Icom IC-F161DS Servise Manual

Summary of IC-F161DS

  • Page 1

    S-14223hz-c1- w mar. 2008 vhf transceiver.

  • Page 2

    This service manual describes the latest service information for the ic-f3061/62/63/t/s, ic-f3161/62/63/t/s and ic-f3163dt/ds vhf transceiver at the time of publication. Never connect the transceiver to an ac outlet or to a dc power supply that uses more than 7.2 v. This will ruin the transceiver. D...

  • Page 3

    Contents section 1 specifications section 2 inside views section 3 disassembly instructions section 4 optional unit installation section 5 circuit descripiton 5-1 receiver circuits. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1 5-2 ...

  • Page 4: Section 1

    1 - 1 section 1 specifications [usa], [gen], [exp] [eur], [frg] general • frequency coverage 136–174 mhz • type of emission wide 16k0f3e (25.0 khz/30.0 khz) 16k0f3e (25.0 khz) [eur-01] middle – 14k0f3e (20.0 khz) [eur-01], [frg-01] narrow 11k0f3e, 11k0f7e/d* (15.0 khz) 8k50f3e, 8k10f1e/d* (12.5 khz)...

  • Page 5: Section 2

    2 - 1 section 2 inside views af power amplifier controller q501: 2sb1132 q502: xp6501 expander ic (ic506: m62320fp) expander ic (ic505: m62320fp) af power amplifier (ic508: tda8547ts) mic selector q506: unr9113j q516: unr9213j speaker selector (q512, q513: unr9213j) apc amplifier (ic601: ta75s01f) t...

  • Page 6: Section 3

    3 - 1 section 3 disassembly instruction • removing the chassis unit 1 unscrew 1 nut a , and remove 2 knobs b and c . 2 unscrew 2 screws d . 3 take off the chassis unit in the direction of the arrow. 4 disconnect the flat cable e form j501. 5 remove the seal f . 6 unscrew 2 nuts g and remove the plat...

  • Page 7

    4 - 1 section 4 optional unit installation caution! Optional unit installation should be done at authorized icom servise center only. The waterproof capability of the transceiver cannot be guaranteed if you install an unit yourself, or have it done at a non-authorised dealer/service center. A b c d ...

  • Page 8: Section 5

    Section 5 circuit description 5-1 receiver circuits 5-1-1 antenna switch (main and rf units) the received signals from the antenna connector are passed through the antenna switch which toggles the receive (rx) line and transmit (tx) line. The received signals from the antenna connector are passed th...

  • Page 9

    The tx/rx hpf filters out 250 hz and lower audio signals, and the de-emphasis circuit obtains –6 db/oct of audio characteristics. The expander expands the compressed audio signals and also noise reduction function is provided. The af signals are then level adjusted at the volume controller (vr4) and...

  • Page 10

    Power amp. Alc amp. Drive amp. + – hv “isens” • apc circuit to the anntena “t2” “tmut” from tx/rx switch (main unit; d14, d15) t5v q604, q605 q602 pre- drive amp. Q603 ic601 q601 to the receive circuits lpf lpf ant sw current detector d604 power detecter d605 q606 the output af signals are then pass...

  • Page 11

    Loop filter x1 15.3 mhz q2, d5–d8 rx vco2 (136–155 mhz) q1, d1–d4 rx vco1 (155–174 mhz) tx vco q3, d10–d12 pll control signals from the cpu (ic18) pll unlock signal to the cpu (ic18, pin 73) 15.3 mhz reference frequency signal • pll circuit buffer q4 buffer q6 buffer q5 to transmitter circuit to 1st...

  • Page 12

    5-5 port allocations 5-5-1 cpu (main unit; ic18) pin no. Port name description 1 dsda outputs serial data to the d/a converter (ic20, pin 6). 2 dast outputs strobe signal to the d/a converter (ic4, pin 6). 3 side3 input port for [side3] key (s4). "low"=when the key is pushed. 4−7 cbi0−3 input ports ...

