1. DL manuals
  2. IBM
  3. Laptop
  4. ThinkPad 570
  5. Hardware Manual

IBM ThinkPad 570 Hardware Manual

Manual is about: IBM ThinkPad 570E: User Guide

Summary of ThinkPad 570

  • Page 1

    January 2000 this manual supports: thinkpad 570 (mt 2643/2644) thinkpad 570e (mt 2643/2644).

  • Page 2

    Note before using this information and the product it supports, be sure to read the general information under “notices” on page 111. First edition (january 2000) the following paragraph does not apply to the united kingdom or any country where such provisions are inconsistent with local law: interna...

  • Page 3

    Contents introduction . . . . . . . . . . . . . . . . . . . 1 important service information . . . . . . . . . . . 1 how to use error messages . . . . . . . . . . 2 how to read post error messages . . . . . . 2 drive and diskette compatibility matrix . . . . . . . 3 safety notices (multi-lingual tran...

  • Page 4

    1080 frame and power switch . . . . . . . . . 63 1090 audio card . . . . . . . . . . . . . . . 65 1100 modem jack . . . . . . . . . . . . . . . 66 1110 speaker . . . . . . . . . . . . . . . . . 67 1120 audio cable . . . . . . . . . . . . . . . 69 1130 pc card slots . . . . . . . . . . . . . . 70 114...

  • Page 5

    Introduction important service information important diskette fixes are customer installable. The diskette fixes are located on the pc company bulletin board service (bbs). The direct phone line for modem connection is 919-557-0001 or tieline 255-0001. Advise customers to contact the pc company help...

  • Page 6

    Attention a customized setup configuration (other than default settings) may exist on the computer you are servicing. Running automatic configuration may alter those settings. Note the current configuration settings (using the view configuration option) and verify that the settings are in place when...

  • Page 7

    Drive and diskette compatibility matrix the following table provides identification information for 3.5-inch drives. Diskette drive identifying mark 3.5-inch - 1.44mb 1.44 on the eject button 3.5-inch - 2.88mb 2.88 on the eject button the following table provides compatibility information for 3.5-in...

  • Page 8

    Safety notices (multi-lingual translations) in this manual, safety notices appear in english with a page number reference to the appropriate multi-lingual, translated safety notice found in this section. The following safety notices are provided in english, french, german, italian, and spanish langu...

  • Page 9

    Safety notice 2 some standby batteries contain a small amount of nickel and cadmium. Do not disassemble it, recharge it, throw it into fire or water, or short-circuit it. Dispose of the battery as required by local ordinances or regulations. Use only the battery in the appropriate parts listing. Use...

  • Page 10

    Safety notice 3 the battery pack contains small amounts of nickel. Do not disassemble it, throw it into fire or water, or short-circuit it. Dispose of the battery pack as required by local ordinances or regulations. Use only the battery in the appropriate parts listing when replacing the battery pac...

  • Page 11

    Safety notice 4 the lithium battery can cause a fire, explosion, or severe burn. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100°c (212°f), incinerate it, or expose its cell contents to water. Dispose of the battery as required by local ordinances or regulations...

  • Page 12

    Safety notice 5 if the lcd breaks and the fluid from inside the lcd gets into your eyes or on your hands, immediately wash the affected areas with water for at least 15 minutes. Seek medical care if any symptoms from the fluid are present after washing. Si le panneau d'affichage à cristaux liquides ...

  • Page 13

    Safety notice 6 to avoid shock, do not remove the plastic cover that surrounds the lower portion of the inverter card. Afin d'éviter tout risque de choc électrique, ne retirez pas le cache en plastique protégeant la partie inférieure de la carte d'alimentation. Aus sicherheitsgründen die kunststoffa...

  • Page 14

    Safety notice 8 before removing any fru, power-off the computer, unplug all power cords from electrical outlets, remove the battery pack, then disconnect any interconnecting cables. Avant de retirer une unité remplaçable en clientèle, mettez le système hors tension, débranchez tous les cordons d'ali...

