1. DL manuals
  2. Jabiru
  3. Aircrafts
  4. J230-D
  5. Pilot Operating Handbook

Jabiru J230-D Pilot Operating Handbook

Summary of J230-D

  • Page 1

    Jabiru aircraft model j230-d pilot's operating handbook revision 0 this document must be carried in the aircraft at all times.

  • Page 2: Aircraft Particulars

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 2 aircraft particulars this aircraft must be operated in accordance with the approved data and limitations contained in this manual at all times. Registration marks: manufacturer: jabiru aircraft pty ltd ai...

  • Page 3: Amendment Record Sheet

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 3 amendment record sheet amendment date affected sections affected pages date inserted signature.

  • Page 4: Introduction

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 4 introduction this operating handbook has been prepared to comply with the requirements of astm f2245. This operating handbook includes the information required of the flight training supplement. The basic...

  • Page 5

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 5 warnings, cautions & notes definitions used in the poh such as warning, caution, note are employed in the following context: warning operating procedures, techniques, etc. Which if not followed correctly,...

  • Page 6: Three-View Drawing

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 6 three-view drawing figure 1-1 three view drawing of the j230-d note: all dimensions in millimetres.

  • Page 7

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 7 symbols, abbreviations and terminology general symbols and abbreviations a ampere agl above ground level amsl above mean sea level avgas aviation gasoline bhp brake horse power casa civil aviation safety ...

  • Page 8

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 8 mogas automotive fuel nm nautical mile, nautical miles oat outside air temperature pax passenger poh pilots operating handbook prop propeller psi pounds per square inch qty quantity qts quarts rh right ha...

  • Page 9

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 9 • v fe maximum flap extended speed: the highest speed permissible with wing flaps in a prescribed extended position. • v ne never exceed speed: the limiting airspeed that may not be exceeded at any time. ...

  • Page 10

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 10 weight and balance terminology • datum – an imaginary vertical plane from which all horizontal distances are measured for balance purposes. • station – a location along the aircraft fuselage usually give...

  • Page 11

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 11 use of metric/imperial units this poh uses the metric system as the basic system of measurement. Where common usage or available instrumentation refer to the imperial/us unit system, both units are quote...

  • Page 12

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 12 table of contents paragraph page 1 general information..............................................................................................14 1.1 manufacturers statement of compliance..............

  • Page 13

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 13 6.2 emergency procedures check lists............................................................ 37 6.2.1 engine failures ....................................................................................

  • Page 14

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 14 1 general information 1.1 manufacturers statement of compliance insert copy of manufacturers statement of compliance.

  • Page 15

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 15 1.1 manufacturer details jabiru aircraft p/l po box 5186 bundaberg west, qld 4670 phone: 07 4155 1778 fax: 07 4155 2669 email: info@jabiru.Net.Au street address: jabiru aircraft airport drive, hinkler ai...

  • Page 16

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 16 2 airplane and systems descriptions 2.1 engine manufacturer: jabiru aircraft pty ltd model: 3300a 2.2 propeller manufacturer: jabiru aircraft pty ltd model: c000262-d60p53 type: wooden, fixed pitch numbe...

  • Page 17

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 17 arm for baggage zone “a” 670-mm aft of datum arm for baggage zone “b” 1034-mm aft of datum main fuel station 451-mm aft of datum header tank fuel station (4l) 1520-mm aft of datum refer to section 4 for ...

  • Page 18

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 18 system instruments and/or equipment vfr day remarks ice & rain protection engine alternate air induction system 1 navigation & pitot static altimeter 1 airspeed indicator 1 magnetic compass 1 time piece ...

  • Page 19

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 19 3 operating limitations 3.1 kinds of operation the standard j230-d, as detailed within this poh, is approved for day vfr operations only. An optional package is available to allow the aircraft to conduct...

  • Page 20

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 20 3.6 prohibited manoeuvres manoeuvres in the course of normal flying are approved. Stalls may be carried out at bank angles of up to 60°. All aerobatic manoeuvres including spins are prohibited. 3.7 power...

  • Page 21

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 21 3.7.2 lubricating oil oil capacity 3.4 litres. Refer to section 8.2 for additional details. 3.8 powerplant instrument markings instrument red line minimum limit green arc normal operating red arc/line ma...

  • Page 22

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 22 • minimum system voltage (bottom of green arc) • maximum system voltage (top of green arc) note the display of these limitations are required for the aircraft’s certification, and it does not comply with...

  • Page 23

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 23 no smoking p/no. 5a035a0d fit to instrument panel. No intentional spins. P/no. 5a072a0d fit to instrument panel owners manual p/no 5a075a0d fitted to inside of rh door above the door pocket. Door open lh...

  • Page 24

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 24 fit inside wing root immediately aft of windows through to electric fuel gauge senders compass card p/no. 5123024 fit in compass card holder attached to compass. Baggage p/no. 5a037a0d fit to right side ...

  • Page 25

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 25 3.12.2 cockpit controls trim position p/no. 5a031a0d (1 off) fit to centre console beside of elevator fwd stop, between trim levers. Brake on p/no. 5a031b0d fit to centre console beside brake lever, arro...