  • Page 13: Section 6

    Section 6 adjustment procedures ▄ required test equipments equipment grade and range equipment grade and range adjustment software (rev. 1.1 or later) cs-f3060 adj (for f3060 series) cs-f3160/5060 adj (for f3160 series) jig cable modifi ed opc-966/u cloning cable fm deviation meter frequency range m...

  • Page 14

    6 - 2 fm deviation meter osciiloscope to the antenna connector attenuator 20 db or 30 db rf power meter 0.1–10 w/50 Ω frequency counter standard signal generator 0.1 µv to 32 mv (–127 dbm to –17 dbm) caution! Do not transmit while the ssg is connected to the antenna connector jig cable jig cable rs-...

  • Page 15

    6 - 3 note: the above values for settings are example only. Each transceiver has its own specific values for each setting. Adjustment setting transmit output power modulation balance modulation preset ctcss/dtcs deviation squelch reference frequency receive sensitivity rx lock voltage (low) rx lock ...

  • Page 16

    6 - 4 6-2 frequency adjustment select an adjustment item using [ ↑ ] / [ ↓ ] keys, then set to the specifi ed value using [ ← ] / [ → ] keys on the connected pc's keyboard. Adjustment adjustment condition measurement value unit operation pll lock voltage [rx lva1] 1 • channel • lock voltage preset [...

  • Page 17

    6 - 5 6-3 transmit adjustment select an adjustment item using [ ↑ ] / [ ↓ ] keys, then set to the specifi ed value using [ ← ] / [ → ] keys on the connected pc's keyboard. Adjustment adjustment condition measurement value unit operation output power [power (hi)] 1 • channel • transmitting : ch 6 top...

  • Page 18

    6 - 6 6-3 transmit adjustment (continued) select an adjustment item using [ ↑ ] / [ ↓ ] keys, then set to the specifi ed value using [ ← ] / [ → ] keys on the connected pc's keyboard. Adjustment adjustment condition measurement value unit operation ctcss/dtcs deviation [ctcss/dtcs] 1 • channel : ch ...

  • Page 19

    6 - 7 6-4 receive adjustment select an adjustment item using [ ↑ ] / [ ↓ ] keys, then set to the specifi ed value using [ ← ] / [ → ] keys on the connected pc's keyboard. Adjustment adjustment condition measurement value unit location receive sensitivity [bpf c all] note: "receive sensitivity" must ...

  • Page 20: Section 7

    7 - 1 section 7 parts list m.=mounted side (t: mounted on the top side, b: mounted on the bottom side) [front unit] (for f3060 series) ref parts description m. H/v no. No. Location ic501 1180002401 s.Reg s-812c30amc-c2k-g b 66.7/35.7 ic505 1110006440 s.Ic m62320fp df5j b 74/36.8 ic506 1110006440 s.I...

  • Page 21

    7 - 2 m.=mounted side (t: mounted on the top side, b: mounted on the bottom side) [front-a unit] (for f3160 series) ref parts description m. H/v no. No. Location ic501 1180002401 s.Reg s-812c30amc-c2k-g b 66.7/35.7 ic505 1110007330 s.Ic m62320fp-df5g b 74/36.8 ic506 1110007330 s.Ic m62320fp-df5g b 5...

  • Page 22

    7 - 3 m.=mounted side (t: mounted on the top side, b: mounted on the bottom side) [main unit] (for f3060 series) ref parts description m. H/v no. No. Location ic1 1130010100 s.Ic lmx2352tmx/nopb b 58.2/18.3 ic3 1110003491 s.Ic ta31136fng (d,el) b 76.6/32.9 ic4 1190001350 s.Ic m62364fp 600d b 42.1/18...