  • Page 15

    Safety information the following section contains the safety information that you need to be familiar with before servicing an ibm mobile computer. General safety follow these rules to ensure general safety: observe good housekeeping in the area of the machines during and after maintenance. When lif...

  • Page 16

    Electrical safety observe the following rules when working on electrical equipment. Important use only approved tools and test equipment. Some hand tools have handles covered with a soft material that does not insulate you when working with live electrical currents. Many customers have, near their e...

  • Page 17

    Regularly inspect and maintain your electrical hand tools for safe operational condition. Do not use worn or broken tools and testers. Never assume that power has been disconnected from a circuit. First, check that it has been powered-off. Always look carefully for possible hazards in your work area...

  • Page 18

    The guide consists of a series of steps presented in a checklist. Begin the checks with the power off, and the power cord disconnected. Checklist: 1. Check exterior covers for damage (loose, broken, or sharp edges). 2. Power-off the computer. Disconnect the power cord. 3. Check the power cord for: a...

  • Page 19

    Handling electrostatic discharge-sensitive devices any computer part containing transistors or integrated circuits (ics) should be considered sensitive to electrostatic discharge (esd). Esd damage can occur when there is a difference in charge between objects. Protect against esd damage by equalizin...

  • Page 20

    Laser compliance statement some ibm personal computer models are equipped from the factory with a cd-rom drive. Cd-rom drives are also sold separately as options. The cd-rom drive is a laser product. The cd-rom drive is certified in the u.S. To conform to the requirements of the department of health...

  • Page 21

    El uso de controles o ajustes o la ejecución de procedimientos distintos de los aquí especificados puede provocar la exposición a radiaciones peligrosas. Opening the cd-rom drive could result in exposure to hazardous laser radiation. There are no serviceable parts inside the cd-rom drive. Do not ope...

  • Page 22

    18 thinkpad 570 and 570e hardware maintenance manual.

  • Page 23

    Read this first general descriptions this chapter includes descriptions for any thinkpad model that has the pc-doctor dos diagnostics program. Some descriptions might not apply to your particular computer. Read this first before you go to the checkout guide, be sure to read this section. Important n...

  • Page 24

    Read this first 6. Procedure index and page number in which the failing fru was detected 7. Failing fru name and part number 8. Machine type, model number, and serial number 9. Customer's name and address before checking problems with the computer, determine whether the damage is covered under the w...

  • Page 25

    Read this first important the following symptoms might indicate damage caused by nonwarranted activities: missing parts might be a symptom of unauthorized service or modification. Hard disk drive spindles can become noisy from being subjected to excessive force or from being dropped. I9990303 errors...

  • Page 26

    Related service information related service information this section provides information about the following: “reset switch” “service web site” “passwords” power management features reset switch the reset switch resets the system (regardless of the microcode status) and forces the power off. Use th...

  • Page 27

    Related service information supervisor and hard disk passwords: the supervisor password (pap) and the hard disk password (hdp) are security features that are used to protect the system and the hard disk data from unauthorized access. No overriding capability is provided. If only a hard disk password...

  • Page 28

    Related service information power management features to reduce power consumption, the computer has three power management modes: standby, suspend, and hibernation. Standby mode: in standby mode, the following occurs: the lcd backlight turns off. The hard disk drive motor stops. The speaker is muted...

  • Page 29

    Related service information the power-saving mode. This default low-battery behavior is independent of the operating system: so if you have set the low-battery alarm, the computer may not do what you specified. It chooses either your setting or the default setting, whichever is appropriate. Any one ...

  • Page 30

    Related service information the timer conditions are satisfied in suspend mode (for operating systems other than windows 98). A critically low battery condition occurs and the mode is set to hibernate when battery becomes low. When the power is turned on, the computer leaves hibernation mode and res...