  • Page 26

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 26 attach to left side of nose wheel spat. Main wheel inflation. P/no. 5a061a0d attach to outsides of main wheel spats engine oil p/no. 5a008a0d attach to inner face of door in top engine cowl. Dipstick ins...

  • Page 27

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 27 4 weight and balance information 4.1 cg range forward limit: 99-mm (3.9”, 10%mac) aft of datum up to & including 600 kg (1320lb) aft limit 277-mm (10.9”, 28 %) aft of datum at all weights datum wing lead...

  • Page 28

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 28 4.3 aircraft weight data insert page 6.2 here.

  • Page 29

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 29 insert page 6.3 here.

  • Page 30

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 30 insert equipment list here..

  • Page 31

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 31 4.4 trim sheets the trim sheets included below, when used correctly, provide a means of calculating the aircraft weight and cg position without manual calculations. An example of using the sheet is inclu...

  • Page 32

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 32 4.4.2 calculating the operating cg locations 2-1. Take the calculated empty weight trim index and mark it’s position on the aircraft index units ladder at the top of the sheet. 2-2 draw a vertical line d...

  • Page 33

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 33.

  • Page 34

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 34.

  • Page 35

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 35 5 performance 5.1 take off and landing distances take-off distance 350 m landing distance 300 m note: all distances quoted are for an aircraft at gross weight, operating from a paved runway surface at se...

  • Page 36

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 36 5.4 airspeed indicator system calibration conditions: power: as required for level flight or maximum rated rpm as appropriate. Kcas kias flaps up flaps take-off flaps landing 42 - - 40 45 - 43 43 47 45 4...

  • Page 37

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 37 6 emergency procedures this section describes the procedures to be adopted in the event of an emergency or abnormal situation occurring in the j230-d aircraft. The procedures are arranged in the sequence...

  • Page 38

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 38 engine failure during flight 1. Airspeed………………………………………….65 kias*. 2. Carburettor heat……………………………….. On 3. Fuel pump………………………………………. On 4. Fuel shutoff valve……………………………… confirm on 5. Fuel quantity………………...

  • Page 39

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 39 6.2.3 forced landings emergency landing without engine power 1. Airspeed…………………………………….... 65 kias 2. Ignition………………………………………… off 3. Fuel shutoff valve…………………………… off 4. Fuel pump……………………………………. Off 5. ...

  • Page 40

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 40 engine fire in flight 1. Throttle....................................................... Close 2. Fuel valve .................................................. Off 3. Fuel pump..............................

  • Page 41

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 41 6.2.5 carburettor icing if carburettor icing is suspected: 1. Throttle .......................................................Full 2. Carb heat...............................................Full on note ...

  • Page 42

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 42 alternator failure is indicated by the illumination of the “chg fail” light on the instrument panel. While the jabiru engine does not require external power to run, power consumption by the radio, transp...

  • Page 43

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 43 7 normal procedures 7.1 general this section describes the procedures to be adopted for normal operations of the j230-d aircraft. The procedures are arranged in the sequence considered to be the most des...

  • Page 44

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 44 7.5 preflight inspection before flight, a careful visual inspection is to be carried out to ensure that the aircraft and its systems are serviceable. The following figure is to be used in conjunction wit...

  • Page 45

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 45 aileron and elevator cables & fasteners... Check rudder and nose wheel steerage linkage check rudder centring springs........................... Check controls (all) ........................................

  • Page 46

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 46 nose wheel .............................................Check condition & pressure. 10. “pulling through” the engine before the first flight of the day the engine must be “pulled through” by hand. This i...

  • Page 47

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 47 7.6 normal procedures check lists 7.6.1 before starting engine pre flight inspection ................................. Completed passenger briefing .................................. Completed harnesses ...

  • Page 48

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 48 switches...................................................Selected as required circuit breakers........................................Check controls....................................................F...

  • Page 49

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 49 7.6.10 baulked landing power ...................................................... Full throttle carburettor heat ..................................... Cold wing flaps .....................................

  • Page 50

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 50 7.6.14 engine management – ground running the 3300a engine fitted to the j230-d is cooled by air flowing over the engine and oil cooler. During ground running care must be taken to ensure that there is a...

  • Page 51

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 51 8 aircraft ground handling and servicing 8.1 fuel • avgas 100ll • avgas 100/130 • mogas with minimum octane rating of 95 ron 1 may be used. • do not use fuel additives such as octane boosters. Note as th...

  • Page 52

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 52 8.3 brakes the brakes of the j230-d use automotive brake fluid. Refer to the j230 technical manual for details of appropriate brake fluid specifications. Warning: the jabiru uses automotive brake fluid (...

  • Page 53

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 53 9 climatic restrictions maximum ambient operating temperature ................38°c flight into known icing conditions................................Prohibited.

  • Page 54

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 54 10 supplements this section consists of a series of supplements, each being self contained and providing details and procedures associated with the fitment of optional and special purpose equipment. Each...

  • Page 55

    Jabiru aircraft pilot operating handbook model j230-d jp-fm-09 revision: 0 12 april 2007 page 55 10.1 log of supplements – jabiru aircraft supplements applicable to aircraft serial number j230-d ______________ install doc. No. Title date.