  • Page 23

    7 - 4 m.=mounted side (t: mounted on the top side, b: mounted on the bottom side) [main unit] (for f3060 series) ref parts description m. H/v no. No. Location r63 7030005090 s.Res erj2gej 104 x (100 k) t 102.7/17.4 r64 7030005310 s.Res erj2gej 124 x (120 k) t 103.9/15.7 r65 7030008280 s.Res erj2gej ...

  • Page 24

    7 - 5 m.=mounted side (t: mounted on the top side, b: mounted on the bottom side) [main unit] (for f3060 series) ref parts description m. H/v no. No. Location r294 7030007280 s.Res erj2gej 331 x (330) b 91.4/33 r295 7030005710 s.Res erj2gej 121 x (120) t 89.9/22.5 r296 7030005090 s.Res erj2gej 104 x...

  • Page 25

    7 - 6 m.=mounted side (t: mounted on the top side, b: mounted on the bottom side) [main unit] (for f3060 series) ref parts description m. H/v no. No. Location c224 4030017790 s.Cer ecj0eb1e682k b 66/35.4 c225 4030016940 s.Cer ecj0eb1a393k b 66.5/38.4 c226 4550006250 s.Tan teesva 1a 106m8r b 41.2/39....

  • Page 26

    7 - 7 m.=mounted side (t: mounted on the top side, b: mounted on the bottom side) [main-a unit] (for f3160 series) ref parts description m. H/v no. No. Location ic1 1130010100 s.Ic lmx2352tmx/nopb b 58.2/18.3 ic3 1110003491 s.Ic ta31136fng (d,el) b 76.6/32.9 ic4 1190001350 s.Ic m62364fp 600d b 42.1/...

  • Page 27

    7 - 8 m.=mounted side (t: mounted on the top side, b: mounted on the bottom side) [main-a unit] (for f3160 series) ref parts description m. H/v no. No. Location r90 7030005040 s.Res erj2gej 472 x (4.7 k) b 70.4/26.4 r91 7030005040 s.Res erj2gej 472 x (4.7 k) b 66/27.9 r95 7030005090 s.Res erj2gej 10...

  • Page 28

    7 - 9 [main-a unit] (for f3160 series) ref parts description m. H/v no. No. Location r330 7030007340 s.Res erj2gej 153 x (15 k) t 55.6/34.9 r331 7030007340 s.Res erj2gej 153 x (15 k) t 47.2/16 r333 7030005090 s.Res erj2gej 104 x (100 k) t 16.6/31 r334 7030007340 s.Res erj2gej 153 x (15 k) b 34.2/38....

  • Page 29

    7 - 10 m.=mounted side (t: mounted on the top side, b: mounted on the bottom side) [main-a unit] (for f3160 series) ref parts description m. H/v no. No. Location c216 4030017740 s.Cer ecj0eb1e821k b 75.9/36.6 c217 4030017730 s.Cer ecj0eb1e471k b 74.1/36.6 c217 4030017740 s.Cer ecj0eb1e821k b 74.1/36...

  • Page 30

    7 - 11 m.=mounted side (t: mounted on the top side, b: mounted on the bottom side) [main-a unit] (for f3160 series) ref parts description m. H/v no. No. Location ep1 6910015370 s.Bea acz1005y-102-t b 53.5/22.5 ep3 6910015370 s.Bea acz1005y-102-t b 45.5/36.8 ep4 6910015600 s.Bea acz1005y-241 (240) b ...

  • Page 31

    7 - 12 m.=mounted side (t: mounted on the top side, b: mounted on the bottom side) [rf unit] ref parts description m. H/v no. No. Location c606 4030007060 s.Cer c1608 ch 1h 270j-t b 28.1/11.7 c608 4030009540 s.Cer c1608 ch 1h 1r5b-t b 27.7/17.8 c609 4030007020 s.Cer c1608 ch 1h 120j-t b 25.5/11.7 c6...