  • Page 31

    Checkout guide checkout guide use the following procedures as a guide in identifying and correcting problems with the thinkpad computer. Note: the diagnostic tests are intended to test only ibm products. The use of non-ibm products, prototype cards, or modified options can lead to false indications ...

  • Page 32

    Checkout guide the options on the test menu are as follows: 4. Run the applicable function test. 5. Follow the instructions on the screen. If there is a problem, pc-doctor shows some messages. 6. To exit the test, select quit — exit diag. To cancel the test, press esc. Diagnostics interactive tests ...

  • Page 33

    Checkout guide vga information ide drive info pci information pnpisa info smbios info fru info utility: run external tests surface scan hard disk benchmark system dos shell tech support form battery rundown view test log print log save log full erase hard drive quick erase hard drive power system ch...

  • Page 34

    Checkout guide (16 - 10 v) if the voltage is not correct, replace the ac adapter. If the voltage is acceptable, do the following: replace the system board. If the problem persists, go to “product overview” on page 35. Note: noise from the ac adapter does not always indicate a defect. Checking operat...

  • Page 35

    Checkout guide 3. If the voltage is less than + 11.0 v dc, the battery pack has been discharged. Recharge the battery pack. Note: it takes at least 3 hours to recharge the battery pack. If the voltage is still less than + 11.0 v dc after recharging, replace the battery. 4. If the voltage is more tha...

  • Page 36

    Checkout guide if the voltage is correct, replace the system board. If the voltage is not correct, replace the backup battery. If the backup battery discharges quickly after replacement, replace the system board. 32 thinkpad 570 and 570e hardware maintenance manual.

  • Page 37

    Thinkpad 570 and 570e thinkpad 570 and 570e this chapter includes the descriptions for the thinkpad 570 series computer. Product overview . . . . . . . . . . . . . . . . . 35 specifications . . . . . . . . . . . . . . . . . 35 status indicators . . . . . . . . . . . . . . . . 37 structure . . . . . ...

  • Page 38

    Thinkpad 570 and 570e lcd fru . . . . . . . . . . . . . . . . . . 103 keyboard . . . . . . . . . . . . . . . . . . 106 common parts list . . . . . . . . . . . . . 108 34 thinkpad 570 and 570e hardware maintenance manual.

  • Page 39

    Product overview product overview this section describes the following product-unique information: “specifications” “status indicators” on page 37 “structure” on page 38 “fn key combinations” on page 41 specifications the following table lists the specifications of the thinkpad 570 series: feature d...

  • Page 40

    Product overview feature description video 570 12.1-inch, 16m colors svga (800 × 600 resolution) tft color lcd 13.3-inch, 16m colors, xga (1024 × 768 resolution) tft color lcd 570e 13.3-inch, 16m colors, xga (1024 × 768 resolution) tft color lcd diskette drive (external) 1.44 mb (3-mode), 3.5-inch h...

  • Page 41

    Product overview status indicators the system status indicators show the current computer status in different colors (green or orange): symbol color meaning 1 battery green the battery is fully charged. Orange the battery is charging. Blinking orange the battery needs charging. 2 suspend mode green ...

  • Page 42

    Product overview structure the following illustration shows the overall organization if the frus. 38 thinkpad 570 and 570e hardware maintenance manual.

  • Page 43

    Product overview the following table shows the test for each fru. Fru applicable test system board 1. Diagnostics --> cpu/coprocessor 2. Diagnostics --> systemboard power diagnostics --> battery lcd unit 1. Diagnostics --> video adapter 2. Interactive tests --> video modem 1. Make sure the modem set...

  • Page 44

    Product overview fru applicable test diskette drive 1. Diagnostics --> diskette drive 2. Interactive tests --> diskette cd-rom or dvd drive (in the ultrabase) interactive tests --> cd-rom/dvd joystick interactive tests --> joystick memory 1. If a dimm is installed, remove it and run memory test - qu...

  • Page 45

    Product overview fn key combinations the following table shows the function of each combination of fn with a function key. The fn key works independently from the operating system. The operating system obtains the status through the system management interface to control the system. Key combination ...

