1. DL manuals
  2. ICOP Technology
  3. Motherboard
  4. ICOP-6036E
  5. User Manual

ICOP Technology ICOP-6036E User Manual

Summary of ICOP-6036E

  • Page 1

    Icop-6036ve/6036e embedded 5x86 3.5"-size all-in-one cpu board series user’s manual (version 3.3).

  • Page 2

    Ii copyright notice this document is copyrighted, 2000 by icop technology inc. All rights are reserved. The information in the manual is subject to change without notice in order to improving products. No part of this manual may be reproduced, copied, translated or transmitted in any form or by any ...

  • Page 3

    Iii t a b l e o f c o n t e n t s c h a p t e r 0 startup 0.1 packing list .............................................................. 1 0.2 specifications ........................................................... 2 0.3 component location ................................................. 3 c h ...

  • Page 4: Warranty

    Iv 4.1 introduction..............................................................31 4.2 software support .....................................................32 appendix pin assignments ide interface connector ................................................... 34 vga/flat panel connectors ............

  • Page 5: C H A P T E R  0

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 1 c h a p t e r 0 startup 0.1 packing list product name function package icop-6036e embedded 5x86 3.5"-size all-in- one cpu board icop-6036e embedded 5x86 3.5"-size all-in-one cpu board utility and drivers diskette x 2 fdd cable x 1 hdd cable ...

  • Page 6: 0.2 Specifications

    2 icop embedded 5x86 3.5"-size aio cpu board user's manual 0.2 specifications features icop-6036e icop-6036ve chipset sgs stpc client, 66/75 mhz processor 5x86 cpu on-die multi i/o chip winbond w83977f-a, ali 5113 bios ami bios watchdog timer from 1 to 64 seconds bus interface pc/104 standard compli...

  • Page 7: 0.3 Component

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 3 0.3 component location icop-6036/6036ve ps/2 keyb. Ethernet rj-45 com4/3/2/1 rs-485 +5v gnd p8 power cont. Eide port fdd port flat panel crt svga parallel port keyb. Cont..

  • Page 8: C H A P T E R  1

    4 icop embedded 5x86 3.5"-size aio cpu board user's manual c h a p t e r 1 introduction 1.1 features 3.5’’-size (144x102 mm) embedded cpu module pc/104 connector sgs stpc client 5x86 processor with fpu unit crt and flat panel display interface 8mb edo ram onboard and up to 16mb by expansion enhanced...

  • Page 9: 1.2 Specifications

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 5 1.2 specifications chipset: sgs st pc client, 66/75mhz, 64-bit internal architecture x86 processor with fpu unit enhanced ide, scatter/gather and multi-word dma data bus: 16-bit bus speeds: isa - 8.3 mhz, pc/104 - 8.3 mhz dma channels: 7 int...

  • Page 10

    6 icop embedded 5x86 3.5"-size aio cpu board user's manual 34-pin box header for floppy disk drive 40-pin box header for enhanced ide 6-pin p8 power connector one socket for flash rom or diskonchip rj-45 connector for 10/100base-t display: (icop-6036ve) • chipset: c&t chips 69000 • memory: 2mb integ...

  • Page 11: 1.3 Vga

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 7 1.3 vga interface (icop-6036e) the stpc integrates a full vga controller with extended functions together with an output color digital to analog (ramdac) and a graphics engine. The vga controller provides the basic video display function. It...

  • Page 12

    8 icop embedded 5x86 3.5"-size aio cpu board user's manual high speed sdram into the chip. The 69000 is the first member of the hiqvideo family to integrate high speed sdram frame buffer memory into the chip. Using leading edge embedded memory logic technologies, the 69000 integrates 2 mbytes of sdr...

  • Page 13

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 9 1.4 diskonchip 2000 flash disk flash disk diskonchip ® 2000 • package: single chip flashdisk in 32-pin dip jedec • capacity: 1-144 mbyte capacity • data reliability: ecc/edc error correction • memory window: 8 kbyte.

  • Page 14: 1.5 Network

    10 icop embedded 5x86 3.5"-size aio cpu board user's manual 1.5 network interface • chipset: realtek 8139bl single chip • type: 10/100base-t • connectors: onboard rj-45 connectors • monitoring leds: network ready indicator, network activity indicator • compatibility: ne2000

  • Page 15: C H A P T E R  2

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 11 c h a p t e r 2 installation 2.1 jumper settings icop-6036/6036ve kb1 j1 rj45 cont9/8/6/com1 cont5 j6 cont10 cont4 ide1 j5 cont7 cont1 p1 j2 j3 jp1 jp3 jp2 jp7/jp6 jp8.

