ICON 100 Series Owner's Manual - page 2
ATTENTION! Use caution when cooking, as grill surfaces get hot. To avoid
burns, always use protective gloves to adjust top and bottom vents when
grill is in use. Do not wear loose clothing near the grill.
ATTENTION! This barbecue will become very hot, do not move it during
operation. For outdoor cooking use only. Do not operate grill indoors or in
an enclosed space. Use grill only in well-ventilated areas. Keep immediate
area around the grill free from combustible materials. Allow for at least
3 feet/1 meter of clearance around grill (house, other outdoor products,
hanging tree limbs, shrubs, etc.)
WARNING! Keep children and pets away from the grill at all times.
Do not allow children to operate grill. Never leave grill unattended when
in use.
Grill should be placed securely on a level base prior to use. Only operate
grill on a hard, stable, level surface (concrete patio, ground, etc.) capable
of supporting the weight of the grill when loaded with food. Never
operate grill on wood support surface, wood deck or like combustible
support surfaces. Never attempt to move grill when in operation or
cooling down. Never operate this grill within 25 feet/7.5 meters of any
flammable liquid. Never operate this grill within 10 feet/3 meters of a gas
cylinder. The grill should not be placed under combustible structures, like
garages, porches, patios, or carports. Burning charcoal produces carbon
monoxide, an odorless gas, which can cause death.
The use of alcohol, prescription or non-prescription drugs may impair the
operator’s ability to properly assemble or safely operate the grill.
Do not use on boats or recreational vehicles.
CAUTION: Never use lighter fluid, gasoline, or other volatiles to start your
charcoal, as it is dangerous and will leave a residual taste in your food. Use
only firelighters complying to EN 1860-3. Use utmost care when adding
charcoal to grill. Dispose of cooled ash by placing it in aluminum foil,
soaking with water and discarding in a non-combustible container. Always
wait for grill to completely cool before opening built-in ash drawer.
When cooking above 500ºF/260ºC, with both top and bottom vents
closed, rapidly opening the lid creates a sudden rush of oxygen into
the grill, which can cause a flare-up. When in this cooking mode, we
recommend that, prior to opening the lid, you open top and bottom
vents to allow oxygen to stabilize inside the grill, minimizing the possibility
of a flare-up.
www.icongrills.com help@icongrills.com 1-877-917-4273
Icon Grills 1531 Fairview Avenue, Suite B, St. Louis, MO 63132
Step 1: Assemble Top Lid Vent
Close lid and press Top Vent
onto top of Kamado. Be sure
spring clips are fully engaged
with calibrations facing the
front of the grill.
Step 3: Insert Grill into Stand
Take all parts out of the grill before
lifting. With the help of a second
person, lower the grill into the Stand
by holding the back hinge and
bottom of grill. As grill is lowered
into stand, carefully switch out hands
from bottom of grill to the ash drawer
opening before reaching the outer
ring of stand. Completely lower grill
to bottom of stand.
Step 4: Add Components to Grill
Lower fire bowl into the grill with
the ash drawer opening facing the
front of the grill. Place cast iron
Charcoal Grate inside fire bowl.
Place stainless steel cooking grate
on top of the fire bowl.
Step 5: Grill Handle Assembly
Attach the Handle by placing
handle bracket over studs,
opposite the hinge. On each
stud use flat washers, then screw
on acorn nuts and tighten with
provided wrench.
Step 6: Ash Drawer Usage
Slide Ash Drawer into ash
drawer opening. When grill is
cool, it is safe to remove ash
from Ash Drawer. To remove
Ash Drawer, use bottom knob
on Ash Drawer, lift slightly and
pull drawer out.
Step 2: Stand Handle Assembly
Attach Stand Handles
to the left and right of
the Stand by placing
handle brackets over
stand studs. On each
stud use flat washers,
then screw on acorn
nuts and tighten with
provided wrench.