1 the ultimate p p r r e e m m i i e e r r s s e e r r i i e e s s version: jan.13 owner’s manual: premier model: jpg700 cart style gas grill jackson grills inc. #106-2480 mt. Lehman rd. Abbotsford, bc v4x 2n3 e-mail: support@jacksongrills.Com web: www.Jacksongrills.Com tel: 1 (888) 287-3333 fax: 1 ...
2 table of contents table of contents: 2 safety warnings: 3 certification & testing; 4 unpacking your grill; parts checklist 4 special message to owners: 5 owner registration: 5 tools required for assembly: 6 assembling & preparing your grill: 6-8 propane gas connection: 9-10 leak testing: 11 instal...
3 !Safety warnings! Safety first: please read and understand all warnings and precautions prior to operating your gas grill. 1 this grill is for outside use only, and shall not be used in any building, garage, enclosed area or vehicle. 2 this grill is set up from the factory for use with propane gas...
4 certification & testing this appliance has been tested by labtest certification (lc) and has been tested to ansi z21.58a-1198 & cga 16a-m98, and certified for canada and the usa. Note: the use and installation of this product must conform to local codes. In the absence of local codes, use the nati...
5 special message for our customers all of us at jackson thank you, for choosing a jackson grill! This appliance was designed, engineered, and built with quality components and we are confident that it will provide you with years of excellent operation. Please take the time to read the entire manual...
6 tools required for assembly*: *please use the proper tools to simplify installation and prevent personal injury or damage to your grill. A) installer supplied tools: 1 x medium phillips screwdriver 1 x 5/16” wrench (or 8mm) 2 x ¾’ wrench (or 19mm) assembling & preparing your grill: b) install flam...
7 d) side burner/side shelf installation: 1. Carefully remove the rotisserie kit parts and the side burner assembly from the packaging. 2. Loosen two 5/16” nuts on lh side of pedestal and turn out two full revolutions. (fig. 4) 3. Remove 5 x phillips screws (4 on the side panel and one on the side o...
8 7. Next, bend the flex fuel inlet line into a gentle “s” and thread it onto the fuel manifold under the side burner. Tighten using 2 x ¾” (or 2 x 19mm) wrenches (fig. 9; note: sealant not required at this connection). E) rotisserie kit installation: 1. Slide the rotisserie motor onto the motor mou...
9 propane gas connection: fuel source: this is a propane (or lp = liquid propane) configured grill. Do not attempt to use a natural gas supply unless the grill has been converted to natural gas use. hose & regulator: use only the propane hose and regulator supplied with this grill. installatio...
10 propane cylinder storage: 1. Disconnected propane cylinders must have a dust cap installed for storage purposes. 2. Store all propane cylinders outdoors in a well-ventilated area. 3. Do not store cylinders in direct sunlight or near a source of heat or combustion. 4. Propane cylinders must be r...
11 leak testing: 1. General: although all gas connections on the grill are leak tested at the factory prior to shipment, a complete gas tightness check must be performed at the installation site due to possible mishandling in shipment, or excessive pressure unknowingly being applied to the unit. Per...
12 introducing the island grillstone™ check out this fabulous new way to enhance your cooking! Quarried from natural volcanic rock and then cut into slabs, it is the ideal accessory for grilling veggies, seafood, or marinated meats. Drops right onto your grill! # grillstonesq (14” x 14”) installer f...
13 grill lighting instructions: 1. Before lighting: a) always inspect the gas supply hose before turning the gas “on”. If there is evidence of cuts, wear, or abrasion, it must be replaced before use. Use only a manufacturer approved replacement hose. B) check all gas connections for leaks before eac...
14 grill, rotisserie & side burner cooking: total gas consumption: total gas consumption per hour, per burner: model jpg700: main burners: 15,000 btu/hr. X 4 = 60,000 btu/hr. Rear burners: 15,000 btu/hr. X 1 = 15,000 btu/hr. Side burner: 15,000 btu/hr. X 1 = 15,000 btu/hr. Total potential consumptio...
15 2. Using the grilling surface (cook grids): a) grilling requires high heat for searing and proper browning. B) most foods are cooked at the “hi” heat setting for the entire cooking duration. C) when grilling large pieces of meat or poultry, it may be necessary to turn the heat to a lower setting,...
16 cleaning and maintenance: caution: keep the grill area clear and free from combustible materials, gasoline and other flammable vapors and liquids ensure that the grill is completely cold before performing any cleaning and maintenance. Burning off deposits and soiling by turning the main burners o...
17 both the grease pan and the cup must be cleaned on a regular basis, for the system to work as designed, and prevent grease fires. A small amount of sand can be added to the grease pan and cup for absorbing accumulated grease. 3. Cooking grid cleaning: if the grids are heavily soiled, turn your ma...
18 specks of grease can adhere to the surfaces of the stainless steel and bake on; this will give the appearance of rust. Use an abrasive pad with stainless steel cleaner to remove. Sand heavy scratches lightly with 600 grit wet and dry sandpaper. Always rinse with clean hot water. Use a spray polis...
19 trouble shooting: a) spider and insect warning: spiders and insects can nest in the burners during storage: these nests can cause fires inside burners or beneath the grill. This is potentially hazardous: always remove and clean the burners immediately after bringing your grill out of storage, and...
20 exploded view: jpg700 cart 1 2 3 4 5 6 7 8 12 2 14 18 50 26 28 15 35 25 34 33 47a 41 40 42 43 56a 56b 49 38 52 54 42 37 44 39 41 32 46 53 51 55 36 20 19 22 21 23 27 31 45 48 47b.
21 parts list: jpg700 cart loc. Description part# (qty.) loc. Description part# (qty.) 01 hood jh-004 32 pedestal side right jc-92 02 warming shelf rail jh-102 (2) 33 pedestal side left jc-93 03 hood handle jh-92 34 pedestal back panel jc-94 04 thermometer jt-04 35 pedestal heat shield jc-95 05 inne...
22 limited lifetime warranty: model no: jpg700 jackson grills inc. Warrants the following materials and workmanship to be free of defects for as long as you own the grill subject to the conditions below: first 5 years: (from date of purchase); jackson grills will replace or repair (at our option), a...