  • Page 16: 2.1.1 Icop-6036Ve

    12 icop embedded 5x86 3.5"-size aio cpu board user's manual 2.1.1 icop-6036ve jp1 cpu clock speed 1-2 3-4 5-6 7-8 75 open open open close 66 open close close close 60 open close open close 50 open close close close 25 close open open close jp2 ide led jp3 rs-232/485 selection 1-2: rs-232 2-3: rs485 ...

  • Page 17: 2.1.2 Icop-6036E

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 13 com4: 4-5 : irq3 5-6 : irq11 j3 reset switch j6 ps/2 mouse irq12 select close: enabled open: disabled 2.1.2 icop-6036e jp1 cpu clock speed 1-2 3-4 5-6 7-8 75 open open open close 66 open close close close 60 open close open close 50 open cl...

  • Page 18

    14 icop embedded 5x86 3.5"-size aio cpu board user's manual j3 reset switch j6 ps/2 mouse irq12 select close: enabled open: disabled.

  • Page 19: 2.2 Connectors

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 15 2.2 connectors 2.2.1 icop-6036ve cont1 external d-type crt vga display connector cont2 40-pin pc/104 bus cont3 64-pin pc/104 bus cont4 p8 power connector cont5 2-pin com2 rs-485 molex connector cont6 10-pin box header connector for com2 rs-...

  • Page 20

    16 icop embedded 5x86 3.5"-size aio cpu board user's manual cont8 10-pin box header connector for com3 rs-232 cont9 10-pin box header connector for com4 rs-232 cont10 +5v power connector j1 5-pin ps/2 connector j2 5-pin keyboard connector j5 fdd connector ide1 ide connector kb1 external ps/2 and at ...

  • Page 21: 2.3.1 Setup A Diskonchip

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 17 2.3 diskonchip/flash rom disk 2.3.1 setup a diskonchip ® 2000 flash disk installation instructions 1. Make sure the icop-6026ve is powered off 2. Plug the diskonchip 2000 device(s) into its socket. Verify the direction is correct (pin 1 of ...

  • Page 22

    18 icop embedded 5x86 3.5"-size aio cpu board user's manual 2.3.2 setting up a flash disk before you can use the icop-6026ve’s flash disk you will have to initialize it using a software utility called “pc104.Exe”. This program can be found on the utility disk in the subdirectory “a:\flash” - connect...

  • Page 23: 2.4 Watchdog

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 19 2.4 watchdog timer the onboard watchdog timer can be disabled or enabled by software for either reboot by reset. Upon boot the watchdog timer is always disabled. Initialize and start the watchdog timer enable the sqw (square wave) output th...

  • Page 24

    20 icop embedded 5x86 3.5"-size aio cpu board user's manual to write for example : d3 = enable d2,d1,d0 = 1 second : out f2h,00001110b refresh the watchdog timer to refresh the watchdog timer simply reading the value at f2 (hex) is enough. In al,f2h programming structure step1 out 70h,0bh (enable sq...

  • Page 27: 2.5  General Purpose I/o

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 23 2.5 general purpose i/o m6117d supports 16 independent gpos and gpis. This group of gpos does not need external 74ls373 to latch as generate purpose output. Also this group of gpis do not share signals with the isa data bus, so no external ...

  • Page 28

    24 icop embedded 5x86 3.5"-size aio cpu board user's manual ; of in direction. Mov al,47h ; output data port. Out 22h,al ; mov al,55h ; example data out value is 55h, ; to output pin out 23h,al ; gpio[7-0]. So user can ; repeat this loop. Mov al,46h ; if gpio[7-0] is set input direction, then data o...

  • Page 29: C H A P T E R  3

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 25 c h a p t e r 3 svga setup 3.1 introduction the icop-6036ve has an on-board vga/lcd interface. The specifications and features are described as follows: the icop-6036e has an on-board vga interface. The specifications and features are descr...

  • Page 30

    26 icop embedded 5x86 3.5"-size aio cpu board user's manual must follow the flow chart instructions and pay attention to the instructions which then appear on your screen..

  • Page 31

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 27 3.2.1 installation for windows 3.1 1. A. Insert the cd/disk into the cd-rom/ fdd drive. B. Select "main" in program manager. C. Double click the "windows setup" icon. D. Select "change system setting" in options. E. Select "other display (r...

  • Page 32

    28 icop embedded 5x86 3.5"-size aio cpu board user's manual 9. A. Restart windows..

  • Page 33

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 29 3.2.2 installation for windows 95/98 1. A. Select "start" , "settings" , "control panel" , "display" , "settings". B. Press "advanced properties". 2. A. Choose the "adapter" label. B. Press the "change..." button. 3. A. Press the "have disk...

  • Page 34

    30 icop embedded 5x86 3.5"-size aio cpu board user's manual 9. A. Click the "uma config" label. B. Adjust the refresh rate and display type. C. Press "ok" to exit. 10. A. Press "yes" to set set the monitor type. 11. A. Select "standard", "super vga 800 x 600", or "xga". B. Press the "ok" button. 12....