  • Page 32

    7 - 13 [main unit] ref order description m. H/v no. No. Location • bc-160 (optional) [main unit] ref order description m. H/v no. No. Location m.=mounted side (t: mounted on the top side, b: mounted on the bottom side) s.=surface mount ic1 1110006480 s.Ic njm2801u1-0543-te1 b 10.2/62.3 ic2 111000307...

  • Page 33: Section 8

    8 - 1 section 8 mechanical parts screw abbreviations b0, bt: self-tapping ph: pan head ft: flat head zk: black sus: stainless ni-zu: nickel-zinc [chassis parts] j1 6910015910 ant connector 104 1 j2 6910015860 imsa-6277s-o2a-g 1 sp1 2510001360 k036nax040a00-55 1 w1 8900014981 opc-1589-1 1 w2 89000149...

  • Page 34

    [accessories] ep1 † – fa-sc55v-2 1 ep2 † – bp-232n 1 mp1 † – mb-94 1 mp2 8210021471 2803 side panel-1 1 mp3 8810010430 screw truss m3x5 sus ssbc 1 parts no. Ref. No. Description qty. [rf unit] j601 6910017940 imsa-9230b-1-05z118-pt1 1 j602 6910017940 imsa-9230b-1-05z118-pt1 1 f601* 5210000970 erbse3...

  • Page 35

    8 - 2 mp26 (c) mp32 (c) mp31 (c) mp8 (c) w1 (c) mp10 (c) mp2 (c)* * mp2 (c), mp12 (c): the shape is depending on the version. Mp22 (c) mp802 (j) mp801(j) mp23 (c) mp24 (c) mp20 (c) mp20 (c) mp18 (c) mp19 (c) mp12 (c)* mp41 (c) mp4 (c) mp1 (c) mp30 (c) mp29 (c) s701 (v) r704 (v) mp35 (c) j602 (rf) j6...

  • Page 36

    9 - 1 section 9 board layouts c559 ds501 ds502 ds503 ds504 ds505 ds506 ds507 ds508 ds509 mc501 h0 h5 h10 h15 h20 h25 h30 h35 h40 h45 h50 h55 h60 h65 h70 h75 h80 h85 h90 h95 h100 v0 v5 v10 v15 v20 v25 v30 v35 v40 c613 c614 c615 c618 c619 c626 c627 c628 c630 c631 c637 c644 c645 c647 c649 c653 c654 c65...

  • Page 37

    9 - 2 c501 c502 c506 c507 c508 c509 c510 c511 c514 c515 c517 c518 c519 c520 c522 c523 c524 c525 c526 c527 c528 c529 c530 c531 c532 c534 c535 c536 c537 c538 c539 c540 c541 c542 c543 c544 c560 c561 c563 d502 d503 d504 d505 d506 d508 ic501 ic505 ic506 ic508 ic509 j501 j502 j503 mp505 q501 q502 q505 q50...

  • Page 38

    9 - 3 c613 c614 c615 c618 c619 c626 c627 c628 c630 c631 c637 c644 c645 c647 c649 c653 c654 c655 c656 c657 c658 c659 c660 c661 d601 d604 d606 d607 f601 ic601 j601 j602 l605 l613 q604 q605 q606 r601 r604 r605 r606 r607 r608 r610 r611 r622 r623 r624 r625 r626 r627 r628 r629 r631 b6419d h0 h5 h10 h15 h2...

  • Page 39

    9 - 4 c601 c602 c604 c605 c606 c608 c609 c610 c611 c612 c616 c617 c620 c622 c623 c624 c629 c632 c633 c634 c635 c638 c639 c640 c642 c643 c646 c648 c650 c651 c662 c663 c664 c665 c666 c667 d603 d605 ep602 l601 l602 l603 l604 l606 l607 l608 l609 l610 l611 l612 mp601 q601 q602 q603 r603 r609 r613 r614 r6...