  • Page 46

    Symptom-to-fru index symptom-to-fru index the symptom-to-fru index lists symptoms and errors and their possible causes. The most likely cause is listed first, in boldface type. Note do the fru replacement or other actions in the sequence shown in the “fru/action in sequence” column. If a fru replace...

  • Page 47

    Symptom-to-fru index symptom or error fru or action, in sequence 0220 monitor type does not match cmos 1. Load setup defaults in ibm bios setup utility. 0230 shadow ram failure at offset nnnn 1. System board. 0231 system ram failure at offset nnnn 1. Dimm. 2. System board. 0250 system battery is dea...

  • Page 48

    Symptom-to-fru index symptom or error fru or action, in sequence 02f5 dimm test failure 1. Dimm. 2. System board. 02f6 software nmi failure 1. Dimm. 2. System board. 02f7 fail—safe timer nmi failure 1. Dimm. 2. System board. Error messages symptom or error fru or action, in sequence device address c...

  • Page 49

    Symptom-to-fru index beep symptoms no beep symptoms symptom or error fru or action, in sequence one beep and a blank, unreadable, or flashing lcd 1. Reseat the lcd connector 2. Lcd assembly 3. System board one long and two short beeps, and a blank or unreadable lcd 1. System board. 2. Lcd assembly. ...

  • Page 50

    Symptom-to-fru index symptom or error fru or action, in sequence no beep, power-on indicator on, and a blank lcd during post 1. System board. Lcd backlight not working lcd too dark lcd brightness cannot be adjusted lcd contrast cannot be adjusted 1. Reseat the lcd connectors.. 2. Lcd assembly. 3. Sy...

  • Page 51

    Symptom-to-fru index 3. Remove or disconnect all of the following devices: a. Non-ibm devices b. Devices attached to the port replicator c. Printer, mouse, and other external devices d. Battery pack e. Hard disk drive f. External diskette drive g. Dimm h. Cd-rom and diskette drive in the ultraslimba...

  • Page 52

    Fru replacement notices fru replacement notices this section contains notices for removal and replacement. Read this section carefully before replacing any fru. Screw notices loose screws can cause a reliability problem. The an ibm thinkpad computer address this problem with special nylon-coated scr...

  • Page 53

    Fru replacement notices torque shown in the table. Never use a screw that you removed. Use a new one. Make sure the screws are tightened firmly retaining serial numbers this section includes the following descriptions: “restoring the serial number of the system unit” “retaining the uuid” restoring t...

  • Page 54

    Fru replacement notices 1. Install the thinkpad hardware maintenance diskette version 1.60, and restart the computer. 2. Select 4. Assign uuid from the main menu. A new uuid is created and written. If a valid uuid already exists, it is not overwritten. 50 thinkpad 570 and 570e hardware maintenance m...

  • Page 55

    Removing and replacing a fru removing and replacing a fru this section presents information and drawings for use in removing and replacing a fru. Be sure to observe the following general rules: 1. Do not try to service the computer unless you have been trained and certified. An untrained person runs...

  • Page 56

    Removing and replacing a fru attention the system board is sensitive to, and can be damaged by, electrostatic discharge. Establish personal grounding by touching a ground point with one hand before touching these units. You must use electrostatic discharge (esd) strap (p/n 6405959) to establish pers...

  • Page 57

    Removing and replacing a fru 1010 battery pack thinkpad 570 and 570e 53.

  • Page 58

    Removing and replacing a fru 1020 backup battery safety notice 4: translation on page 7 the backup battery is a lithium battery and can cause a fire, an explosion, or severe burns. Do not recharge it, remove its polarized connector, disassemble it, heat it above 100°c (212°f), incinerate it, or expo...

  • Page 59

    Removing and replacing a fru cable route: thinkpad 570 and 570e 55.