  • Page 35: C H A P T E R  4

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 31 c h a p t e r 4 network interface 4.1 introduction the realtek rtl8139b(l) is a highly integrated and cost-effective single- chip fast ethernet controller that provides 32-bit performance, pci bus master capability, and full compliance with...

  • Page 36: 4.2 Software

    32 icop embedded 5x86 3.5"-size aio cpu board user's manual rtl8139b(l) can be shut down temporarily according to the user’s requirement or when the rtl8139b(l) is in power down states with the wakeup function disabled. Besides, when the analog part is shut down and the isolateb pin is low (i.E. The...

  • Page 37

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 33 netware 16-bit odi driver for dos, os/2 and 32-bit odi driver for netware 3.X, 4.X, 5.0 server packet driver for unix client sco unix driver linux driver freebsd unixware 7.0 help utility for easy installation support dmi rpl boot rom for n...

  • Page 38: Appendix

    34 icop embedded 5x86 3.5"-size aio cpu board user's manual appendix pin assignments ide interface connector pin description pin description 1 reset 2 gnd 3 data 7 4 data 8 5 data 6 6 data 9 7 data 5 8 data 10 9 data 4 10 data 11 11 data 3 12 data 12 13 data 2 14 data 13 15 data 1 16 data 14 17 data...

  • Page 39: Vga/flat Panel Connectors

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 35 vga/flat panel connectors flat panel connector pin assignment (50 pin for all icop 5x86 series) pin description pin description 1 +12v 2 +12v 3 gnd 4 gnd 5 pvcc 6 enavdd 7 enavee 8 gnd 9 p0 10 p1 11 p2 12 p3 13 p4 14 p5 15 p6 16 p7 17 p8 18...

  • Page 40

    36 icop embedded 5x86 3.5"-size aio cpu board user's manual description for pin of flat panel connector name description p0~p23 flat panel data output enabkl activity indicator and enable backlight outputs shfclk shift clock. Pixel clock for flat panel data m m signal for panel ac drive control lp l...

  • Page 41: Floppy Disk Connector

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 37 floppy disk connector pin description pin description 1 gnd 2 drive enable select 3 gnd 4 n/c 5 gnd 6 n/c 7 gnd 8 index # 9 gnd 10 drive select 0 11 gnd 12 drive select 1 13 gnd 14 drive select 2 15 gnd 16 motor enable 17 gnd 18 direction #...

  • Page 42: Parallel Port Interface

    38 icop embedded 5x86 3.5"-size aio cpu board user's manual parallel port interface pin description pin description 1 strobe 2 data 0 3 data 1 4 data 2 5 data 3 6 data 4 7 data 5 8 data 6 9 data 7 10 acknowledge # 11 busy 12 paper empty # 13 printer select 14 auto form feed # 15 error # 16 initializ...

  • Page 43: Serial Port Interface

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 39 serial port interface 10- pin d-type description 1 1 data carrier detect (dcd)/5v/12v 2 2 receive data (rxd) 3 3 transmit data (txd) 4 4 data terminal ready (dtr) 5 5 ground (gnd) 6 6 data set ready (dsr) 7 7 request to send (rts) 8 8 clear...

  • Page 44

    40 icop embedded 5x86 3.5"-size aio cpu board user's manual keyboard and ps/2 mouse connector clock data no connection gnd power 1 2 5 4 3 clock data no connection gnd power 1 2 5 4 3 note for keyboard: pin1: kbclk pin2: kbdata note for mouse: pin1: mclk pin2: mdata.

  • Page 45: Pc/104 Connectors

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 41 pc/104 connectors 64-pin long connector pin no. Pin name pin no. Pin name 1 iochchk * 2 0v 3 sd7 4 resetdrv 5 sd6 6 +5v 7 sd5 8 irq9 9 sd4 10 -5v 11 sd3 12 drq2 13 sd2 14 -12v 15 sd1 16 endxfr * 17 sd0 18 +12v 19 iochrdy 20 (key) 21 aen 22 ...

  • Page 46

    42 icop embedded 5x86 3.5"-size aio cpu board user's manual 40-pin short connector pin no. Pin name pin no. Pin name 1 0v 2 0v 3 memcs16 * 4 sbhe * 5 iocs16 * 6 la23 7 irq10 8 la22 9 irq11 10 la21 11 irq12 12 la20 13 irq15 14 la19 15 irq14 16 la18 17 dack0 * 18 la17 19 drq0 20 memr * 21 dack5 * 22 m...

  • Page 47: Warranty

    Icop embedded 5x86 3.5"-size aio cpu board user's manual 43 warranty this product is warranted to be in good working order for a period of one year from the date of purchase. Should this product fail to be in good working orderat any time during this period, we will, at our option, replace or repair...