- DL manuals
- J. A. Roby
- Stove
- CUISINIERE
- Owner's Manual
J. A. Roby CUISINIERE Owner's Manual
Summary of CUISINIERE
Page 1
490, rue de l'argon québec (québec) g2n 2c9 phone: 418-849-8095 fax : 418-849-0077 www.Jaroby.Com april 18, 2012 reviewed cuisiniere - tison wood stove certified and tested according to can/csa std b415.1-10 and ulc std s627-00. Warmth, from the heart of j.A. Roby.
Page 2: Contents
2 contents warning.................................................................................................................3 notice .....................................................................................................................5 c reosote ..................................
Page 3: Warning
3 warning before installing, please take a few minutes to read this handbook. Keep this manual in a sure place and easily reachable for future references. If this appliance is not properly installed, it could cause fire damages to the property, injuries and death. To reduce fire hazards, follow inst...
Page 4
4 do not charge the appliance beyond the firebricks height. Ashes must be evacuated frequently, put in a steel container provided with a tight lid and be placed outside at once. You must never place other waste in this container. Very hot when lighted. Keep the children away. Can cause burns by cont...
Page 5: Notice
5 notice the tison and cuisiniere models were designed to operate safely with the doors closed and only when burning firewood. Any change, modification or unauthorized installation will automatically void the certification of the appliance, its guarantee, its homologation and the appliance might bec...
Page 6: Characteristics
6 characteristics option c uisiniere t ison combustible wood wood recommended surface 500pi 2 à 2000pi 2 (46.4m 2 à 185.8m 2 ) 500pi 2 à 2500pi 2 (46.4m 2 à 232.3m 2 ) capacity 95 000 btu/h 95 000 btu/h evacuation pipe diameter 6" (12cm) 6" (12cm) chimney minimal height 12pi (8,91m) 12pi (8,91m) ext...
Page 7: Installation
7 installation a good installation is extremely important for a safe and efficient use of your j.A. Roby inc. Appliance. If you doubt on the way to install the appliance correctly, seek for professional installation service. We suggest you to call masters installers. 1. Withdraw firebricks placed in...
Page 8
8 v ertical installation inside a masonry chimney the tison and cuisiniere models must be installed in accordance with the applicable local laws or the can/csa - b365 ulc s635, ulc s640 standards. For the chimney, follow the chimney manufacturer's instructions. E xterior vertical installation the ti...
Page 9
9 v ertical installation on a cathedral roof the tison and cuisiniere models must be installed in accordance with the applicable local laws or the can/csa - b365 ulc s635, ulc s640 standards. For the chimney, follow the chimney manufacturer's instructions..
Page 10
10 c ross installation the tison and cuisiniere models must be installed in accordance with the applicable local laws or the can/csa - b365 ulc s635, ulc s640 standards. For the chimney, follow the chimney manufacturer's instructions. V ertical installation the tison and cuisiniere models must be in...
Page 11: Clearances
11 clearances due to its reduced clearances, this appliance occupies a minimum space in the room where it is installed. No matter where you install it, the tison and models will perfectly complete your decoration by its originality and its heat. It requires only 12 inches of clearance to the back an...
Page 12: Seating
12 seating you must install a fireproof plate under the appliance, which must exceed it of 18 inches to the front, 8 inches to the sides and 8 inches at the back. *** use only non-combustible materials. Ex: (ceramics, marbles, granites).
Page 13: Lighting
13 lighting now that you have completed the installation of the appliance according to the recommendations, you are ready for the lighting! 1. Place papers and small wood in the appliance and fully open the air intake. 2. When the fire is well lit, gradually add bigger wood logs until an ember bed i...
Page 14: Fans And Thermodisc
14 fans and thermodisc the 115 volts fans must be screwed with the grids beneath the air corridor. The thermodisc box must be screwed on the back of the corridor. Connect the thermodisc into the electrical outlet. When the appliance is in function, the heat reaching a temperature of 120 o c activate...
Page 15
15 preventive measures and maintenance 1. We recommend to open the air intakes completely and to maintain an intense fire from 10 to 20 minutes per day. 2. Verify the accumulation of creosote every week that you use the appliance until you know at which frequency it must be cleaned (minimum once per...
Page 16: Interchangeable Parts List
16 interchangeable parts list bricks wool cap plates used to retain wool pipes glasses door's handle appliance's door fans cords brick retaining plate thermometer oven glass oven grill * t o order parts , please contact your authorized retailer ..
Page 17
17 installation of the firebricks 1. Fix the 7 screws with there bricks support to there designated space but do not tightened tem completely. There should be 3 screw on the back and 2 on each side of the stove. (see fig. 1). If it's not already done. 2. Install the bricks on the back and on the sid...
Page 18
18 fig. 2.
Page 19
19 using the removable handle to open the oven and the food warmer door 1- use the removable handles to open the oven door and food warmer door. 2- to insert the ends of the removable handle into the hooks, see detail d and e. 3- pull the removable handle to open the door. To close the door 1- use t...
Page 20: Limited Life Warranty
20 limited life warranty j.A. Roby inc. Warrants for life (following conditions written in the present manual) its high quality appliances against all manufacturing defectiveness. This warranty is only valid for the first buyer of the appliance with a purchase proof and the serial number of the appl...