  • Page 60

    Removing and replacing a fru 1030 dimm battery pack (1010) note the thinkpad 570e computer's dimm slot faces in the direction opposite that shown here. However, the procedure for removing dimm is the same. Step screw (quantity) torque 1 not removable 4 kgcm 56 thinkpad 570 and 570e hardware maintena...

  • Page 61

    Removing and replacing a fru 1040 hard disk drive attention do not drop or apply any shock to the hard disk drive. The hard disk drive is sensitive to physical shock. Incorrect handling can cause damage and permanent loss of data. Before removing the drive, have the user make a backup copy of all th...

  • Page 62

    Removing and replacing a fru when removing the hard disk drive, open the lcd a little as shown in the figure. Attention be careful not to drop the hard disk drive. It is still attached to the cover when you push it up. 58 thinkpad 570 and 570e hardware maintenance manual.

  • Page 63

    Removing and replacing a fru 1050 keyboard battery pack (1010) hard disk drive (1040) (continued) step screw (quantity) torque 1 m2.5 x 9 mm (3) 4 kgcm thinkpad 570 and 570e 59.

  • Page 64

    Removing and replacing a fru 60 thinkpad 570 and 570e hardware maintenance manual.

  • Page 65

    Removing and replacing a fru 1060 center cover battery pack (1010) hard disk drive (1040) keyboard (1050) step screw (quantity) torque 1 m2.5 x 3 mm (2) 4 kgcm 2 m2.5 x 9 mm (1) 4 kgcm 3 m2.5 x 9 mm (1) 4 kgcm thinkpad 570 and 570e 61.

  • Page 66

    Removing and replacing a fru 1070 modem card battery pack (1010) hard disk drive (1040) keyboard (1050) center cover (1060) 62 thinkpad 570 and 570e hardware maintenance manual.

  • Page 67

    Removing and replacing a fru 1080 frame and power switch battery pack (1010) hard disk drive (1040) keyboard (1050) center cover (1060) (continued) step screw (quantity) torque 1 m2.5 x 3 mm (4) 4 kgcm thinkpad 570 and 570e 63.

  • Page 68

    Removing and replacing a fru step screw (quantity) torque 2 m2.5 x 4.8 mm (4) 4 kgcm 64 thinkpad 570 and 570e hardware maintenance manual.

  • Page 69

    Removing and replacing a fru 1090 audio card battery pack (1010) hard disk drive (1040) keyboard (1050) center cover (1060) modem card (1070) frame and power switch (1080) step screw (quantity) torque 4 m2.5 x 4.8 mm (1) 4 kgcm thinkpad 570 and 570e 65.

  • Page 70

    Removing and replacing a fru 1100 modem jack battery pack (1010) hard disk drive (1040) keyboard (1050) center cover (1060) modem card (1070) frame and power switch (1080) audio card (1090) step screw (quantity) torque 1 m2.5 x 4.8 mm (1) 4 kgcm 66 thinkpad 570 and 570e hardware maintenance manual.

  • Page 71

    Removing and replacing a fru 1110 speaker battery pack (1010) hard disk drive (1040) keyboard (1050) center cover (1060) modem card (1070) frame and power switch (1080) audio card (1090) for the thinkpad 570 computer (continued) step screw (quantity) torque 1 m2.5 x 4.8 mm (2) 4 kgcm thinkpad 570 an...

  • Page 72

    Removing and replacing a fru for the thinkpad 570e computer 68 thinkpad 570 and 570e hardware maintenance manual.

  • Page 73

    Removing and replacing a fru 1120 audio cable battery pack (1010) hard disk drive (1040) keyboard (1050) center cover (1060) modem card (1070) frame and power switch (1080) audio card (1090) when replacing: make sure you install the cable in the correct direction. Installing it the wrong direction w...

  • Page 74

    Removing and replacing a fru 1130 pc card slots battery pack (1010) hard disk drive (1040) keyboard (1050) center cover (1060) frame and power switch (1080) step screw (quantity) torque 1 m2.5 x 4.8 mm (1) 4 kgcm 70 thinkpad 570 and 570e hardware maintenance manual.