  • Page 40

    10 - 1 section 10 block diagram front/front-a unit rf unit main/main-a unit explanatory notes fm if ic jack unit vr unit ic501 s-812c30amc ds510 m4-0078tay-2 lcd expand mcon pttsw ptt sw pwr ctrl afono afon vcc ptti eptt expand d505/d506 dap222 sp/esp sw q512 unr9213j q513 unr9213j ic509 njm12904v i...

  • Page 41

    *; refer to “parts list.” 11 - 1 section 11 voltage diagram key s508 0 r518 sml-310m t ds508 23/00/025/w02/w02 w502 imsa-9631s-20a-tb j501 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 ma2s111 d504 47 r535 4.7k r558 s-812c30amc ic501 1 gnd 2 vin 3 vout 4 nc 5 nc key s507 dtb123ek q509 unr...

  • Page 42

    11 - 2 *; refer to “parts list.” ma8110 d509 15k r543 47p c556 100k r529 4.7k r558 470 r531 imsa-9631s-20a-tb j501 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 0.0033 c560 100k r570 100k r523 100k r567 100k r552 23/00/025/w02/w02 w502 100k r527 key s513 dap222 d506 390p c540 4.7k r560 47...

  • Page 43

    11 - 3 10 r243 4.7k r89 15k r11 0.001 c349 3.3k r133 1sv284 d6 *r334 0.001 c167 24k r169 0. 1 c10 100k r152 0.001 c63 skhllfa010 s3 68n l13 3.3k r119 1.2k r110 2sc4116 q17 10k r231 0.0022 c256 3.3k r304 0.01 c279 4.7k r9 0 hvc376b d12 1m r318 ma 2 s 1 1 1 d25 0.01 c347 2sa1577 q14 10k r62 2sc510 7 q...

  • Page 44

    11 - 4 • main-a unit (for f3160 series) /wvg /wvg acz1005y ep 5 s-80942cnmc ic8 1 out 2 vdd 3 vss 4 nc 5 cd 100k r383 56n l34 10 r66 m62364fp ic4 1 vin1 2 vout1 3 vout2 4 vin2 5 vdd 6 ld 7 clk 8 di 9 vin3 10 vout3 11 vout4 12 vin4 13 vin5 14 vout5 15 vout6 16 vin6 17 do 18 vdaref 19 reset 20 gnd 21 ...

  • Page 45

    11 - 5 4.7k r604 33k r616 0.001 c655 4.7k r614 0.001 c620 0.001 c626 220k r608 0.001 c640 0.001 c649 100k r613 4.7k r617 0.001 c613 56p c623 0.001 c610 0.01 c627 1k r624 0.5p c618 2sc4081 q605 470p c635 0.001 c634 47p c659 100k r601 0.001 c654 cp06s cp602 0.001 c631 47p c644 0.001 c619 0.001 c657 0....

  • Page 46

    12 - 1 section 12. Bc-160 (optional) [chassis parts] mp1 8010019750 2830 case 1 mp2 8110008220 2830 cover 1 mp3 8930039620 leg cushion (a) 2 mp4 8810008630 screw ph bt m3 × 6 ni-zu 1 order no. Ref. No. Description qty. [main unit] j1 6510023070 connector hec2305-01-250 1 ds1 5040002740 led rt3-03hry...

  • Page 47

    6f no.68, sec. 1 cheng-teh road, taipei, taiwan, r.O.C. Phone : +886 (02) 2559 1899 fax : +886 (02) 2559 1874 url : http://www.Asia-icom.Com e-mail : sales@asia-icom.Com zac de la plaine 1 rue brindejonc des moulinais bp 5804 31505 toulouse cedex, france phone : +33 (5) 61 36 03 03 fax : +33 (5) 61 ...

  • Page 48

    1-1-32, kamiminami, hirano-ku, osaka 547-0003, japan s-14223hz-c1- w © 2006–2008 icom inc..