezel v bracket v flexible cable v screw caps 04p3967 miscellaneous parts, for lcd: v latch (right/left) v spring v spacer (for 15.0-in.) v blank cap, ultraport v screw caps 04p3968 miscellaneous kit for lcd 15.0-in. Lg v latch (rh 15.0 lg) v latch ...
Page 102
Optional frus 64-mb sdram so dimm 20l0264 128-mb sdram so dimm 20l0265 ac adapter (72w), 3-pin (astec) 02k6666 ac adapter (72w), 3-pin (delta) 02k6670 ac adapter (72w), 2-pin (astec) 02k6669 ac adapter (72w), 2-pin (sanken) 02k6677 ac adapter (72w), 2-pin (delta) 02k6673 ultrabay 2000 cd-rom drive (...
Page 103
Common parts list tools triconnector wrap plug 72x8546 pc test card 35g4703 audio wrap cable 66g5180 usb parallel test cable 05k2580 screwdriver kit 95f3598 torque screwdriver 05k4695 5 mm socket wrench 05k4694 screwdriver 27l8126 thinkpad hardware maintenance diskette version 1.61 note: download th...
Page 104
Notices references in this publication to ibm products, programs, or services do not imply that ibm intends to make these available in all countries in which ibm operates. Any reference to an ibm product, program, or service is not intended to state or imply that only that ibm product, program, or s...
Page 105
Notices thinkpad a21e 101.
Page 106
Part number: 06p8883 printed in u.S.A. (1p) p/n: 06p8883.