  • Page 75

    Removing and replacing a fru 1140 hard disk drive cable battery pack (1010) hard disk drive (1040) keyboard (1050) center cover (1060) frame and power switch (1080) for the thinkpad 570 computer (continued) step screw (quantity) torque 1 m2.5 x 4.8 mm (2) 4 kgcm thinkpad 570 and 570e 71.

  • Page 76

    Removing and replacing a fru for the thinkpad 570e computer (continued) step screw (quantity) torque 1 m2.5 x 4.8 mm (2) 4 kgcm 72 thinkpad 570 and 570e hardware maintenance manual.

  • Page 77

    Removing and replacing a fru when replacing: if the cable and cable shield are not installed correctly, they might be in the way when you install the hard disk drive. To install them correctly, do as follows: 1. Insert the tab of the cable 1 and catch the cable shield by the base cover latches 2 . 2...

  • Page 78

    Removing and replacing a fru 1150 upper shield battery pack (1010) hard disk drive (1040) keyboard (1050) center cover (1060) frame and power switch (1080) (continued) step screw (quantity) torque 2 m2.5 x 4.8 mm (3) 4 kgcm 3 m2 x 9 mm (4) 2 kgcm 74 thinkpad 570 and 570e hardware maintenance manual.

  • Page 79

    Removing and replacing a fru for the thinkpad 570 computer (continued) step screw (quantity) torque 6 m2.5 x 4.8 mm (3) 4 kgcm 7 m2 x 9 mm (3) yellow 2 kgcm thinkpad 570 and 570e 75.

  • Page 80

    Removing and replacing a fru for the thinkpad 570e computer step screw (quantity) torque 5 m2 x 9 mm (3) 4 kgcm 6 m2.5 x 4.8 mm (1) 4 kgcm 76 thinkpad 570 and 570e hardware maintenance manual.

  • Page 81

    Removing and replacing a fru 1160 fan battery pack (1010) hard disk drive (1040) keyboard (1050) center cover (1060) frame and power switch (1080) upper shield (1150) for the thinkpad 570 computer note: do not pinch the fan cable when re-installing the fan. Step screw (quantity) torque 1 m2 x 9 mm (...

  • Page 82

    Removing and replacing a fru for the thinkpad 570e computer when replacing: 1. Make sure not to pinch the fan cable when re-installing the fan. 2. Apply grease to the underside of the surface shown in the dotted square in the following figure: step screw (quantity) torque 1 m2.5 x 4.8 mm (2) 2 kgcm ...

  • Page 83

    Removing and replacing a fru 1170 lcd unit battery pack (1010) hard disk drive (1040) keyboard (1050) center cover (1060) frame and power switch (1080) (continued) step screw (quantity) torque 1 m2.5 x 4.8 mm (4) 4 kgcm thinkpad 570 and 570e 79.

  • Page 84

    Removing and replacing a fru step screw (quantity) torque 2 m2 x 9 mm (1) 4 kgcm 3 m2.5 x 4.8 mm (1) 4 kgcm 5 m2.5 x 4.8 mm (2) 4 kgcm 80 thinkpad 570 and 570e hardware maintenance manual.

  • Page 85

    Removing and replacing a fru 1180 system board assembly battery pack (1010) backup battery (1020) dimm (1030) hard disk drive (1040) keyboard (1050) center cover (1060) modem card (1070) frame and power switch (1080) audio card (1090) modem jack (1100) speaker (1110) audio cable (1120) pc card slots...

  • Page 86

    Removing and replacing a fru 1190 i/o connector cable or system board battery pack (1010) backup battery (1020) dimm (1030) hard disk drive (1040) keyboard (1050) center cover (1060) modem card (1070) frame and power switch (1080) audio card (1090) modem jack (1100) speaker (1110) audio cable (1120)...

