- DL manuals
- Ice-O-Matic
- Ice Maker
- CD10022
- Service & Installation Manual
Ice-O-Matic CD10022 Service & Installation Manual
Summary of CD10022
Page 1
Service/installation manual hotel/motel dispenser part number 80701101 print date: 6/00 gc series cuber shown cd10022 cd10522 ice series cuber shown cd20030 cd20530 ice-o-matic 11100 east 45th avenue denver, colorado, usa 80239.
Page 3: Cd10022
Cd10022 cd20030 cd10522 cd20530 introduction to the owner or user. This product is a source of information about the installation, start up, cleaning, maintenance and repair of the product. The cd10022, cd10522, cd20030 and cd20530 are ice-o-matics brand hotel/motel ice dispenser. The cd10022 is des...
Page 4: Cd10022
Cd10022 cd20030 cd10522 cd20530 specifications limitations: • must meet the same limitations as the cuber installed on top of it: • 50 o f air minimum • 100 o f air maximum • must be installed indoors • must allow space to the right for air intake when using air cooled machine. • the cd10022 and cd1...
Page 5: Cd10022
Cd10022 cd20030 cd10522 cd20530 installation: general after the carton has been removed from the dispenser, the legs may be installed. Place flat portions of the carton on the floor behind the dispenser and lay the dispenser down on its back. Thread the legs into the base of the dispenser. Be sure t...
Page 6: Cd10022
Cd10022 cd20030 cd10522 cd20530 installation: ice machine check that gasket tape has been placed at the outside edge of the dispenser top. Place corner posts from the carton on top of the dispenser, at the left and right corners. Place the ice machine onto the dispenser. The ice machine is heavy, us...
Page 7: Cd10022
Cd10022 cd20030 cd10522 cd20530 kits: coin mechanism kits are available to install a coin mechanism, a room key mechanism or a key card mechanism. All kits come with detailed instructions which are also listed below. Please follow these instructions carefully to complete the addition of the coin mec...
Page 8: Cd10022
Cd10022 cd20030 cd10522 cd20530 kits: coin mechanism 15. Replace the control box cover, front brace and decorative front cover. The dispenser should now be restored to service. 6.
Page 9: Cd10022
Cd10022 cd20030 cd10522 cd20530 key kit installation this kit has been designed for use with the cd10022, cd10522, cd20030 and cd20530 ice dis- penser. When this kit is installed, ice cannot be dis- pensed unless a specific type of key is inserted into the lock cylinder. The kit contains a universal...
Page 10: Cd10022
Cd10022 cd20030 cd10522 cd20530 key kit installation the operation of this kit is as follows: when the key is inserted into the lock cylinder, a portion of the key will extend beyond the brass fitting. It is this part of the key that will actuate the kit micro switch. Then when the dispense button s...
Page 11: Cd10022
Cd10022 cd20030 cd10522 cd20530 key card kit installation this kit has been designed for use with the cd10022, cd10522, cd20030 and cd20530 ice dispenser. When this kit is installed, ice cannot be dispensed unless a key card is inserted into the key card slot. The kit contains a universal mounting a...
Page 12: Cd10022
Cd10022 cd20030 cd10522 cd20530 key card kit installation the operation of this kit is as follows: when the key card is inserted into the key card slot, and the dispenser button switch is depressed and held, the machine will dispense ice.. 10
Page 13: Cd10022
Cd10022 cd20030 cd10522 cd20530 final check list/initial start up 11 1. Check that electrical power has been supplied. 2. Check that a drain, separate from the ice machine, insulated and made of rigid tubing, has been connected to the dispenser. 3. Check that the ice machine has been properly instal...
Page 14: Cd10022
Cd10022 cd20030 cd10522 cd20530 operational schematic 12.
Page 15: Cd10022
Cd10022 cd20030 cd10522 cd20530 cleaning general care and ceaning: periodically inspect and clean the ice dispenser to keep it operating at peak performance. Wash the outside of the dispenser with warm water and soap. Rinse off and dry. Cleaning and sanitizing of the ice storage bin: the minerals, c...
Page 16: Cd10022
Cd10022 cd20030 cd10522 cd20530 cleaning 10. Mix a solution of ice machine sanitixer and water: 1 ounce of household bleach to 2 gallons of (95 o f-115 o f) water. Wash all interior surfaces and the wheel withthe sanitizer solution. Use a clean cloth. 11. Allow the parts to air dry. 12.Reassemble wh...
Page 17: Cd10022
Cd10022 cd20030 cd10522 cd20530 service diagnosis leaks water bin drain leaks check bin drain connections and fittings check for clogged bin drain tubing coin mechanism does not vend, no ice check the above, plus coin switch 15 problem does not vend possible cause no ice probable fix check ice machi...
Page 18: Cd10022
Cd10022 cd20030 cd10522 cd20530 removal and replacement gear motor: 1. Disconnect electrical power. 2. Locate key and remove front panel. 3. Remove dispenser wheel. 4. Disconnect wires at gearmotor. 5. Remove 4 bolts securing gearmotor bracket to cabinet. 6. Pull gearmotor out of cabinet. 7. Remove ...
Page 19: Cd10022
Cd10022 cd20030 cd10522 cd20530 standard with room key kit or card kit electrical schematic 17.
Page 20: Cd10022
Cd10022 cd20030 cd10522 cd20530 standard with room key kit or card kit electrical schematic 18.
Page 21: Cd10022
Cd10022 cd20030 cd10522 cd20530 with coin mechanism electrical schematic 19.
Page 22
Service history model number: ______________ serial number: _____________ ____________________________ ____________________________ ____________________________ ____________________________ ____________________________ ____________________________ ____________________________ _______________________...