Intermatic IG3240RC Installation Instructions

MODEL IG3240RC

INSTALLATION INSTRUCTIONS

(FIG.1)

CAUTION

Electricity is dangerous; follow safety rules. Never work on equipment with the

electricity turned “ON”. Be absolutely certain the power is turned “OFF” to the

circuit or device you are installing. Be sure you read and understand all of these

installation steps before you begin to install this Surge Protection Device. For

your protection, check and follow your local electrical codes. Do not touch 

electric circuits or devices when you are wet or standing on a wet surface. Use

a circuit tester or AC voltmeter to be sure the electricity is “OFF” before you

touch wires or devices. This device is suitable for use on a circuit capable of

delivering not more than 25,000 rms symmetrical ampers, 240 volts maximum.

NOTE:

ELECTRICAL GROUND IS REQUIRED FOR THIS UNIT TO

FUNCTION PROPERLY AND SAFELY!

STEP 1

Select a mounting location for the Surge Protection Device (SPD) which will

allow convenient connection to the panel while keeping the lead wires as

short as possible. Use an AC voltmeter or circuit tester across two breaker

outputs to confirm that there is 240 volts between them. If the voltage is 0,

select a different breaker of equal amperage.

OPERATION

Both green indicator lights will be ON when power is present and the IG3240RC 

is operating properly. If one of the indicator lights is OFF, check the breakers to

make sure that both are on and not tripped. If one or both of the green indicators

are OFF, and the red indicator is on, the IG3240RC is no longer protecting.

Replace the unit.

TEN YEAR PRODUCT WARRANTY

SURGE PROTECTION DEVICES

If within ten (10) years from the date of purchase, this surge protection device 

fails due to defect in material or workmanship, Intermatic Incorporated will repair

or replace it free of charge. The warranty does not apply to: (a) damage caused

by accident, abuse, mishandling, dropping; (b) units which have been subject to

unauthorized repair, opened, taken apart; (c)  units not used in accordance with

directions; (d) damages exceeding the cost of the product. Some states do not 

allow a limitation of damages, so the foregoing limitations may not apply to you. 

This warranty gives you specific legal rights and you may also have other rights 

which vary from state to state. This warranty service is available by either (a) 

returning the product to the dealer from whom the unit was purchased, or 

(b) contacting Intermatic at 1-800-270-7227.

For complete information regarding the Warranty on this product, refer to the

enclosed form, “TEN YEAR LIMITED PRODUCT

and CONNECTED 

EQUIPMENT WARRANTY for INTERMATIC Panel Guard Model IG3240RC

SURGE PROTECTION DEVICE”.

INTERMATIC INCORPORATED

SPRING GROVE, ILLINOIS 60081-9698

HTTP: WWW.INTERMATIC.COM

158IG11205