  • Page 87

    Removing and replacing a fru thinkpad 570 and 570e 83.

  • Page 88

    Removing and replacing a fru 2010 lcd front bezel battery pack (1010) hard disk drive (1040) keyboard (1050) center cover (1060) frame and power switch (1080) lcd unit (1170) caution: the inverter card has a high tension current. To avoid shock hazard, never power on the computer when the lcd cover ...

  • Page 89

    Removing and replacing a fru 13.1-inch xga tft lcd step screw (quantity) torque 1 m2.5 x 3 mm (2) 4 kgcm thinkpad 570 and 570e 85.

  • Page 90

    Removing and replacing a fru 12.1-inch svga tft lcd step screw (quantity) torque 1 m2.5 x 3 mm (4) 4 kgcm 86 thinkpad 570 and 570e hardware maintenance manual.

  • Page 91

    Removing and replacing a fru 2020 inverter card battery pack (1010) hard disk drive (1040) keyboard (1050) center cover (1060) frame and power switch (1080) lcd unit (1170) lcd front bezel (2010) note: be careful of high voltage on the cable. Connect the lcd connector firmly to the inverter card by ...

  • Page 92

    Removing and replacing a fru 2030 lcd panel battery pack (1010) hard disk drive (1040) center cover (1060) lcd unit (1170) lcd front bezel (2010) inverter card (2020) 13.3-inch xga tft lcd (continued) step screw (quantity) torque 1 m2.5 x 3 mm (2) 4 kgcm 2 m2.5 x 3 mm (2) 4 kgcm 88 thinkpad 570 and ...

  • Page 93

    Removing and replacing a fru step screw (quantity) torque note 4 m2.5 x 3 mm (2) 4 kgcm blue, small head thinkpad 570 and 570e 89.

  • Page 94

    Removing and replacing a fru 12.1-inch svga tft lcd step screw (quantity) torque 1 m2.5 x 3 mm (4) 4 kgcm 90 thinkpad 570 and 570e hardware maintenance manual.

  • Page 95

    Removing and replacing a fru 2040 hinges battery pack (1010) hard disk drive (1040) keyboard (1050) center cover (1060) frame and power switch (1080) lcd unit (1170) lcd front bezel (2010) inverter card (2020) lcd panel (2030) 13.3-inch xga tft lcd: see “2030 lcd panel” on page 88. 12.1-inch svga tf...

  • Page 96

    Removing and replacing a fru 3010 blank bezel in the ultrabase in the ultraslimbay in the diskette-drive/battery bay 92 thinkpad 570 and 570e hardware maintenance manual.

  • Page 97

    Removing and replacing a fru battery pack in the ultrabase thinkpad 570 and 570e 93.

  • Page 98

    Locations locations front view 1 lcd panel 2 brightness control 3 built-in microphone 4 external diskette drive 5 diskette eject button 6 headphone jack 7 line-in jack 8 microphone jack 9 reset switch 1 pc card slots 11 pc card eject button 12 status indicator 13 trackpoint 14 click buttons 15 fn ke...

  • Page 99

    Locations thinkpad 570 and 570e 95.

  • Page 100

    Locations rear view 1 security keyhole 2 ac adapter jack 3 external-diskette-drive connector 4 serial connector 5 parallel connector 6 external-monitor connector 7 external-input-device connector 8 modem connector 96 thinkpad 570 and 570e hardware maintenance manual.

  • Page 101

    Locations bottom view 1 battery pack 2 battery release switch 3 built-in speaker 4 expansion connector 5 power switch 6 usb port 7 memory slot 8 hard disk drive 9 lcd latches thinkpad 570 and 570e 97.

  • Page 102

    Locations password pads 98 thinkpad 570 and 570e hardware maintenance manual.

  • Page 103

    Parts list parts list thinkpad 570 and 570e 99.

  • Page 104

    Parts list the parts marked with asterisk are cru (customer replacement unit). (continued) no. Fru p/n 1 lcd unit (see “lcd fru” on page 103.) 2 center cover, for 12.1-inch 05k6081 center cover (570), for 13.3-inch 05k6082 center cover (570e), for 13.3-inch 05k6096 3 keyboard (see “keyboard” on page...

  • Page 105

    Parts list (continued) no. Fru p/n for 570e, mt 2643 base cover 08k5683 base cover, for korea 08k5684 base cover, for china 08k5685 base cover, for taiwan 08k5686 for 570e, mt 2644 base cover 05k6286 base cover, for korea 05k6287 base cover, for china 05k6288 base cover, for taiwan 05k6289 13 dimm c...

  • Page 106

    Parts list no. Fru p/n screw kit (including nylon-coated screws): m2 x 4 mm, pan head (5) m2 x 9 mm, flat head (10) m2.5 x 3 mm, flat head (20) m2.5 x 4.8 mm, flat head (30) m2.5 x 9 mm, flat head (10) m2.5 x 3 mm, flat head small (5) m3 x 3 mm, flat head (5) hex stud d-sub (10) screw caps (10) scre...

  • Page 107

    Parts list lcd fru 13.3-inch xga tft (continued) thinkpad 570 and 570e 103.

  • Page 108

    Parts list no. Fru p/n lcd unit (dbu) 05k9506 lcd unit (hitachi) 05k9492 lcd rear cover kit for korea (570) 05k6456 lcd rear cover kit for korea (570e) 05k6455 1 lcd front bezel 05k6077 2 lcd panel (see lcd unit) 3 lcd rear cover 08k6454 4 hinges 08k5290 5 shield 08k6384 6 lcd cables 05k2836 7 lcd m...

  • Page 109

    Parts list 12.1-inch svga tft no. Fru p/n lcd unit 05k9505 lcd rear cover kit for korea 10l1909 1 lcd front bezel 05k6076 2 lcd panel (see lcd unit) 3 inverter card 10l1248 4 lcd rear cover 05k6074 5 hinges 05k6078 6 lcd miscellaneous parts kit 05k6080 7 lcd cables 27l0507 thinkpad 570 and 570e 105.

  • Page 110

    Parts list keyboard option list no. Fru p/n arabic 10l2208 belgian 10l2190 canadian french 10l2168 chinese, simplified 02k4875 chinese, traditional 10l2176 czech 10l2210 danish 10l2200 dutch 10l2188 french 10l2182 german 10l2180 hungary 10l2212 hebrew 10l2206 italian 10l2184 japanese 10l2172 korean ...

  • Page 111

    Parts list modem kit for australia 22l1939 for austria 22l1863 for belgium 22l1929 for denmark 22l1919 for france 22l1909 for germany 22l1911 for israel 22l1935 for italy 22l1915 for malaysia 27l0425 for netherlands 22l1917 for new zealand 22l1937 for norway or finland 22l1921 for portugal 22l1931 f...

  • Page 112

    Parts list common parts list tools triconnector wrap plug 72x8546 pc test card 35g4703 audio wrap cable 66g5180 usb parallel test cable 05k2580 screwdriver kit 95f3598 torque screwdriver 05k4695 5mm socket wrench 05k4694 screwdriver 27l8126 thinkpad hardware maintenance diskette version 1.60 note: d...

  • Page 113

    Parts list power cords: ibm power cords for a specific country are usually available only in that country: for 2-pin power cords: for 3-pin power cords: used in these countries p/n japan 13h5273 argentina 36l8870 used in these countries p/n argentina 36l8867 people's republic of china (other than ho...

  • Page 114

    Parts list 110 thinkpad 570 and 570e hardware maintenance manual.

  • Page 115

    Notices references in this publication to ibm products, programs, or services do not imply that ibm intends to make these available in all countries in which ibm operates. Any reference to an ibm product, program, or service is not intended to state or imply that only that ibm product, program, or s...

  • Page 116

    Part number: 09n8609 printed in u.S.A..